| Most common failures | No# failures |
|---|
| Registration plate lamp issues | 10 |
| Parking brake: efficiency below requirements |3.7.B.7| | 8 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 5 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 4 |
| Rear parking brake recording little or no effort | 4 |
| Nearside Rear Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 4 |
| Headlamp aim out of alignment | 4 |
| Rear brake binding | 4 |
| Windscreen wiper does not clear the windscreen effectively | 3 |
| Offside Front coil spring incomplete |2.4.C.1a| | 3 |
| Offside Rear Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 3 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Nearside Rear Suspension arm has excessive play in a pin/bush |2.4.G.2| | 2 |
| Nearside Front coil spring incomplete |2.4.C.1a| | 2 |
| Offside Front coil spring broken |2.4.C.1a| | 2 |
| Offside Front Seat belt retracting mechanism defective |5.2.5b| | 2 |
| Front Exhaust system not adequately supported |7.1.1| | 2 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 2 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 2 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Rear Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear position lamp|s| has less than 50% of the light sources illuminating |1.1.A.3b| | 1 |
| Brake pipe inadequately supported |3.6.B.1| | 1 |
| Steering system excessively rough |2.2.D.1| | 1 |
| Headlamp levelling device inoperative |1.7.2| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Offside Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.A.3| | 1 |
| Offside Rear Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt and nearside |2.4.G.2| | 1 |
| Offside Rear Suspension component pin or bush excessively worn radius arm (5.3.4 (a) (i)) | 1 |
| Nearside Rear Brake hose leaking |3.6.A.1| | 1 |
| Offside Rear Upper Trailing arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Steering lock warning lamp indicates a fault |2.1.4c| | 1 |
| Offside Rear Brake hose leaking |3.6.A.1| | 1 |
| Offside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear Braking system leaking |3.6.A.1| | 1 |
| Nearside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear Upper Suspension arm has excessive play in a pin/bearing |2.4.G.2| | 1 |
| Nearside Rear Trailing arm rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Hazard warning lamps inoperative |1.4.B.1b| | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Exhaust system insecure (6.1.2 (a)) | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Front Headlamp aim not tested |1.8.A.1c| | 1 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Front Anti-roll bar missing LINK |2.4.G.1| | 1 |
| Nearside Front Wheel bolt|s| missing |4.2.A.1e| | 1 |
| Offside Front Upper Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Lower Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Headlamp levelling device obviously defective |1.7.2| | 1 |
| Electronic stability system warning lamp indicates a fault |3.4.1c| | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front coil spring broken |2.4.C.1a| | 1 |
| Offside Front coil spring fractured |2.4.C.1a| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Nearside Front Position lamp light intensity significantly reduced (4.2.3 (a) (ii)) | 1 |
| Nearside Rear Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Power steering fluid reservoir empty (2.1.5 (b) (ii)) | 1 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Power steering component|s| leaking |2.3.3b| | 1 |
| Nearside Front Upper Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Upper Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Front brake disc in such a condition that it is seriously weakened | 1 |
| Rear brake disc in such a condition that it is seriously weakened | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Rear Upper Suspension arm has excessive play in a pin/bush hub rose joint |2.4.G.2| | 1 |
| Offside Rear Upper Suspension arm has excessive play in a pin/bush hub rose joint |2.4.G.2| | 1 |
| Offside Rear Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 1 |
| Nearside Front Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |