| Most common failures | No# failures |
|---|
| Parking brake: efficiency below requirements |3.7.B.7| | 103 |
| Rear parking brake recording little or no effort | 63 |
| Brake pipe excessively corroded | 62 |
| Windscreen wiper does not clear the windscreen effectively | 61 |
| Parking brake lever has no reserve travel |3.1.6b| | 58 |
| Headlamp aim out of alignment | 51 |
| Registration plate lamp issues | 50 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 41 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 37 |
| Brake hose excessively deteriorated | 29 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 28 |
| Registration plate issues | 26 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 25 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 25 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 22 |
| Offside Front Front constant velocity joint gaiter split |2.5.C.1a| | 21 |
| Brakes imbalanced across an axle | 20 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 19 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 18 |
| Nearside Stop lamp not working |1.2.1b| | 18 |
| Offside Front constant velocity joint gaiter split |2.5.C.1a| | 18 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 17 |
| Rear Exhaust system not adequately supported |7.1.1| | 16 |
| Windscreen has damage | 15 |
| Nearside Front Front constant velocity joint gaiter split |2.5.C.1a| | 14 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 13 |
| Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 13 |
| Service brake: efficiency below requirements |3.7.B.7| | 13 |
| Offside Stop lamp not working |1.2.1b| | 12 |
| Steering column top mounting bracket insecure |2.1.2d| | 11 |
| Offside Rear fog lamp not working |1.3.2b| | 11 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 11 |
| Offside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 11 |
| Offside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 9 |
| Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 9 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 9 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 9 |
| Nearside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 8 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 8 |
| Nearside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 8 |
| Anti-lock braking system warning lamp indicates an ABS fault | 8 |
| Offside Front Windscreen wiper blade deteriorated |8.2.2| | 7 |
| Offside Side repeater not working |1.4.A.2c| | 7 |
| Horn not working |1.6.2a| | 6 |
| Brake hose has insufficient room to move | 6 |
| Offside Front Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 6 |
| Exhaust system not adequately supported |7.1.1| | 6 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 6 |
| Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 6 |
| Driver`s seat insecure |6.2.A.1| | 5 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 5 |
| Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 5 |
| Rear fog lamp tell tale not working |1.3.1b| | 5 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 5 |
| Nearside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
| Battery insecure |1.9.1| | 5 |
| Steering column top bearing excessively worn |2.1.2c| | 5 |
| Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 5 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 5 |
| Offside Rear Stop lamp not working |1.2.1b| | 5 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 5 |
| Offside Front Brake pipe leaking |3.6.A.1| | 5 |
| Steering column will not lock in a fixed position |adjustable type| |2.1.2a| | 5 |
| Offside Rear Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 5 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 5 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 5 |
| Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 5 |
| Offside Outer Front constant velocity joint gaiter split |2.5.C.1a| | 5 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 5 |
| Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 5 |
| Rear Exhaust mounting missing |7.1.1b| | 4 |
| Nearside Rear Stop lamp not working |1.2.1b| | 4 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 4 |
| Offside Obligatory mirror insecure |8.1.1| | 4 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 4 |
| Nearside Side repeater not working |1.4.A.2c| | 4 |
| Nearside Rear Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 4 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 4 |
| Nearside front brake binding |3.7.B.1| | 4 |
| Offside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 4 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 4 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 4 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 4 |
| Nearside Inner Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 4 |
| Offside Inner Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 4 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 4 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 4 |
| Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 4 |
| Offside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 4 |
| Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 4 |
| Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 4 |
| Brake hose damaged | 4 |
| Windscreen wiper blade deteriorated |8.2.2| | 3 |
| Headlamp switch faulty |1.7.1| | 3 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
| Offside Steering rack gaiter insecure |2.2.D.2d| | 3 |
| Nearside Headlamp not working on main beam |1.7.5a| | 3 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 3 |
| Offside Obligatory mirror missing |8.1.1| | 3 |
| Nearside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 3 |
| Nearside Outer Front constant velocity joint gaiter split |2.5.C.1a| | 3 |
| Fuel tank leaking |7.2.3| | 3 |
| Power steering component|s| leaking |2.3.3b| | 3 |
| Brake performance not tested |3.7.A.1| | 3 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 3 |
| Brake pedal has insufficient reserve movement |3.3.A.5| | 3 |
| Exhaust emissions carbon monoxide content excessive |8.2.1.2 |b|| | 3 |
| Stop lamp remains on when the brakes are released | 3 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Nearside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 3 |
| Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 3 |
| Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 3 |
| Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 3 |
| Offside Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 3 |
| Front Exhaust has part of the system excessively deteriorated |7.1.1a| | 3 |
| Front brake application uneven | 3 |
| Nearside Front Brake hose bulging under pressure |3.6.B.3| | 3 |
| Offside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 3 |
| Nearside Rear brake caliper leaking |3.6.A.1| | 3 |
| Offside front brake binding |3.7.B.1| | 3 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 3 |
| Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 3 |
| Emissions not tested |7.0| | 3 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 3 |
| Fuel system component insecure |7.2.1| | 3 |
| Rear Rear fog lamp not working |1.3.2b| | 3 |
| Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 3 |
| Centre Exhaust has part of the system excessively deteriorated |7.1.1a| | 3 |
| Offside Rear Fuel system component insecure |7.2.1| | 3 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 3 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 3 |
| Offside Rear Brake lever has restricted free movement |3.5.1k| | 3 |
| Nearside Front Side repeater not working |1.4.A.2c| | 3 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 3 |
| Stop lamp not working |1.2.1b| | 2 |
| Offside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Steering rack gaiter split |2.2.D.2d| | 2 |
| Braking system leaking |3.6.A.1| | 2 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 2 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Nearside Front coil spring fractured |2.4.C.1a| | 2 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 2 |
| Brake pedal creeps down when held under pressure |3.3.B.1a| | 2 |
| Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Nearside Rear Rear passenger seat cannot be secured in the upright position. |6.2.3| | 2 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 2 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 2 |
| Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 2 |
| Offside Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 2 |
| Nearside Rear Seat belt anchorage prescribed area is inadequately repaired |5.2.6| | 2 |
| Nearside Steering rack gaiter insecure |2.2.D.2d| | 2 |
| Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 2 |
| Hazard warning switch faulty |1.4.B.1d| | 2 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 2 |
| Offside Front Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 2 |
| Nearside Inner Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Inner Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Nearside Outer Rear Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Outer Rear Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Position lamp switch faulty |1.1.A.1| | 2 |
| Nearside Front front brake binding |3.7.B.1| | 2 |
| Offside Front front brake binding |3.7.B.1| | 2 |
| Nearside Front front brake recording little or no effort |3.7.B.5a| | 2 |
| Offside Front front brake recording little or no effort |3.7.B.5a| | 2 |
| Nearside Rear front brake recording little or no effort |3.7.B.5a| | 2 |
| Offside Rear front brake recording little or no effort |3.7.B.5a| | 2 |
| Nearside Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 2 |
| Nearside Front suspension has a suspension lower ball joint securing nut loose |2.5.B.1a| | 2 |
| Front Headlamp not working on dipped beam |1.7.5a| | 2 |
| Power steering pipe|s| or hose|s| leaking |2.3.3b| | 2 |
| Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 2 |
| Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 2 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 2 |
| Windscreen washer not working | 2 |
| Offside Ball joint has excessive play |2.2.B.1f| | 2 |
| Nearside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Offside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Nearside Rear Rear fog lamp not working |1.3.2b| | 2 |
| Offside Rear Brake pipe leaking |3.6.A.1| | 2 |
| Exhaust noise is clearly in excess of that emitted by a similar vehicle fitted with a standard silencer in average condition |7.1.4| | 2 |
| Rear fog lamp switch faulty |1.3.1a| | 2 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 2 |
| Hazard warning tell tale not working correctly |1.4.B.1e| | 2 |
| Offside Stop lamp emits other than a steady red light |1.2.1e| | 2 |
| Offside Rear Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 2 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 2 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded outer sill |5.2.6| | 2 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Nearside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 2 |
| Nearside Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 2 |
| Nearside Front Brake pipe leaking |3.6.A.1| | 2 |
| Nearside Front Suspension arm attachment bracket/mounting cracked |2.4.G.1| | 2 |
| Front Exhaust system not adequately supported |7.1.1| | 2 |
| Rear brake binding | 2 |
| Offside Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 2 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Nearside Outer Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Brake master cylinder fluid level below minimum level |3.6.G.1e| | 2 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 2 |
| Horn not working (7.7 (a) (ii)) | 2 |
| Horn not working (7.7 (a)) | 2 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Nearside Headlamp not in a clean condition affecting beam image |1.2.4a| | 2 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Front Braking system leaking |3.6.A.1| | 2 |
| Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Offside Front Side repeater not working |1.4.A.2c| | 2 |