Most common failures | No# failures |
---|
Parking brake: efficiency below requirements |3.7.B.7| | 22 |
Headlamp aim out of alignment | 20 |
Brakes imbalanced across an axle | 11 |
Registration plate lamp issues | 11 |
Windscreen wiper does not clear the windscreen effectively | 8 |
Service brake: efficiency below requirements |3.7.B.7| | 7 |
Rear parking brake recording little or no effort | 7 |
Brake pipe excessively corroded | 7 |
Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 6 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 6 |
Rear brake application uneven | 6 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 5 |
Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
Rear brake binding | 5 |
Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
Horn not working |1.6.2a| | 4 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 4 |
Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 4 |
Rear Mechanical brake component has restricted free movement | 4 |
Brake pedal has insufficient reserve movement |3.3.A.5| | 3 |
Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 3 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 3 |
Offside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
Nearside Headlamp not working on main beam |1.7.5a| | 3 |
Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 3 |
Offside rear brake recording little or no effort |3.7.B.5a| | 3 |
Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 3 |
Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 3 |
Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
Nearside Stop lamp not working |1.2.1b| | 3 |
Offside Stop lamp not working |1.2.1b| | 3 |
Offside Headlamp not working on main beam |1.7.5a| | 3 |
Offside Front Upper Ball joint has excessive play |2.2.B.1f| | 3 |
Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Offside Front Driver`s seat insecure |6.2.A.1| | 2 |
Nearside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Position lamp switch faulty |1.1.A.1| | 2 |
Steering column top bearing excessively worn |2.1.2c| | 2 |
Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 2 |
Nearside Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 2 |
Nearside Steering rack gaiter split |2.2.D.2d| | 2 |
Offside Front Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 2 |
Nearside Front Steering rack gaiter split |2.2.D.2d| | 2 |
Nearside Rear Rear wheel bearing rough when rotated |2.6.1| | 2 |
Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Nearside Front Ball joint has excessive play |2.2.B.1f| | 2 |
Direction indicators flashing less than 60 times a minute |1.4.A.2g| | 2 |
Indicator tell tale inoperative |1.4.A.2a| | 2 |
Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
Offside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 2 |
Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
Driver`s seat cannot be secured in the upright position. |6.2.A.2| | 2 |
Offside Front wheel bearing rough when rotated |2.5.A.2| | 2 |
Nearside Front wheel bearing has excessive play |2.5.A.3c| | 2 |
Brake pedal spongy |3.3.B.1b| | 2 |
Brake pedal creeps down while the pedal is held under pressure |3.3.B.1a| | 2 |
Offside Rear Wheel nut|s| missing |4.2.A.1e| | 2 |
Front Fuel system component leaking |7.2.3| | 2 |
Offside Front Lower Ball joint has excessive play |2.2.B.1f| | 2 |
Rear Sub-frame corroded and seriously weakened |2.4.G.1| | 2 |
Offside Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 2 |
Battery insecure |1.9.1| | 2 |
Brake hose excessively deteriorated | 2 |
Offside Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
Brake pipe fouled by moving parts |3.6.B.2a| | 1 |
Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Brake pedal anti-slip provision missing |3.3.A.1b| | 1 |
Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Rear Brake pivot locking device missing |3.5.1l| | 1 |
Nearside Front suspension has excessive movement at a suspension ball joint |2.5.A.1c| | 1 |
Fuel tank leaking |7.2.3| | 1 |
Nearside Front Steering rack gaiter insecure |2.2.D.2d| | 1 |
Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
Offside Rear Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
All position lamps not working |1.1.A.3b| | 1 |
Offside Steering damper leaking oil |2.2.C.1f| | 1 |
Nearside Front Steering pivot point has excessive play |2.2.B.1g| | 1 |
Nearside Front brake disc excessively pitted |3.5.1h| | 1 |
Offside Front brake disc excessively pitted |3.5.1h| | 1 |
Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Offside Rear position lamp|s| incomplete |1.1.4a| | 1 |
Windscreen has damage | 1 |
Steering rack fractured and unserviceable |2.2.C.1d| | 1 |
Front position lamp|s| not working both |1.1.A.3b| | 1 |
Rear position lamp|s| not working |1.1.A.3b| | 1 |
Offside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside front brake binding |3.7.B.1| | 1 |
Offside Rear Bonded suspension unit bonding failed and part of unit is likely to become displaced |2.4.F.2| | 1 |
Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
Nearside Rear Radius arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Windscreen wiper blade missing |8.2.2| | 1 |
Offside Inner Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
Nearside Inner Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Front Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
Nearside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Front Brake pipe inadequately clipped |3.6.B.1| | 1 |
Nearside Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Rear Stop lamp not working |1.2.1b| | 1 |
Offside Front Sub-frame attachment bracket/mounting insecure |2.4.G.1| | 1 |
Centre Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Nearside Front Front drive shaft coupling flexible rubber or fabric coupling unit breaking up |2.5.C.1d| | 1 |
Upper Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Front Ball joint has excessive play |2.2.B.1f| | 1 |
Offside Rear Rear wheel bearing rough when rotated |2.6.1| | 1 |
Nearside Front Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
Offside Front Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
Hazard warning tell tale not working correctly |1.4.B.1e| | 1 |
Nearside Upper Body or chassis has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Upper Body or chassis has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Centre Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
Nearside Rear Brake clevis joint has restricted free movement |3.5.1k| | 1 |
Offside Rear Brake clevis joint has restricted free movement |3.5.1k| | 1 |
Nearside Front passenger seat insecure |6.2.3| | 1 |
Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
Nearside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
Offside Rear wheel bearing has excessive play |2.6.2| | 1 |
Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
Nearside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
Offside Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
Offside Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
Offside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
Nearside Track rod end ball pin shank loose |2.2.B.1c| | 1 |
Power steering pump drive system defective |2.3.6| | 1 |
Offside Rear Leaf spring has excessive side play at eye |shackle| |2.4.B.4| | 1 |
Nearside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
Windscreen washer control missing |8.2.1a| | 1 |
Offside Intermediate drop arm insecure |2.2.B.1a| | 1 |
Nearside Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
Offside Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
Offside Rear Braking system leaking |3.6.A.1| | 1 |
Rear brake disc excessively pitted |3.5.1h| | 1 |
Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
Service brake efficiency below requirements |1.2.2 |a| |i|| | 1 |
Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
Nearside Inner Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Mechanical brake component has restricted free movement | 1 |
Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Centre Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Front An item not tested |Manual| | 1 |
Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
Offside Front An item not tested |Manual| | 1 |
Offside Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
Nearside Front An item not tested |Manual| | 1 |
Offside Front Direction indicator flashing less than 60 times a minute |1.4.A.2g| | 1 |
Offside Rear Direction indicator flashing less than 60 times a minute |1.4.A.2g| | 1 |
Registration plate issues | 1 |
Nearside Rear brake drum contaminated by oil |3.5.1h| | 1 |
Nearside Rear Fuel cap/sealing device mounting flange/sealing method defective |7.2.4c| | 1 |
Offside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
Hazard warning lamps inoperative |1.4.B.1b| | 1 |
Offside Headlamp insecure |1.7.3| | 1 |
Nearside Steering component is not secure to the vehicle structure |2.2.B.1a| | 1 |
Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 1 |
Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Brake master cylinder leaking hydraulic fluid |3.6.G.1f| | 1 |
Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Nearside Front position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Nearside Front Direction indicator incomplete |1.5.A1b| | 1 |
Fuel cap/sealing device sealing washer deteriorated |7.2.4c| | 1 |
Offside Steering rack gaiter split |2.2.D.2d| | 1 |
Offside Rear Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
Offside Front Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
Offside Front Power steering pipe|s| or hose|s| leaking from a joint |2.3.3b| | 1 |
Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Nearside Rear wheel bearing rough when rotated |2.6.1| | 1 |
Nearside Rear Trailing arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Rear Trailing arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
Offside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
Offside Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Nearside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
Offside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
Nearside Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Direction indicators not working |1.4.A.2c| | 1 |
Nearside Front Bonded suspension unit bonding failed and part of unit is likely to become displaced |2.4.F.2| | 1 |
Hazard warning switch faulty |1.4.B.1d| | 1 |
Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Outer Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Power steering pump leaking from a failed component |2.3.3b| | 1 |
Power steering pump leaking from a failed seal |2.3.3b| | 1 |
Offside Rear Leaf spring cracked |2.4.B.1a| | 1 |
Nearside Rear Stop lamp not working |1.2.1b| | 1 |
Nearside Front Axle swivel joint has excessive movement between a swivel joint and its housing |2.5.A.1b| | 1 |
Offside Steering pivot point has excessive play |2.2.B.1g| | 1 |
Nearside Axle swivel joint has excessive play |2.5.A.3b| | 1 |
Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Nearside Rear Exhaust system not adequately supported |7.1.1| | 1 |
Offside Driver`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
Offside Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Front Direction indicators flashing less than 60 times a minute |1.4.A.2g| | 1 |
Centre Brake pipe leaking |3.6.A.1| | 1 |
Nearside Direction indicators flashing less than 60 times a minute |1.4.A.2g| | 1 |
Offside Front Steering locking device missing |2.2.C.1g| | 1 |
Nearside Front Steering locking device missing |2.2.C.1g| | 1 |
Nearside Rear Leaf spring saddle is fractured |2.4.B.7a| | 1 |
Nearside Front Leaf spring saddle is fractured |2.4.B.7a| | 1 |
Centre Exhaust system not adequately supported |7.1.1| | 1 |
Offside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Front Suspension spring mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
Nearside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Front Suspension spring mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
Nearside Rear Suspension spring mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
Offside Rear Suspension spring mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
Brake actuating linkage mounting prescribed area is excessively corroded |3.3.A.2| | 1 |
Nearside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside Rear Brake pipe inadequately supported |3.6.B.1| | 1 |
Offside Rear Brake pipe inadequately supported |3.6.B.1| | 1 |
Brake pipe inadequately supported |3.6.B.1| | 1 |
Offside Front Brake pipe inadequately clipped |3.6.B.1| | 1 |
Nearside Front Lower Shock absorber insecure |2.7.2b| | 1 |
Nearside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
Brake pedal anti-slip provision worn smooth |3.3.A.1b| | 1 |
Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
Offside Front Brake hose bulging under pressure |3.6.B.3| | 1 |
Nearside Front Upper Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
Nearside Front Lower Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
Offside Front Upper Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
Offside Front Lower Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Steering rack damaged and unserviceable |2.2.C.1d| | 1 |
Nearside Rear Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Rear Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Steering wheel weakened by fractures |2.1.1| | 1 |
Steering wheel in a condition likely to injure the driver`s hands |2.1.1| | 1 |
Nearside Front front brake recording little or no effort |3.7.B.5a| | 1 |
Front brake application uneven | 1 |
Front front brakes release unevenly |3.7.B.4| | 1 |
Front front brake binding |3.7.B.1| | 1 |
Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Offside Upper Ball joint has excessive play |2.2.B.1f| | 1 |
Offside Lower Ball joint has excessive play |2.2.B.1f| | 1 |