| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 84 |
| Brake pipe excessively corroded | 43 |
| Parking brake: efficiency below requirements |3.7.B.7| | 39 |
| Service brake: efficiency below requirements |3.7.B.7| | 28 |
| Windscreen wiper does not clear the windscreen effectively | 28 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 16 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 15 |
| Rear parking brake recording little or no effort | 14 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 13 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 12 |
| Brakes imbalanced across an axle | 11 |
| Nearside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 11 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 11 |
| Nearside Rear Radius arm has excessive play in a pin/bush |2.4.G.2| | 11 |
| Offside Rear fog lamp not working |1.3.2b| | 11 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 10 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 10 |
| Offside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 10 |
| Rear brake binding | 10 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 10 |
| Nearside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 9 |
| Offside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 8 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 8 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 8 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 8 |
| Nearside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 7 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 7 |
| Registration plate lamp issues | 7 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 7 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 7 |
| Rear Sub-frame corroded and seriously weakened |2.4.G.1| | 6 |
| Nearside Front Suspension arm corroded and seriously weakened |2.4.G.1| | 6 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 6 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 6 |
| Offside Rear Radius arm has excessive play in a pin/bush |2.4.G.2| | 6 |
| Front Fluid suspension has no suspension movement |2.4.D.5| | 6 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 6 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 6 |
| Nearside Stop lamp not working |1.2.1b| | 6 |
| Offside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 5 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 5 |
| Offside Front Lower Suspension arm corroded and seriously weakened |2.4.G.1| | 5 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 5 |
| Parking brake lever has no reserve travel |3.1.6b| | 5 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
| Brake hose excessively deteriorated | 5 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 5 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 5 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 4 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 4 |
| Nearside Front Fluid suspension has no suspension movement |2.4.D.5| | 4 |
| Offside Front Fluid suspension has no suspension movement |2.4.D.5| | 4 |
| Nearside Rear Radius arm has excessive play in a pin/bearing |2.4.G.2| | 4 |
| Offside Rear Radius arm has excessive play in a pin/bearing |2.4.G.2| | 4 |
| Nearside Rear Stop lamp not working |1.2.1b| | 4 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 4 |
| Offside Front Suspension arm corroded and seriously weakened |2.4.G.1| | 4 |
| Offside Stop lamp not working |1.2.1b| | 4 |
| Nearside Front Lower Suspension arm corroded and seriously weakened |2.4.G.1| | 4 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 4 |
| Rear fog lamp not working |1.3.2b| | 4 |
| Windscreen has damage | 3 |
| Offside Front Suspension has inadequate clearance with the bump stop |2.4.A.1a| | 3 |
| Front Exhaust has part of the system excessively deteriorated |7.1.1a| | 3 |
| Rear Rear fog lamp not working |1.3.2b| | 3 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 3 |
| Rear Mechanical brake component has restricted free movement | 3 |
| Emissions not tested |7.0| | 3 |
| Offside Rear Stop lamp not working |1.2.1b| | 3 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 3 |
| Registration plate issues | 3 |
| Offside Rear Suspension arm has excessive play in a pin/bush |2.4.G.2| | 3 |
| Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 2 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 2 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Rear brake application uneven | 2 |
| Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 2 |
| Offside Rear Brake linkage has restricted free movement |3.5.1k| | 2 |
| Nearside Front Direction indicators incorrect colour |1.4.A.2f| | 2 |
| Offside Front Direction indicators incorrect colour |1.4.A.2f| | 2 |
| Front brake application uneven | 2 |
| rear brake recording little or no effort |3.7.B.5a| | 2 |
| Nearside Rear Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 2 |
| Nearside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Vehicle structure has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Nearside Outer Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Offside Rear Brake cable has a seized clevis joint pivot |3.5.1c| | 2 |
| Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 2 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 2 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Front Direction indicators incorrect colour |1.4.A.2f| | 2 |
| Rear Direction indicator incorrect colour |1.4.A.2f| | 2 |
| Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
| Nearside Headlamps matched pair are incorrectly positioned |1.7.3| | 2 |
| Offside Headlamps matched pair are incorrectly positioned |1.7.3| | 2 |
| Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 2 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Horn not working |1.6.2a| | 2 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 2 |
| Nearside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Nearside Front Sub-frame attachment bracket/mounting corroded and its strength is seriously reduced |2.4.G.1| | 2 |
| Offside Front Sub-frame attachment bracket/mounting corroded and its strength is seriously reduced |2.4.G.1| | 2 |
| Nearside Front Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 2 |
| Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Front Suspension has inadequate clearance with the bump stop |2.4.A.1a| | 2 |
| Rear fog lamp tell tale not working |1.3.1b| | 2 |
| Nearside Rear Suspension arm has excessive play in a pin/bush |2.4.G.2| | 2 |
| Direction indicators incorrect colour |1.4.A.2f| | 2 |
| Rear fog lamp switch faulty |1.3.1a| | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Rear Suspension unit damaged or deteriorated and function affected (5.3.5 (b) (i)) | 1 |
| Offside Rear Suspension arm pin or bush excessively worn radius arm (5.3.4 (a) (i)) | 1 |
| Rear Service brake effort inadequate at a wheel both (1.2.1 (a) (i)) | 1 |
| Offside Rear Suspension has inadequate clearance with the bump stop |2.4.A.1a| | 1 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Front Sub-frame corroded and seriously weakened |2.4.G.1| | 1 |
| Nearside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Rear brake drum contaminated by brake fluid |3.5.1h| | 1 |
| Nearside Rear Trailing arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Trailing arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Service brake: efficiency below requirements |3.7.D.4| | 1 |
| Nearside Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Nearside Rear fog lamp not working |1.3.2b| | 1 |
| Offside Rear fog lamp flickers when tapped lightly by hand |1.1.6d| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Front Side repeater not working |1.4.A.2c| | 1 |
| Offside Front Fluid suspension unit totally deflated |2.4.D.1a| | 1 |
| Nearside Rear Brake linkage has restricted free movement |3.5.1k| | 1 |
| Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Brake pedal spongy |3.3.B.1b| | 1 |
| Nearside Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Centre Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Offside Front Headlamp flickers when tapped lightly by hand |1.2.4c| | 1 |
| Nearside Rear Brake pedal does not operate a brake fitted to each wheel |3.3.A.3| | 1 |
| Battery insecure |1.9.1| | 1 |
| Stop lamp not working |1.2.1b| | 1 |
| Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
| Nearside Rear Brake clevis joint has restricted free movement |3.5.1k| | 1 |
| Nearside Rear Radius arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Fluid suspension unit leaking |2.4.D.2| | 1 |
| Front Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
| Nearside Rear Brake cable has a seized clevis joint pivot |3.5.1c| | 1 |
| Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Fluid suspension unit totally deflated |2.4.D.1a| | 1 |
| Rear Exhaust mounting missing |7.1.1b| | 1 |
| Nearside Front Wheel insecure |4.2.A.1c| | 1 |
| Suspension has inadequate clearance with the bump stop |2.4.A.1a| | 1 |
| Offside Rear Lower Subframe mounting prescribed area is excessively corroded floor pan/sill |2.4.A.3| | 1 |
| Offside Front Side repeater insecure |1.4.A.2b| | 1 |
| Stop lamp|s| all not working offside and nearside |4.3.1 |a| |iii|| | 1 |
| Offside Rear Subframe mounting prescribed area excessively corroded significantly reducing structural strength inner sill |5.3.6 |a| |i|| | 1 |
| Nearside Rear Subframe mounting prescribed area excessively corroded significantly reducing structural strength wheel arch |5.3.6 |a| |i|| | 1 |
| Offside Front front brake recording little or no effort |3.7.B.5a| | 1 |
| Parking brake lever is impeded in its travel |3.1.6c| | 1 |
| Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Fuel cap/sealing device sealing washer missing |7.2.4c| | 1 |
| Front Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Rear Radius arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Front Exhaust mounting missing |7.1.1b| | 1 |
| Offside Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Exhaust tailpipe not capable of allowing the emission probe to be inserted |7.3.D.1| | 1 |
| Offside Front Upper Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Outer Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Inner Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Outer Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Inner Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Direction indicators not working |1.4.A.2c| | 1 |
| Windscreen wiper blade insecure | 1 |
| Nearside Rear Shock absorber has negligible damping effect |2.7.5| | 1 |
| Offside Rear Shock absorber has negligible damping effect |2.7.5| | 1 |
| An item not tested |Manual| | 1 |
| Nearside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Rear Gas suspension has no suspension movement |2.4.D.5| | 1 |
| Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front suspension has excessive movement at a suspension ball joint |2.5.A.1c| | 1 |
| Nearside Outer Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Lower Ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Lower Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Offside Rear Upper Fuel system component leaking |7.2.3| | 1 |
| Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings rear panel holed |6.1.B.2| | 1 |
| Offside Rear Inner Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced floor by jacking point (6.1.1 (c) (i)) | 1 |
| Nearside Headlamp aim beam image too far to the left |1.6.B4| | 1 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Offside Outer Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Outer Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Brake cable has restricted free movement |3.5.1k| | 1 |
| Nearside Rear Brake lever has restricted free movement |3.5.1k| | 1 |
| Offside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Torque/reaction arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Suspension has inadequate clearance with the bump stop |2.4.A.1a| | 1 |
| Centre Statutory seat belt missing |5.1.1| | 1 |
| Offside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Nearside Suspension arm corroded and seriously weakened |2.4.G.1| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Nearside Rear Suspension arm locating pin incorrectly positioned |2.4.G.3a| | 1 |
| Centre Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Rear Fluid suspension unit interconnecting pipe corroded and seriously weakened |2.4.D.3| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear passenger door does not latch securely closed |6.2.B.1a| | 1 |
| Offside Side repeater insecure |1.4.A.2b| | 1 |
| Nearside Rear Sub-frame attachment bracket/mounting corroded and its strength is seriously reduced |2.4.G.1| | 1 |
| Offside Rear Sub-frame attachment bracket/mounting corroded and its strength is seriously reduced |2.4.G.1| | 1 |
| Nearside Rear Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Rear Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Headlamp insecure |1.7.3| | 1 |
| Steering column shaft has excessive end float |2.1.3| | 1 |
| Nearside Front Suspension system inoperative |5.3.5 |a|| | 1 |
| Offside Front Suspension system inoperative |5.3.5 |a|| | 1 |
| Offside Front Upper Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Rear Sub-frame corroded and seriously weakened |5.3.3 |b| |i|| | 1 |
| Rear Suspension system inoperative |5.3.5 |a|| | 1 |
| Nearside Rear Brake cable has restricted free movement |1.1.15 |e|| | 1 |
| Offside Rear Brake cable has restricted free movement |1.1.15 |e|| | 1 |
| Nearside Rear Brake linkage has restricted free movement |1.1.15 |e|| | 1 |
| Offside Rear Brake linkage has restricted free movement |1.1.15 |e|| | 1 |
| Nearside Rear Service brake effort inadequate at a wheel |1.2.1 |a| |i|| | 1 |
| Offside Rear Service brake effort inadequate at a wheel |1.2.1 |a| |i|| | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds default limits |8.2.1.2 |b|| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits |8.2.1.2 |b|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Rear Fluid suspension has no suspension movement |2.4.D.5| | 1 |
| Nearside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Nearside Rear position lamp|s| incomplete |1.1.4a| | 1 |
| Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Rear Rear position lamp|s| incomplete |1.1.4a| | 1 |
| Nearside Rear Brake pipe inadequately supported |3.6.B.1| | 1 |
| Offside Rear Brake pipe inadequately supported |3.6.B.1| | 1 |
| Offside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Parking brake recording little or no effort |3.7.D.3a| | 1 |
| Nearside Rear Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Nearside Rear Fluid suspension unit deteriorated and likely to fail |2.4.D.1b| | 1 |
| Offside Rear Fluid suspension unit deteriorated and likely to fail |2.4.D.1b| | 1 |
| Nearside Rear Radius arm attachment bracket/mounting corroded and its strength is seriously reduced |2.4.G.1| | 1 |
| Nearside Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Exhaust has a part missing |7.1.1a| | 1 |
| Nearside Front Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Offside Rear Braking system leaking |3.6.A.1| | 1 |
| Offside Front Brake hose stretched |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Nearside Rear Anti-roll bar attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Offside Rear Anti-roll bar attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Rear Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Rear fog lamp switch insecure |1.3.1a| | 1 |
| Offside Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Centre Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Statutory seat belt missing |5.1.1| | 1 |