| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 44 |
| Windscreen wiper does not clear the windscreen effectively | 39 |
| Brake pipe excessively corroded | 19 |
| Registration plate lamp issues | 13 |
| Horn not working (7.7 (a)) | 13 |
| Offside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 11 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 10 |
| Offside Stop lamp not working |1.2.1b| | 9 |
| Offside Front coil spring broken |2.4.C.1a| | 9 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 9 |
| Nearside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 9 |
| Fuel cap/sealing device ineffective (6.1.3 (b) (i)) | 9 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 8 |
| Horn not working |1.6.2a| | 8 |
| Registration plate issues | 8 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 7 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 7 |
| Nearside Stop lamp not working |1.2.1b| | 7 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 7 |
| Windscreen washer not working | 6 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 6 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 6 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 5 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 5 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 5 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 5 |
| Rear brake binding | 4 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 4 |
| Rear Exhaust system not adequately supported |7.1.1| | 4 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 4 |
| Anti-lock braking system warning lamp indicates an ABS fault | 4 |
| Offside Front Coil spring fractured or broken |5.3.1 |b| |i|| | 4 |
| Nearside Rear Stop lamp not working |1.2.1b| | 3 |
| Nearside Front Coil spring fractured or broken |5.3.1 |b| |i|| | 3 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 3 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 3 |
| Fuel cap/sealing device sealing washer deteriorated |7.2.4c| | 3 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 3 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 3 |
| Fuel cap/sealing device ineffective |6.1.3 |b| |i|| | 3 |
| Brakes imbalanced across an axle | 3 |
| Front brake disc in such a condition that it is seriously weakened | 3 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Rear brake application uneven | 2 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Nearside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 2 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Offside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 2 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 2 |
| Exhaust system not adequately supported |7.1.1| | 2 |
| Offside Rear Stop lamp not working |1.2.1b| | 2 |
| Offside Side repeater incorrect colour (4.4.3 (a)) | 2 |
| Parking brake: efficiency below requirements |3.7.B.7| | 2 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Central Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Horn not working (7.7 (a) (ii)) | 2 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 2 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Parking brake lever has no reserve travel |3.1.6b| | 2 |
| Offside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 2 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Offside front brake binding |3.7.B.1| | 1 |
| Brake performance unable to be tested (1.2.1 (g)) | 1 |
| Nearside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Centre Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Rear Upper Fuel cap/sealing device component leaking ineffective seal needs replacing (6.1.3 (b) (i)) | 1 |
| Nearside Front Shock absorbers has a serious fluid leak | 1 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Side repeater obviously incorrectly positioned (4.4.3 (a)) | 1 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Emissions not tested (8.2.1.2 (d)) | 1 |
| Central Front Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen too high (3.5 (a)) | 1 |
| Offside Rear Fuel cap/sealing device sealing washer deteriorated |7.2.4c| | 1 |
| Suspension arm corroded and seriously weakened Both fronts (5.3.3 (b) (i)) | 1 |
| Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
| Nearside Front Road wheel fixing missing (5.2.1 (a) (i)) | 1 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Nearside Front Headlamp insecure (4.1.1 (c)) | 1 |
| Rear Mechanical brake component has restricted free movement | 1 |
| Front Lower Engine mounting damaged or deteriorated resulting in excessive movement (6.1.8 (a) (i)) | 1 |
| Headlamp aim not tested |1.8.A.1c| | 1 |
| Exhaust system insecure |6.1.2 |a|| | 1 |
| Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Offside Front Shock absorbers has a serious fluid leak | 1 |
| Offside Front Drivers airbag missing (7.1.5 (a)) | 1 |
| Nearside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Horn not working |7.7 |a| |ii|| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Fuel cap/sealing device ineffective Fuel filler cap seal broken (6.1.3 (b) (i)) | 1 |
| Offside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Offside Rear Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
| Nearside Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Offside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Lower Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Fuel cap/sealing device component leaking (6.1.3 (b) (i)) | 1 |
| Offside Front Suspension arm pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
| Front passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn rear cotton reel bush |5.3.4 |a| |i|| | 1 |
| Offside Front Lower Suspension arm pin or bush excessively worn rear cotton reel bush |5.3.4 |a| |i|| | 1 |
| Offside Front Suspension arm pin or bush excessively worn lower wishbone bush broken,n/s rusty (5.3.4 (a) (i)) | 1 |
| Fuel cap/sealing device ineffective seal broken |6.1.3 |b| |i|| | 1 |
| Nearside Macpherson strut pin or bush excessively worn top mount (5.3.4 (a) (i)) | 1 |
| Offside Front Macpherson strut pin or bush excessively worn top mount (5.3.4 (a) (i)) | 1 |
| Brake pressure/vacuum build up too slow (1.1.3 (b)) | 1 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Emissions unable to be completed (8.2.1.2 (d)) | 1 |
| Nearside Rear Road wheel badly damaged |4.2.A.1a| | 1 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Headlamp aim not tested |1.8.A.1c| | 1 |
| Central Engine mounting damaged or deteriorated resulting in excessive movement gear box stabiliser (6.1.8 (a) (i)) | 1 |
| Offside Front Lower Suspension arm corroded and seriously weakened foremost mounting (5.3.3 (b) (i)) | 1 |
| Offside Rear Inner Road wheel badly distorted (5.2.2 (c) (i)) | 1 |
| Nearside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn wishbone arm excess play in ball joint (5.3.4 (a) (i)) | 1 |
| Fuel cap/sealing device ineffective seal split |6.1.3 |b| |i|| | 1 |
| Central Upper Stop lamp not working |1.2.1b| | 1 |
| Offside Side repeater incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Side repeater incorrect colour (4.4.3 (a)) | 1 |
| Offside Front Side repeater incorrect colour (4.4.3 (a)) | 1 |
| Nearside Rear Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Offside Front Lower Suspension arm pin or bush excessively worn arm rear bush and forward bush worn (5.3.4 (a) (i)) | 1 |
| Offside Front Headlamp light intensity severely reduced |4.1.4 |a|| | 1 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Front Windscreen wiper blade missing (3.4 (b) (ii)) | 1 |
| Nearside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Brake hydraulic reservoir insecurely mounted |3.6.A.2a| | 1 |
| Nearside Front Inner Suspension arm pin or bush excessively worn bushes (5.3.4 (a) (i)) | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Nearside Front Track rod end ball joint worn to the extent there is a serious risk of detachment Securing nut loose likely to become detatched (2.1.3 (b) (ii)) | 1 |
| Fuel cap/sealing device sealing washer torn |7.2.4c| | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
| Central Rear Inner Engine mounting damaged or deteriorated resulting in excessive movement (6.1.8 (a) (i)) | 1 |
| Nearside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
| Emissions not tested |8.2.1.2 |d|| | 1 |
| Offside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Offside Front Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Macpherson strut insecurely attached |5.3.3 |a| |i|| | 1 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 1 |
| Nearside Front Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
| Offside Front Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
| Headlamp not working on dipped beam |1.7.5a| | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Front Headlamp has a product on the lens so that the light output is severely reduced (4.1.4 (b)) | 1 |
| engine mounting deteriorated resulting in excessive movement |6.1.D.1a| | 1 |
| Offside Rear Shock absorbers has a serious fluid leak | 1 |
| Fuel cap/sealing device ineffective seal damaged (6.1.3 (b) (i)) | 1 |
| Offside Front Suspension arm pin or bush excessively worn rearward bush (5.3.4 (a) (i)) | 1 |
| Nearside Headlamp incorrect colour |1.7.5b| | 1 |
| Undertray likely to become detached (6.2.1 (a) (ii)) | 1 |
| Nearside Rear Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Front Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Front Seat belt anchorage loose (7.1.1 (b)) | 1 |
| Fuel cap/sealing device missing (6.1.3 (b) (i)) | 1 |
| Anti-roll bar pin or bush excessively worn both front d-bushes (5.3.4 (a) (i)) | 1 |
| Lower Engine mounting damaged or deteriorated resulting in excessive movement (6.1.8 (a) (i)) | 1 |
| Nearside Rear Stop lamp(s) missing (4.3.1 (a) (ii)) | 1 |
| Nearside Rear Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement front and rear bushes |2.4.G.2| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| Offside Front Position lamp not working |4.2.1 |a|| | 1 |
| Offside Front Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |