| Most common failures | No# failures |
|---|
| Registration plate lamp issues | 28 |
| Parking brake: efficiency below requirements |3.7.B.7| | 21 |
| Headlamp aim out of alignment | 17 |
| Rear parking brake recording little or no effort | 17 |
| Brake pipe excessively corroded | 16 |
| Windscreen wiper does not clear the windscreen effectively | 13 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 12 |
| Registration plate issues | 10 |
| Rear brake binding | 6 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 6 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 6 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 5 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 5 |
| Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 5 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 5 |
| Offside Side repeater not working |1.4.A.2c| | 5 |
| Nearside Stop lamp not working |1.2.1b| | 4 |
| Nearside Side repeater not working |1.4.A.2c| | 4 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 4 |
| Offside Front Side repeater not working |1.4.A.2c| | 4 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 4 |
| Offside Rear passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 4 |
| Offside Stop lamp not working |1.2.1b| | 4 |
| Parking brake lever has no reserve travel |3.1.6b| | 4 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 4 |
| Centre Stop lamp not working |1.2.1b| | 4 |
| Power steering component|s| leaking |2.3.3b| | 3 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 3 |
| Offside Rear Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 3 |
| Rear Rear fog lamp not working |1.3.2b| | 3 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Battery insecure |1.9.1| | 3 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 3 |
| Windscreen has damage | 3 |
| Brake pedal creeps down when held under pressure |3.3.B.1a| | 3 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Nearside Rear Stop lamp not working |1.2.1b| | 2 |
| Offside Rear Stop lamp not working |1.2.1b| | 2 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Rear Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 2 |
| Rear brake application uneven | 2 |
| rear brakes release unevenly |3.7.B.4| | 2 |
| Brakes imbalanced across an axle | 2 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Service brake: efficiency below requirements |3.7.C.1a| | 2 |
| Nearside Front Side repeater not working |1.4.A.2c| | 2 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 2 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Brake pedal creeps down while the pedal is held under pressure |3.3.B.1a| | 2 |
| Offside Rear Coil spring mounting corroded and seriously weakened |2.4.C.3c| | 2 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 2 |
| Offside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 2 |
| Brake pedal spongy |3.3.B.1b| | 2 |
| Service brake: efficiency below requirements |3.7.B.7| | 2 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 2 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 2 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 2 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength CHASSIS LEG (5.3.6 (a) (i)) | 2 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 2 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Offside Outer Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 2 |
| Offside Steering rack gaiter split |2.2.D.2d| | 1 |
| Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded at D bush MARKED IN YELLOW |2.4.A.3| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Power steering component|s| leaking Rack |2.3.3b| | 1 |
| Nearside Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Nearside Rear Seat belt not functioning as intended (7.1.2 (c)) | 1 |
| Nearside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Rear Anti-roll bar attachment bracket/mounting damaged and seriously weakened (5.3.3 (b) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Shock mount (5.3.6 (a) (i)) | 1 |
| Nearside Rear Seat belt not functioning as intended |7.1.2 |c|| | 1 |
| Nearside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Nearside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Exhaust has a part missing |7.1.1a| | 1 |
| Exhaust tailpipe not capable of allowing the emission probe to be inserted |7.4.B.1| | 1 |
| Nearside Front Upper Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Upper Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Offside Rear Lower Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 1 |
| Offside Front brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Front Anti-roll bar linkage fractured |2.4.G.1| | 1 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Offside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Rear Rear reflector missing |1.5.1a| | 1 |
| Nearside Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Upper Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Upper Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Upper Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Rear Parking brake not fitted on at least two wheels |3.1.1| | 1 |
| Offside Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Rear reflector missing |1.5.1a| | 1 |
| Offside Rear reflector missing |1.5.1a| | 1 |
| Fuel pipe leaking |7.2.3| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Rear brake disc in such a condition that it is seriously weakened | 1 |
| Offside Front Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Trailer electrical socket insecure |1.9.3a| | 1 |
| Offside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Brake lever has restricted free movement |3.5.1k| | 1 |
| Nearside Rear Brake lever has restricted free movement |3.5.1k| | 1 |
| Nearside Front Upper Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Upper Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Rear Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Nearside Front Anti-roll bar attachment bracket/mounting cracked |2.4.G.1| | 1 |
| Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings mid chassis point |6.1.B.2| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Front Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Nearside Rear coil spring fractured |2.4.C.1a| | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Windscreen wiper blade insecure | 1 |
| Steering system excessively tight |2.2.D.1| | 1 |
| Rear Upper Trailing arm attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Front brake disc in such a condition that it is seriously weakened | 1 |
| Offside front brake juddering severely |3.7.A.2b| | 1 |
| Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Front Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Nearside Rear Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
| Nearside Front brake disc has restricted free movement |3.5.1j| | 1 |
| Front brake application uneven | 1 |
| Nearside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Offside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Front Drive shaft uj which forms part of the suspension has excessive play in a universal joint |2.4.G.4b| | 1 |
| Offside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front front brake juddering severely |3.7.A.2b| | 1 |
| Offside Front front brake juddering severely |3.7.A.2b| | 1 |
| Offside Rear Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
| Rear Brake pipe leaking |3.6.A.1| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| All position lamps not working |1.1.A.3b| | 1 |
| Nearside Front Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Offside Front Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Offside Front Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Rear Leaf spring cracked |2.4.B.1a| | 1 |
| Offside Rear Leaf spring cracked |2.4.B.1a| | 1 |
| Offside Front Intermediate drop arm insecure |2.2.B.1a| | 1 |
| Rear Exhaust has a part missing |7.1.1a| | 1 |
| Offside Towbar retaining device missing |6.6.3a| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Offside Rear reflector excessively damaged so that its function is impaired |1.5.1c| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Centre Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear brake disc excessively scored |3.5.1h| | 1 |
| Nearside Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Rear fog lamp switch faulty |1.3.1a| | 1 |
| Rear Exhaust system insecure SUPPORT (6.1.2 (a)) | 1 |
| Fluid leaking continuously posing a serious risk to road safety DIESAL LINES REAR (8.4.1 (a) (ii)) | 1 |
| Front Prop shaft bearing excessively worn REAR JOINT (6.1.7 (b) (i)) | 1 |
| Nearside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Rear Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength CHASSIS LEG (5.3.6 (a) (i)) | 1 |
| Nearside Front Shock absorbers has negligible damping effect (5.3.2 (d)) | 1 |
| Offside Front Shock absorbers has negligible damping effect (5.3.2 (d)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Rear Vehicle structure is so weakened by corrosion within 30cm of a towbar mounting, the towbar is likely to become detached CHASSIS LEG (6.1.6 (i) (ii)) | 1 |
| Nearside Rear Anti-roll bar attachment bracket/mounting insecure (5.3.3 (a) (i)) | 1 |
| Nearside Front Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Emissions not tested due to badly holed rear section |7.4.B.1| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded chassis |2.4.A.3| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded chassis |2.4.A.3| | 1 |
| Nearside Rear Vehicle structure excessively corroded within 30cm of towbar mounting chassis |6.6.6| | 1 |
| Offside Rear Vehicle structure excessively corroded within 30cm of towbar mounting chassis |6.6.6| | 1 |
| Brake lever has insufficient reserve travel Parking Brake |1.1.2 |a|| | 1 |
| Rear Suspension rod corroded and seriously weakened |5.3.3 |b| |i|| | 1 |
| Offside Rear Anti-roll bar attachment bracket/mounting corroded and seriously weakened |5.3.3 |b| |i|| | 1 |
| Offside Front Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting |6.2.2 |d| |i|| | 1 |
| Offside Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Offside Front Front position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Headlamp insecure |1.7.3| | 1 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Rear Anti-roll bar attachment bracket/mounting corroded and its strength is seriously reduced |2.4.G.1| | 1 |
| Nearside Rear Anti-roll bar attachment bracket/mounting corroded and its strength is seriously reduced |2.4.G.1| | 1 |
| Emissions not tested |7.4.B.1| | 1 |
| Trailer electrical socket |13 pin| not operating the trailer lamps as intended |1.9.4| | 1 |
| Nearside Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
| Offside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Front position lamp|s| has less than 50% of the light sources illuminating |1.1.A.3b| | 1 |
| Offside Front position lamp|s| has less than 50% of the light sources illuminating |1.1.A.3b| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Offside Rear Brake cable has restricted free movement |3.5.1k| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |