| Most common failures | No# failures |
|---|
| Registration plate lamp issues | 44 |
| Windscreen wiper does not clear the windscreen effectively | 35 |
| Headlamp aim out of alignment | 35 |
| Brake pipe excessively corroded | 20 |
| Brakes imbalanced across an axle | 12 |
| Rear parking brake recording little or no effort | 10 |
| Nearside Stop lamp not working |1.2.1b| | 9 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 7 |
| Rear brake binding | 7 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 7 |
| Offside Front Macpherson strut has excessive movement at the upper attachment |2.5.A.1c| | 7 |
| Exhaust emits an excessive level of metered smoke for a non-turbo charged engine |7.4.B.3b| | 7 |
| Nearside Front Brake hose bulging under pressure |3.6.B.3| | 6 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 6 |
| Parking brake: efficiency below requirements |3.7.B.7| | 6 |
| Offside Stop lamp not working |1.2.1b| | 6 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 5 |
| Parking brake lever has no reserve travel |3.1.6b| | 5 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
| Windscreen has damage | 4 |
| Bonnet cannot be secured in the closed position |8.4.1| | 4 |
| Registration plate issues | 4 |
| Nearside Front Macpherson strut has excessive movement at the upper attachment |2.5.A.1c| | 4 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 4 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 3 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 3 |
| Rear Brake valve leaking |3.6.A.1| | 3 |
| Offside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 3 |
| Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 3 |
| Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.A.3| | 3 |
| Front Exhaust system not adequately supported |7.1.1| | 3 |
| Offside Rear Direction indicator not working (4.4.1 (a) (ii)) | 2 |
| Offside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 2 |
| Nearside Front Road wheel bead rim badly distorted |4.2.A.1a| | 2 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 2 |
| Offside Steering rack gaiter split |2.2.D.2d| | 2 |
| Brake hose has insufficient room to move | 2 |
| Emissions not tested |7.0| | 2 |
| Exhaust emissions exceed manufacturer`s specified limit |8.2.2.2 |a|| | 2 |
| Horn not working |1.6.2a| | 2 |
| Brake hose excessively deteriorated | 2 |
| Nearside Front Seat belt affected by an insecure seat fixing |5.2.1b| | 2 |
| Nearside Obligatory mirror insecure |8.1.1| | 2 |
| Offside Rear Service brake effort inadequate at a wheel |1.2.1 |a| |i|| | 2 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 2 |
| Battery insecure |1.9.1| | 2 |
| Offside Front constant velocity joint gaiter split |2.5.C.1a| | 2 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 2 |
| Offside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 2 |
| Nearside Lower Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Spare wheel carrier insecure |6.4.2| | 2 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 2 |
| Nearside Rear Stop lamp not working |1.2.1b| | 2 |
| Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Brake load sensing valve seized |3.6.E.3| | 2 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Rear Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Nearside Front Anti-roll bar attachment bracket/mounting corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength anti roll bar (5.3.6 (a) (i)) | 1 |
| Nearside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting seat (6.2.2 (d) (i)) | 1 |
| Nearside Rear Exhaust silencer insecure (8.1.1 (b) (i)) | 1 |
| Offside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
| Windscreen damaged and affecting the drivers view of the road (3.2 (a) (ii)) | 1 |
| Offside Outer Seat belt anchorage prescribed area is excessively corroded sill |5.2.6| | 1 |
| Nearside Rear Outer Suspension component mounting prescribed area is excessively corroded sill |2.4.A.3| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded chassis |2.4.A.3| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Brake load sensing valve linkage seized |3.6.E.3| | 1 |
| Offside Rear brake drum contaminated by brake fluid |3.5.1h| | 1 |
| Offside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
| Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Nearside Front front brake binding |3.7.B.1| | 1 |
| Offside Rear Upper Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Obligatory mirror insecure (3.3 (b) (ii)) | 1 |
| Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 1 |
| Front Passenger`s seat insecure |6.2.A.1| | 1 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Horn not working (7.7 (a)) | 1 |
| Nearside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced over axle (6.1.1 (c) (i)) | 1 |
| Outer Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced sills both sides (6.1.1 (c) (i)) | 1 |
| Front Service brake imbalanced across an axle (1.2.1 (b) (i)) | 1 |
| Front Brake servo defective or ineffective (1.1.10 (a) (i)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Nearside Front Suspension arm pin or bush excessively worn Rear bus de bonded (5.3.4 (a) (i)) | 1 |
| Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 1 |
| Offside Rear Suspension spring mounting prescribed area excessively damaged significantly reducing structural strength Leaf spring hanger rear (5.3.6 (a) (i)) | 1 |
| Nearside Seat belt anchorage prescribed area strength or continuity significantly reduced Outer sill (7.1.1 (a) (i)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Headlamp levelling device inoperative (4.1.5 (a)) | 1 |
| Exhaust has a major leak of exhaust gases Centre section (6.1.2 (a)) | 1 |
| Offside Rear Service brake lagging in operation (1.2.1 (d)) | 1 |
| Emissions not tested Due to exhaust condition (8.2.2.2 (e)) | 1 |
| Offside Seat belt anchorage prescribed area strength or continuity significantly reduced Outer sill (7.1.1 (a) (i)) | 1 |
| Emissions not tested cambelt ? |7.4.B.1| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded outer sill |5.2.6| | 1 |
| Steering column will not lock in a fixed position |adjustable type| |2.1.2a| | 1 |
| Offside Front Lower Suspension arm synthetic bush deteriorated resulting in excessive movement front |2.4.G.2| | 1 |
| Rear Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Nearside Rear Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Brake hydraulic reservoir cap missing |3.6.G.1a| | 1 |
| Offside Rear Upper Brake valve leaking |3.6.A.1| | 1 |
| Nearside Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Offside Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Front Power steering pipe|s| or hose|s| excessively corroded |2.3.2| | 1 |
| Front Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded Outer sill |5.2.6| | 1 |
| Offside Front Bonded suspension unit deteriorated and cannot function as intended |2.4.F.3| | 1 |
| Nearside Front coil spring broken |2.4.C.1a| | 1 |
| Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Nearside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Offside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Nearside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Lower Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Outer Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Front Brake hose bulging under pressure |3.6.B.3| | 1 |
| Offside Seat belt anchorage prescribed area strength or continuity significantly reduced floor (7.1.1 (a) (i)) | 1 |
| Nearside Front Subframe mounting prescribed area excessively damaged significantly reducing structural strength chassis rail (5.3.6 (a) (i)) | 1 |
| Offside Front Subframe mounting prescribed area excessively damaged significantly reducing structural strength chassis rail (5.3.6 (a) (i)) | 1 |
| Brake valve leaking rear compensator valve (1.1.7 (d) (i)) | 1 |
| Nearside Front Passenger`s seat insecure |6.2.A.1| | 1 |
| Offside Rear Rear position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment |1.1.6 |c|| | 1 |
| Horn not working |7.7 |a| |ii|| | 1 |
| Nearside Rear Service brake effort inadequate at a wheel |1.2.1 |a| |i|| | 1 |
| Nearside Parking brake inoperative on one side effort low |1.4.1 |a|| | 1 |
| Offside Parking brake inoperative on one side effort low |1.4.1 |a|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Nearside Rear Rear position lamp|s| incomplete |1.1.4a| | 1 |
| Offside Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Nearside Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Nearside Front Brake hose bulging under pressure |1.1.12 |d|| | 1 |
| Offside Front Seat belt affected by an insecure seat fixing |5.2.1b| | 1 |
| Offside Rear Brake valve leaking |3.6.A.1| | 1 |
| Fuel tank leaking |7.2.3| | 1 |
| Offside Front Steering system has a road wheel fouling a part of the vehicle |2.2.D.2a| | 1 |
| Nearside Front Steering system has a road wheel fouling a part of the vehicle |2.2.D.2a| | 1 |
| Emissions not tested |7.4.B.1| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
| Windscreen washer not working | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Parking brake lever insecure |3.1.3b| | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Central Stop lamp excessively damaged so that it is not visible from a reasonable distance |1.2.1d| | 1 |
| Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 1 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Front Brake hose bulging under pressure (1.1.12 (d)) | 1 |
| Nearside Front Anti-roll bar linkage insecurely attached (5.3.3 (a) (i)) | 1 |
| Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Exhaust has a major leak of exhaust gases rear of cat |7.1.2| | 1 |
| Centre Exhaust has a major leak of exhaust gases in front of rear joint. |7.1.2| | 1 |
| Nearside Steering rack gaiter missing or no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Nearside Front Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
| Offside Front Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Offside Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Rear Brake load sensing valve linkage seized |3.6.E.3| | 1 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Offside Front Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Front Upper Driver`s door hinge insecure |6.2.B.2| | 1 |
| Nearside Front Lower Suspension arm insecure bolt |2.4.G.1| | 1 |
| Front Braking system leaking brake pedal when pressed |3.6.A.1| | 1 |
| Brake pressure build up too slow |3.3.E.6| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Centre Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Hydraulic brake cylinder leaking hydraulic fluid |3.6.A.1| | 1 |
| Nearside Rear Lower Stop lamp not working |1.2.1b| | 1 |
| Exhaust noise is clearly in excess of that emitted by a similar vehicle fitted with a standard silencer in average condition |7.1.4| | 1 |
| Offside Front All position lamps not working |1.1.A.3b| | 1 |
| Exhaust system not adequately supported forward support |7.1.1| | 1 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Macpherson strut has excessive movement at the upper attachment |2.5.A.1c| | 1 |
| Offside Macpherson strut has excessive movement at the upper attachment |2.5.A.1c| | 1 |
| Windscreen wiper not working working at maximum sweep only (3.4 (a)) | 1 |
| Offside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Exhaust system insecure forward hangers corroded/ broken (6.1.2 (a)) | 1 |
| Front passenger door cannot be opened from inside the vehicle (6.2.3 (a)) | 1 |
| Offside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Front Brake disc significantly and obviously worn inner face (1.1.14 (a) (i)) | 1 |
| Offside Front Brake disc significantly and obviously worn inner face (1.1.14 (a) (i)) | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Exhaust has a major leak of exhaust gases rear box (6.1.2 (a)) | 1 |
| Exhaust system insecure front hanger (6.1.2 (a)) | 1 |
| Brake load sensing valve seized and ABS not fitted or inoperative (1.1.17 (c) (ii)) | 1 |
| Windscreen wiper not working wipers stopping in mid sweep posing a danger to drivers view of the road ahead (3.4 (a)) | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Offside Front Shock absorbers has a serious fluid leak | 1 |
| Offside Front Macpherson strut top bush or bearing has excessive wear or free play (5.3.4 (a) (i)) | 1 |
| Offside Front Anti-roll bar linkage fractured (5.3.3 (b) (ii)) | 1 |
| Offside Front Inner Suspension arm pin or bush excessively worn wishbone rear bush (5.3.4 (a) (i)) | 1 |
| Drivers seat fore and aft adjustment mechanism not functioning as intended. (6.2.5 (b) (i)) | 1 |
| Rear Parking (secondary brake) on a single line braking system has inadequate effort at a wheel (1.3.1 (a) (i)) | 1 |
| Nearside Front Macpherson strut top bush or bearing has excessive wear or free play (5.3.4 (a) (i)) | 1 |
| Nearside Front Headlamp insecure |1.7.3| | 1 |
| Rear Electrical wiring insecure |1.9.2a| | 1 |
| Nearside Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
| Nearside Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Mechanical brake component has restricted free movement | 1 |
| Nearside Headlamp insecure |1.7.3| | 1 |
| Offside Headlamp insecure |1.7.3| | 1 |
| Nearside Front Direction indicator insecure |1.4.A.2b| | 1 |
| Offside Front Direction indicator insecure |1.4.A.2b| | 1 |
| Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Centre Stop lamp obscured more than 50% |1.2.1c| | 1 |
| Steering column top mounting bracket insecure |2.1.2d| | 1 |
| Rear passenger door does not latch securely closed |6.2.B.1a| | 1 |
| Centre Front Exhaust system not adequately supported |7.1.1| | 1 |
| Centre Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Nearside Front position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |