| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 445 |
| Registration plate lamp issues | 239 |
| Windscreen wiper does not clear the windscreen effectively | 136 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 135 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 107 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 104 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 101 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 94 |
| Exhaust emits an excessive level of metered smoke |7.4.B.3a| | 87 |
| Parking brake: efficiency below requirements |3.7.B.7| | 83 |
| Nearside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 63 |
| Windscreen washer not working | 61 |
| Anti-lock braking system warning lamp indicates an ABS fault | 57 |
| Offside Stop lamp not working |1.2.1b| | 56 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 54 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 53 |
| Offside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 48 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 47 |
| Registration plate issues | 47 |
| Rear parking brake recording little or no effort | 46 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 46 |
| Engine MIL inoperative or indicates a malfunction (8.2.2.2 (g)) | 46 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 44 |
| Offside Rear coil spring broken |2.4.C.1a| | 43 |
| Nearside Stop lamp not working |1.2.1b| | 42 |
| Offside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 42 |
| Brakes imbalanced across an axle | 41 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 41 |
| Brake hose excessively deteriorated | 40 |
| Nearside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 39 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 37 |
| Nearside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 37 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 35 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 35 |
| Exhaust emissions exceed default limit of 1.5m-1 (8.2.2.2 (b)) | 34 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 33 |
| Offside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 32 |
| Front brake disc in such a condition that it is seriously weakened | 30 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 28 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 27 |
| Nearside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 27 |
| Offside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 27 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 26 |
| Offside Front Position lamp not working |4.2.1 |a|| | 26 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 26 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 26 |
| Nearside Rear coil spring broken |2.4.C.1a| | 25 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 25 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 25 |
| Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 25 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 24 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 24 |
| Nearside Side repeater not working |1.4.A.2c| | 23 |
| Offside Front Macpherson strut has excessive movement at the upper attachment |2.5.A.1c| | 23 |
| Rear brake disc in such a condition that it is seriously weakened | 23 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 22 |
| Nearside Rear Stop lamp not working |1.2.1b| | 22 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 22 |
| Nearside Front Macpherson strut has excessive movement at the upper attachment |2.5.A.1c| | 21 |
| Offside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 21 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 21 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 21 |
| Brake hose damaged | 20 |
| Offside Rear Coil spring fractured or broken |5.3.1 |b| |i|| | 20 |
| Offside Side repeater not working |1.4.A.2c| | 20 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 20 |
| Offside Rear Stop lamp not working |1.2.1b| | 20 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 20 |
| Nearside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 19 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 19 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 19 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 19 |
| Offside Front Macpherson strut top bush or bearing has excessive wear or free play (5.3.4 (a) (i)) | 18 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 18 |
| Offside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 18 |
| Nearside Inner Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 17 |
| Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 16 |
| Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 16 |
| Nearside Front Inner Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 16 |
| Offside Rear Position lamp not working |4.2.1 |a|| | 16 |
| Electronic stability control warning lamp indicates a fault (7.12 (e)) | 16 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 16 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 16 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 15 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 15 |
| Offside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 15 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 15 |
| Nearside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 15 |
| Offside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 15 |
| Rear Exhaust system not adequately supported |7.1.1| | 14 |
| Nearside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 14 |
| Exhaust emissions exceed default limit of 1.5m-1 |8.2.2.2 |b|| | 14 |
| Offside Rear fog lamp not working |1.3.2b| | 14 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 14 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 14 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 14 |
| Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 14 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 13 |
| Offside Front Inner Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 13 |
| Nearside Front Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 13 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 13 |
| Offside Side repeater not working (4.4.1 (a) (ii)) | 13 |
| Offside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 13 |
| Nearside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 13 |
| Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 12 |
| Front brake excessively fluctuating | 12 |
| Front position lamp|s| not working |1.1.A.3b| | 12 |
| Rear brake binding | 12 |
| Central Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 12 |
| Offside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 11 |
| Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 11 |
| Exhaust system not adequately supported |7.1.1| | 11 |
| Offside Front Macpherson strut pin or bush excessively worn (5.3.4 (a) (i)) | 11 |
| Offside Front Suspension arm pin or bush excessively worn rear bush (5.3.4 (a) (i)) | 11 |
| Nearside Front Suspension arm pin or bush excessively worn rear bush (5.3.4 (a) (i)) | 11 |
| Nearside Rear Other passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 11 |
| Offside Front Lower Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 11 |
| Offside Stop lamp|s| not working |4.3.1 |a| |ii|| | 10 |
| Emissions not tested |7.4.B.1| | 10 |
| Windscreen has damage | 10 |
| Nearside Stop lamp|s| not working |4.3.1 |a| |ii|| | 10 |
| Offside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 10 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 10 |
| Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.A.3| | 10 |
| Nearside Rear Position lamp not working |4.2.1 |a|| | 10 |
| Offside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 10 |
| Offside Rear Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 10 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 10 |
| Battery insecure |1.9.1| | 9 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 9 |
| Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 9 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 9 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 9 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 9 |
| Offside Front Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 9 |
| Nearside Front Lower Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 9 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 9 |
| Offside Front Lower Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 9 |
| Emissions not tested (8.2.2.2 (e)) | 9 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 9 |
| Nearside Front Lower Suspension component ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 9 |
| Nearside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 9 |
| Nearside Front Macpherson strut top bush or bearing has excessive wear or free play (5.3.4 (a) (i)) | 9 |