| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 6 |
| Rear parking brake recording little or no effort | 6 |
| Parking brake: efficiency below requirements |3.7.B.7| | 5 |
| Rear brake binding | 5 |
| Service brake: efficiency below requirements |3.7.B.7| | 5 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 5 |
| Headlamp aim out of alignment | 4 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 4 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 3 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Brake hose excessively deteriorated | 2 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Registration plate lamp issues | 2 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 2 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Brake pipe excessively corroded | 2 |
| Nearside Front Lower Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
| Rear brake application uneven | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear Rear position lamp|s| incomplete |1.1.4a| | 1 |
| Nearside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Horn not working |1.6.2a| | 1 |
| Nearside Front Tie bar/rod synthetic bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Tie bar/rod synthetic bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Direction indicators flashing less than 60 times a minute |1.4.A.2g| | 1 |
| Nearside Front Tie bar/rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Tie bar/rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded floor pan area |2.4.A.3| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded floor pan area |2.4.A.3| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded chassis area |2.4.A.3| | 1 |
| Offside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Direction indicators not working |1.4.A.2c| | 1 |
| Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Rear passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 1 |
| Towbar assembly inappropriately repaired |6.6.7| | 1 |
| Nearside Rear Body has a projection caused by corrosion |6.1.C.1| | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| An item not tested |Manual| | 1 |
| Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 1 |
| Offside Obligatory mirror insecure |8.1.1| | 1 |
| Bonnet cannot be secured in the closed position |8.4.1| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Rear Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Seat belt anchorage prescribed area is inadequately repaired |5.2.6| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Rear Mechanical brake component has restricted free movement | 1 |
| Nearside Front Lower Suspension arm has excessive play in a pin/bearing |2.4.G.2| | 1 |
| Nearside Front Upper Suspension arm has excessive play in a pin/bearing |2.4.G.2| | 1 |
| Offside Rear passenger door does not latch securely closed |6.2.B.1a| | 1 |
| Offside Rear An item not tested |Manual| | 1 |
| Nearside Rear Hydraulic brake cylinder leaking hydraulic fluid |3.6.A.1| | 1 |
| Offside Front Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Steering column movement between the shaft and steering wheel |2.1.2b| | 1 |
| Nearside Front All position lamps not working |1.1.A.3b| | 1 |
| Offside Front All position lamps not working |1.1.A.3b| | 1 |
| Nearside Rear All position lamps not working |1.1.A.3b| | 1 |
| Nearside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Offside Rear Direction indicators not in good working order |function impaired| |1.5.A1b| | 1 |
| Offside Front Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Inner Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Inner Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Vehicle structure is damaged, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Vehicle structure has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Braking system leaking |3.6.A.1| | 1 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Rear Upper Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Inner Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Front Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Outer Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings arch |6.1.B.2| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Fuel pipe leaking |7.2.3| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Torque/reaction arm has a deteriorated synthetic bush resulting in excessive movement |2.4.G.2| | 1 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 1 |