| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 63 |
| Brake pipe excessively corroded | 41 |
| Headlamp aim out of alignment | 38 |
| Offside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 12 |
| Registration plate lamp issues | 9 |
| Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 8 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 8 |
| Brakes imbalanced across an axle | 7 |
| Centre Stop lamp not working |1.2.1b| | 7 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 7 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 7 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 7 |
| Offside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 7 |
| Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 6 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 6 |
| Nearside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 6 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 6 |
| Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 6 |
| Parking brake: efficiency below requirements |3.7.B.7| | 5 |
| Central Stop lamp(s) not working (4.3.1 (a) (ii)) | 5 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 4 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 4 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 4 |
| Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 4 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 4 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 3 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 3 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 3 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 3 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 2 |
| Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 2 |
| Rear parking brake recording little or no effort | 2 |
| Front brake disc in such a condition that it is seriously weakened | 2 |
| Offside Front Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 2 |
| Upper Stop lamp not working |1.2.1b| | 2 |
| Central Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 2 |
| Anti-lock braking system warning lamp indicates an ABS fault | 2 |
| Windscreen washer not working | 2 |
| Offside Front Anti-roll bar ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 2 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Offside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 2 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 2 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 2 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 2 |
| Exhaust carbon monoxide content at idle exceeds default limits (8.2.1.2 (b)) | 2 |
| Nearside Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 2 |
| Offside Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 2 |
| Electronic power steering warning lamp indicates a system malfunction (2.6 (a)) | 2 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 2 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 2 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Horn not working (7.7 (a)) | 2 |
| Offside Front Lower Suspension arm ball joint likely to become detached (5.3.4 (a) (ii)) | 2 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 2 |
| Exhaust silencer likely to become detached |8.1.1 |b| |ii|| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Emissions not tested |7.3.A.1| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Front Macpherson strut has excessive movement at the upper attachment |2.5.A.1c| | 1 |
| Exhaust system insecure |6.1.2 |a|| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Anti-roll bar linkage severely distorted |2.4.G.1| | 1 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Outer Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Outer Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 1 |
| Front Exhaust system insecure mounting broken |6.1.2 |a|| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Front Exhaust system not adequately supported |7.1.1| | 1 |
| Centre Upper Stop lamp not working |1.2.1b| | 1 |
| Offside Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Nearside Inner Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Central Stop lamp not working |1.2.1b| | 1 |
| Nearside Headlamp insecure |1.7.3| | 1 |
| Offside Front Anti-roll bar missing |2.4.G.1| | 1 |
| Rear Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Steering rack has excessive free play detected at the steering wheel |steering rack fitted| |2.3 |a| |i|| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Centre Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Suspension component ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Front front brake juddering severely |3.7.A.2b| | 1 |
| obligatory indirect vision device seriously obscured affecting the rear view bears on parcel shelf |8.1.2a| | 1 |
| Nearside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
| Rear brake binding | 1 |
| Nearside Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Stop lamp not working |1.2.1b| | 1 |
| Offside Front front brake juddering severely |3.7.A.2b| | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt drop link |2.4.G.2| | 1 |
| Horn not working |1.6.2a| | 1 |
| Mechanical brake component has restricted free movement | 1 |
| Nearside Rear Seat belt cut sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Front Inner Brake disc significantly and obviously worn N/S AND O/S |1.1.14 |a| |i|| | 1 |
| Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Front brake excessively fluctuating | 1 |
| Offside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Nearside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 1 |
| Offside Front Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Headlamp aim does not move downwards when dipped |British American headlamp| |1.8.C.4| | 1 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Nearside Front Steering system excessively rough |2.2.D.1| | 1 |
| front brake juddering severely |3.7.A.2b| | 1 |
| Windscreen wiper blade insecure | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a ball joint (2.4.G.2) | 1 |
| Offside Front Service brake grabbing severely (1.2.1 (c)) | 1 |
| Brake pedal has insufficient reserve travel (1.1.2 (a)) | 1 |
| Front Exhaust system insecure mounting (6.1.2 (a)) | 1 |
| Nearside Front Seat belt buckle not functioning as intended (7.1.2 (d)) | 1 |
| Exhaust system insecure Rear silencer mounting bracket broken. (6.1.2 (a)) | 1 |
| Exhaust system insecure (6.1.2 (a)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (bulb incorrectly fitted) (4.1.2 (c)) | 1 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt outer (6.1.7 (g) (ii)) | 1 |
| Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt outer (6.1.7 (g) (ii)) | 1 |
| Offside Front Anti-roll bar attachment bracket/mounting insecure (5.3.3 (a) (i)) | 1 |
| Nearside Rear Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 1 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 1 |
| Rear Parking brake efficiency below requirements nearside and offside (1.4.2 (a) (i)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Front Inner Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Headlamp lens seriously defective (4.1.1 (b) (ii)) | 1 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Nearside Front Headlamp aim not tested (4.1.2 (b)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Outer Prop shaft joint constant velocity boot no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Front Exhaust system insecure (6.1.2 (a)) | 1 |
| Nearside Front Inner Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Inner Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Registration plate issues | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Front Shock absorbers has a serious fluid leak | 1 |
| Nearside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Fuel pipe leaking excessively or a risk of fire (6.1.3 (b) (ii)) | 1 |
| Offside Parking brake inoperative on one side low (1.4.1 (a)) | 1 |
| Offside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Suspension component mounting prescribed area excessively corroded significantly reducing structural strength nearside and offside inner sills (5.3.6 (a) (i)) | 1 |
| Suspension component mounting prescribed area excessively corroded significantly reducing structural strength nearside and offside front jacking point area (5.3.6 (a) (i)) | 1 |
| Offside Front Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength subframe mounting inner sill (5.3.6 (a) (i)) | 1 |
| Offside Front Lower Suspension arm attachment bracket/mounting corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Parking brake lever defective so that it cannot be satisfactorily operated release button sticking in. (1.1.6 (d)) | 1 |
| Exhaust has a major leak of exhaust gases at rear, rear section of exhaust missing. emissions just past test on lamda. (6.1.2 (a)) | 1 |
| Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Nearside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting jacking point (6.2.2 (d) (i)) | 1 |
| Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting jacking point (6.2.2 (d) (i)) | 1 |
| Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced cross member (6.1.1 (c) (i)) | 1 |
| Offside Rear Seat belt flexible stalk stretched or damaged likely to lead to failure under load webbing seriously damaged (7.1.2 (b) (ii)) | 1 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Exhaust emissions - engine idle speed too high (8.2.1.2 (e)) | 1 |
| Front Bumper insecure (6.1.4 (a) (i)) | 1 |
| Front Bumper damaged and likely to cause injury when grazed or contacted (6.1.4 (a) (i)) | 1 |
| Nearside Front Suspension arm corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Offside Front Suspension arm has an unsafe modification has been welded (5.3.3 (c) (i)) | 1 |
| Offside Front Lower Suspension component ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Lower Suspension arm ball joint likely to become detached (5.3.4 (a) (ii)) | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Headlamp aim unable to be tested (4.1.2 (b)) | 1 |
| Nearside Rear Lower Coil spring mounting damaged and seriously weakened (5.3.1 (b) (i)) | 1 |
| Offside Rear Lower Coil spring mounting damaged and seriously weakened (5.3.1 (b) (i)) | 1 |
| Nearside Front Headlamp aim unable to be tested (4.1.2 (b)) | 1 |
| Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength landing panel at anti roll bar (5.3.6 (a) (i)) | 1 |
| Nearside Front Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill at floor (5.3.6 (a) (i)) | 1 |
| Offside Front Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill at floor (5.3.6 (a) (i)) | 1 |
| Offside Rear Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Brake pipe at imminent risk of failure or fracture (1.1.11 (a)) | 1 |
| Offside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Electronic power steering not working (2.6 (c)) | 1 |
| Front Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Emissions unable to be completed (8.2.1.2 (d)) | 1 |
| Central Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
| Offside Front Outer Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Headlamp lens seriously defective (4.1.1 (b) (ii)) | 1 |
| Nearside Front Brake disc contaminated rusty and pitted (1.1.14 (b)) | 1 |
| Nearside Front Suspension arm pin or bush excessively worn lower arm rear bush (5.3.4 (a) (i)) | 1 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Power steering inoperative (2.1.5 (c) (i)) | 1 |
| Nearside Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced floor (6.1.1 (c) (i)) | 1 |
| Offside Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced floor (6.1.1 (c) (i)) | 1 |
| Offside Front Lower Suspension component mounting prescribed area is corroded to the extent that control of the vehicle is likely to be adversely affected inner body (5.3.6 (a) (ii)) | 1 |
| Nearside Front Suspension arm pin or bush excessively worn rear bush (5.3.4 (a) (i)) | 1 |
| Offside Body component damaged and likely to cause injury mirror backing (6.2.1 (a) (i)) | 1 |
| Offside Headlamp has a product on the lens so that the light output is severely reduced (4.1.4 (b)) | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits needs full exhaust system (8.2.1.2 (c)) | 1 |
| Nearside Rear Outer Seat belt anchorage prescribed area strength or continuity significantly reduced sill (7.1.1 (a) (i)) | 1 |
| Headlamp aim projected beam image is obviously incorrect both (4.1.2 (c)) | 1 |
| Nearside Front Anti-roll bar ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Front Suspension arm attachment bracket/mounting corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Offside Front Suspension arm attachment bracket/mounting corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength anti roll bar mounting (5.3.6 (a) (i)) | 1 |
| Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength FLOOR BOTH SIDES (5.3.6 (a) (i)) | 1 |
| Front Anti-roll bar missing (5.3.3 (a) (ii)) | 1 |
| Offside Front Subframe mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Front Subframe mounting prescribed area excessively corroded significantly reducing structural strength inner sill (5.3.6 (a) (i)) | 1 |
| Offside Front Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 1 |