| Most common failures | No# failures |
|---|
| Registration plate lamp issues | 35 |
| Headlamp aim out of alignment | 34 |
| Windscreen wiper does not clear the windscreen effectively | 23 |
| Parking brake: efficiency below requirements |3.7.B.7| | 15 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 13 |
| Rear parking brake recording little or no effort | 13 |
| Brakes imbalanced across an axle | 12 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 11 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 11 |
| Registration plate issues | 8 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 8 |
| Front brake disc in such a condition that it is seriously weakened | 7 |
| Centre Exhaust system not adequately supported |7.1.1| | 6 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 6 |
| Windscreen has damage | 5 |
| Offside Stop lamp not working |1.2.1b| | 4 |
| Nearside Stop lamp not working |1.2.1b| | 4 |
| Rear brake binding | 4 |
| Service brake: efficiency below requirements |3.7.B.7| | 4 |
| Nearside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 4 |
| Offside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 4 |
| Offside Steering rack gaiter split |2.2.D.2d| | 3 |
| Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 3 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 3 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Anti-lock braking system warning lamp indicates an ABS fault | 3 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 3 |
| Offside Front constant velocity joint gaiter split |2.5.C.1a| | 3 |
| Brake pipe excessively corroded | 3 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 3 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 3 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 3 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 3 |
| rear parking |secondary| brakes imbalanced | 3 |
| Nearside Front Anti-roll bar linkage insecure |2.4.G.1| | 2 |
| Offside Steering arm has relative movement at its fixings |2.2.B.1h| | 2 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
| Rear Direction indicator incorrect colour |1.4.A.2f| | 2 |
| Nearside Rear coil spring broken |2.4.C.1a| | 2 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Nearside Front Steering rack gaiter split |2.2.D.2d| | 2 |
| Offside Rear wheel bearing has excessive play |2.6.2| | 2 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Nearside Rear Direction indicators incorrect colour |1.4.A.2f| | 2 |
| Offside Rear Direction indicators incorrect colour |1.4.A.2f| | 2 |
| Offside Side repeater not working |1.4.A.2c| | 2 |
| Offside Front Wheel bolt|s| missing |4.2.A.1e| | 2 |
| Nearside Front Direction indicator insecure |1.4.A.2b| | 2 |
| Driver`s seat insecure |6.2.A.1| | 2 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Nearside Rear Rear wheel bearing rough when rotated |2.6.1| | 2 |
| Emissions not tested |7.0| | 2 |
| Brake pedal creeps down while the pedal is held under pressure |3.3.B.1a| | 2 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Nearside Front Shock absorber has negligible damping effect |2.7.5| | 2 |
| Parking brake lever has no reserve travel |3.1.6b| | 2 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Outer Front constant velocity joint gaiter split |2.5.C.1a| | 2 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 2 |
| Nearside Headlamp insecure |1.7.3| | 2 |
| Offside Front Shock absorber has negligible damping effect |2.7.5| | 2 |
| Rear Mechanical brake component has restricted free movement | 2 |
| Nearside Side repeater not working |1.4.A.2c| | 2 |
| Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Offside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Offside Rear wheel bearing rough when rotated |2.6.1| | 2 |
| Offside Rear wheel cylinder leaking |3.6.A.1| | 2 |
| Brake hose excessively deteriorated | 2 |
| Stop lamp not working |1.2.1b| | 2 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Centre Rear Statutory seat belt missing |5.1.1| | 1 |
| Nearside Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Centre Rear Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Nearside Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
| Offside Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
| Offside Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear coil spring fractured |2.4.C.1a| | 1 |
| Nearside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Wheel stud|s| missing |4.2.A.1e| | 1 |
| Offside Front Wheel stud|s| missing |4.2.A.1e| | 1 |
| Offside Front Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Seat belt anchorage prescribed area is inadequately repaired |5.2.6| | 1 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 1 |
| Offside Front brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Rear brake disc excessively pitted |3.5.1h| | 1 |
| Offside Rear brake disc excessively pitted |3.5.1h| | 1 |
| Offside Rear Wheel bolt|s| missing |4.2.A.1e| | 1 |
| Nearside Rear Wheel bolt|s| missing |4.2.A.1e| | 1 |
| Nearside Rear Lower coil spring incomplete |2.4.C.1a| | 1 |
| Offside Rear Road wheel bead rim badly distorted |4.2.A.1a| | 1 |
| Nearside Front Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Offside Rear position lamp|s| adversely affected by the operation of another lamp with fog always on |1.1.A.3f| | 1 |
| Rear Direction indicator incorrect colour both sides |1.4.A.2f| | 1 |
| Front Track rod end ball joint has excessive play both sides |2.2.B.1f| | 1 |
| Nearside Front coil spring broken |2.4.C.1a| | 1 |
| Offside Front Inner Suspension arm rubber bush deteriorated resulting in excessive movement wishbone bush |2.4.G.2| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Direction indicators not working |1.4.A.2c| | 1 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Nearside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement rearmost |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement rearmost |2.4.G.2| | 1 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Front Headlamp has a product on the lens so that the light output is severely reduced no beam pattern |1.7.5a| | 1 |
| Fuel cap/sealing device missing |7.2.4a| | 1 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Inner Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Rear Hydraulic brake cylinder leaking hydraulic fluid |3.6.A.1| | 1 |
| Offside Front Brake hose twisted |3.6.B.4c| | 1 |
| Offside Front Track rod end loose |2.2.B.1d| | 1 |
| Nearside Front Track rod end loose |2.2.B.1d| | 1 |
| Mechanical brake component has restricted free movement | 1 |
| Nearside Rear Direction indicator excessively damaged so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
| Offside Rear Direction indicator excessively damaged so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
| Brake hose has insufficient room to move | 1 |
| Nearside Outer Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
| Nearside Front coil spring fractured |2.4.C.1a| | 1 |
| Rear brake application uneven | 1 |
| Offside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Nearside Rear coil spring fractured |2.4.C.1a| | 1 |
| Exhaust mounting missing |7.1.1b| | 1 |
| Offside Rear coil spring incomplete |2.4.C.1a| | 1 |
| Offside Steering rack insecure |2.2.B.1a| | 1 |
| Nearside Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Front brake excessively fluctuating | 1 |
| Nearside Front Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Exhaust emits dense blue smoke at idle |7.3.A.2b| | 1 |
| Centre Stop lamp not working |1.2.1b| | 1 |
| Offside Side repeater incorrect colour |1.4.A.2f| | 1 |
| Offside Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Offside Front coil spring incomplete |2.4.C.1a| | 1 |
| Nearside Front Anti-roll bar linkage insecure bolt missing |2.4.G.1| | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| Offside Outer Front constant velocity joint is excessively worn |2.5.C.1b| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc both outer |2.5.C.1a| | 1 |
| Power steering pump leaking from a failed component pump area needs clean off and check |2.3.3b| | 1 |
| Nearside Front Upper Macpherson strut has excessive movement at the upper attachment |2.5.A.1c| | 1 |
| Nearside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Nearside Front Macpherson strut has excessive movement in the upper support bearing assembly |2.5.B.1b| | 1 |
| Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Nearside Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Bonnet retaining device excessively deteriorated |8.4.2| | 1 |
| Nearside Outer Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Exhaust emits excessive dense blue smoke during acceleration |7.3.A.2c| | 1 |
| Offside Rear coil spring broken |2.4.C.1a| | 1 |
| Offside Hazard warning lamps inoperative front and rear also repeater light |1.4.B.1b| | 1 |
| Offside Front Outer Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Front Upper Macpherson strut has excessive movement in the upper support bearing assembly |2.5.B.1b| | 1 |
| Nearside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
| Brake pedal creeps down when held under pressure |3.3.B.1a| | 1 |
| Offside Rear Braking system leaking |3.6.A.1| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Braking system leaking |3.6.A.1| | 1 |
| Windscreen wiper blade insecure | 1 |
| Exhaust emissions likely to be affected by an exhaust leak |8.2.1.1 |b|| | 1 |
| Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Offside Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Nearside Rear passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 1 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Nearside Front Seat belt damaged sufficient to significantly weakened the webbing |5.2.2a| | 1 |
| Offside Front Sub-frame damaged and seriously weakened |2.4.G.1| | 1 |
| Offside Front Suspension arm locating pin insecure |2.4.G.3a| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Front Suspension arm rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |