| Most common failures | No# failures |
|---|
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 25 |
| Parking brake: efficiency below requirements |3.7.B.7| | 18 |
| Rear parking brake recording little or no effort | 13 |
| Rear brake binding | 12 |
| Registration plate lamp issues | 10 |
| Windscreen wiper does not clear the windscreen effectively | 10 |
| Brakes imbalanced across an axle | 9 |
| Horn not working |1.6.2a| | 8 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 8 |
| Headlamp aim out of alignment | 6 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 6 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 5 |
| Rear brake application uneven | 5 |
| Service brake: efficiency below requirements |3.7.B.7| | 5 |
| Registration plate issues | 5 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 4 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 4 |
| Nearside Indicator tell tale inoperative |1.4.A.2a| | 3 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 3 |
| Parking brake lever has no reserve travel |3.1.6b| | 3 |
| Rear Exhaust system not adequately supported |7.1.1| | 3 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Offside Rear An item not tested |Manual| | 2 |
| Nearside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
| Offside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
| Nearside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
| Brake pipe excessively corroded | 2 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 2 |
| Brake pedal spongy |3.3.B.1b| | 2 |
| Offside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Nearside Windscreen wiper blade missing |8.2.2| | 2 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Rear Wheel nut|s| loose |4.2.A.1e| | 2 |
| Offside Steering rack gaiter split |2.2.D.2d| | 2 |
| Exhaust emissions carbon monoxide content excessive |8.2.1.2 |b|| | 2 |
| Rear Brake hose bulging under pressure |3.6.B.3| | 2 |
| Windscreen washer not working | 2 |
| Nearside Front Seat belt retracting mechanism defective |5.2.5b| | 2 |
| Brake hose excessively deteriorated | 2 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Offside Headlamps matched pair are not the same colour |1.7.6| | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Front brake disc in such a condition that it is seriously weakened | 1 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Front brake application uneven | 1 |
| Nearside Front Suspension arm ball joint dust cover insecure so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Brake hose twisted |3.6.B.4c| | 1 |
| Steering column flexible coupling cracked and unserviceable |2.2.C.1d| | 1 |
| Nearside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Rear Fuel hose insecure (6.1.3 (a) (i)) | 1 |
| Offside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Rear Shock absorber has negligible damping effect |2.7.5| | 1 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Brake master cylinder fluid level below minimum level |3.6.G.1e| | 1 |
| Offside Rear Trailing arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Windscreen wiper blade missing |8.2.2| | 1 |
| Nearside Rear Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Offside Rear Direction indicator flashing less than 60 times a minute |1.4.A.2g| | 1 |
| Offside Rear position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Front Brake hose bulging under pressure |3.6.B.3| | 1 |
| Offside Headlamp insecure |1.7.3| | 1 |
| Steering component cracked and unserviceable |2.2.C.1d| | 1 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Steering component mounting prescribed area is excessively corroded bulk head by steering column uj |2.2.C.1h| | 1 |
| Nearside Front Steering component mounting prescribed area is excessively corroded inner wheel arch by steering column uj |2.2.C.1h| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Emissions not tested |7.0| | 1 |
| Front Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
| Nearside Front Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Inner Front Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Suspension arm locating pin incorrectly positioned |2.4.G.3a| | 1 |
| Rear Mechanical brake component has restricted free movement | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Direction indicator flashing less than 60 times a minute |1.4.A.2g| | 1 |
| Nearside Direction indicator not working |1.4.A.2c| | 1 |
| Offside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
| Rear Brake pipe leaking |3.6.A.1| | 1 |
| Power steering pump leaking |2.1.5 |a|| | 1 |
| Centre Stop lamp not working |1.2.1b| | 1 |
| Hazard warning tell tale not working correctly |1.4.B.1e| | 1 |
| Direction indicators flashing less than 60 times a minute |1.4.A.2g| | 1 |
| Offside Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Braking system leaking |3.6.A.1| | 1 |
| Nearside Front Brake pipe leaking on a hydraulic braking system |1.1.11 |b| |ii|| | 1 |
| Offside Outer Front Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Outer Front Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Outer sill corroded (5.3.6 (a) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Outer sill corroded (5.3.6 (a) (i)) | 1 |
| Offside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Offside Front Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Nearside Front Body has a projection caused by damage |6.1.C.1| | 1 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Rear Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Exhaust engine idle speed too high |7.3.A.2a| | 1 |
| Front Stop lamp not working |1.2.1b| | 1 |
| Offside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Inner Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Lower Steering column locking device insecure |2.1.6| | 1 |
| Lower Steering column movement between the shaft and steering wheel |2.1.2b| | 1 |
| Nearside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Front Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Nearside Rear Trailing arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Trailing arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Direction indicator flashing less than 60 times a minute |1.4.A.2g| | 1 |
| Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| All position lamps not working |1.1.A.3b| | 1 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Offside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 1 |
| Exhaust has a part missing |7.1.1a| | 1 |
| An item not tested |Manual| | 1 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Rear Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| rear brakes release unevenly |3.7.B.4| | 1 |
| Centre Exhaust mounting missing |7.1.1b| | 1 |
| Exhaust tailpipe not capable of allowing the emission probe to be inserted |7.3.B.1| | 1 |
| Nearside Direction indicators flashing less than 60 times a minute |1.4.A.2g| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front Brake pipe leaking |3.6.A.1| | 1 |
| Nearside Front Wheel nut|s| loose |4.2.A.1e| | 1 |
| Offside Front Wheel nut|s| loose |4.2.A.1e| | 1 |
| Windscreen has damage | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Offside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Offside Front Direction indicators not working |1.4.A.2c| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Upper Steering column universal joint has excessive play |2.1.5| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Nearside front parking brake recording little or no effort |3.7.B.6a| | 1 |
| Tailgate cannot be secured in the closed position |6.4.1| | 1 |
| Sub-frame attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Anti-roll bar attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Power steering pipe|s| or hose|s| leaking |2.3.3b| | 1 |
| Lower Steering column top bearing excessively worn |2.1.2c| | 1 |
| Centre Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Rear Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Offside Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Steering component damaged and unserviceable |2.2.C.1d| | 1 |