| Most common failures | No# failures |
|---|
| Brakes imbalanced across an axle | 21 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 18 |
| Headlamp aim out of alignment | 17 |
| Rear brake binding | 10 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 6 |
| Offside front brake binding |3.7.B.1| | 6 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 6 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 6 |
| Parking brake: efficiency below requirements |3.7.B.7| | 6 |
| Service brake: efficiency below requirements |3.7.B.7| | 6 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 5 |
| Brake hose excessively deteriorated | 5 |
| Brake pipe excessively corroded | 5 |
| Windscreen washer not working | 4 |
| Exhaust emissions carbon monoxide content excessive |8.2.1.2 |b|| | 4 |
| Registration plate lamp issues | 4 |
| Windscreen wiper does not clear the windscreen effectively | 4 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
| Rear brake application uneven | 4 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 3 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Nearside Rear wheel bearing rough when rotated |2.6.1| | 3 |
| Nearside front brake juddering severely |3.7.A.2b| | 3 |
| Nearside Stop lamp not working |1.2.1b| | 3 |
| Stop lamp not working |1.2.1b| | 3 |
| Hazard warning tell tale not working correctly |1.4.B.1e| | 2 |
| Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 2 |
| Nearside Front front brake binding |3.7.B.1| | 2 |
| Offside Front front brake binding |3.7.B.1| | 2 |
| Registration plate issues | 2 |
| Windscreen wiper not working (3.4 (a)) | 2 |
| Nearside rear brake excessively fluctuating |3.7.B.3| | 2 |
| Battery insecure |1.9.1| | 2 |
| Nearside Front Steering rack gaiter split |2.2.D.2d| | 2 |
| Hazard warning switch faulty |1.4.B.1d| | 2 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 2 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Offside Headlamp insecure |1.7.3| | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 2 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 2 |
| Rear parking brake recording little or no effort | 2 |
| Offside Rear wheel bearing has excessive play |2.6.2| | 2 |
| Nearside Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 2 |
| Front brake application uneven | 2 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Nearside front brake binding |3.7.B.1| | 2 |
| Offside Headlamp insecure |4.1.1 |c|| | 1 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Fuel cap/sealing device does not fasten securely by positive means |7.2.4b| | 1 |
| Offside Headlamp aim beam image too far to the right |1.6.B4| | 1 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Stop lamp(s) not working all (4.3.1 (a) (ii)) | 1 |
| Offside rear brake excessively fluctuating |3.7.B.3| | 1 |
| Direction indicator adversely affected by the operation of another lamp both staying on with side lights |1.4.A.2h| | 1 |
| Nearside Headlamp insecure |1.7.3| | 1 |
| Front Exhaust has a major leak of exhaust gases manifold to down pipe |7.1.2| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Direction indicators not working |1.4.A.2c| | 1 |
| Driver`s view of the road through the swept area of the windscreen materially affected by an obstruction wipers not parking |3.1 |a| |ii|| | 1 |
| Offside Rear Service brake grabbing severely |1.2.1 |c|| | 1 |
| Parking brake lever, pawl mechanism pivot|s| retaining device missing both |3.1.4b| | 1 |
| Offside Inner Rear Upper Brake pipe leaking |3.6.A.1| | 1 |
| Steering rack insecure |2.2.B.1a| | 1 |
| Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Brake hose damaged | 1 |
| Front Suspension has inadequate clearance with the bump stop |2.4.A.1a| | 1 |
| Rear Suspension has inadequate clearance with the bump stop |2.4.A.1a| | 1 |
| Nearside Steering column shaft has excessive end float |2.1.3| | 1 |
| Offside Rear An item not tested |Manual| | 1 |
| Offside Front Suspension has inadequate clearance with the bump stop |2.4.A.1a| | 1 |
| Offside Front Seat belt stitching badly frayed |5.2.2b| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded underwing forward section |2.4.A.3| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded underwing forward section |2.4.A.3| | 1 |
| Front Suspension component mounting prescribed area is excessively corroded centre crossmember box section corroded/holed |2.4.A.3| | 1 |
| Front Suspension component mounting prescribed area is excessively corroded valance section holed |2.4.A.3| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded underfloor box sections corroded/ holed |2.4.A.3| | 1 |
| Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength both inner wings/chassis legs |5.3.6 |a| |i|| | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sub frame mount |5.3.6 |a| |i|| | 1 |
| Offside Rear Suspension component insecurely attached rebound strap |5.3.3 |a| |i|| | 1 |
| Central Seat belt anchorage prescribed area strength or continuity significantly reduced O/S |7.1.1 |a| |i|| | 1 |
| Offside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Exhaust mounting missing |7.1.1b| | 1 |
| Fuel system component leaking |7.2.3| | 1 |
| Mechanical brake component has restricted free movement | 1 |
| Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside rear parking |secondary| brake grabbing severely |3.7.B.6b| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded inner sill |2.4.A.3| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded inner sill |2.4.A.3| | 1 |
| Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Exhaust has a major leak of exhaust gases manifold |7.1.2| | 1 |
| Offside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Brake cable has a seized clevis joint pivot |3.5.1c| | 1 |
| Offside Rear Brake cable has a seized clevis joint pivot |3.5.1c| | 1 |
| Offside Brake cable has restricted free movement |3.5.1k| | 1 |
| Nearside Brake cable has restricted free movement |3.5.1k| | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Horn not working |7.7 |a| |ii|| | 1 |
| Oil leaking excessively from engine |8.4.1 |a| |i|| | 1 |
| Nearside Rear Service brake lagging in operation |1.2.1 |d|| | 1 |
| Nearside Front Braking system leaking |3.6.A.1| | 1 |
| Fluid suspension has no suspension movement |2.4.D.5| | 1 |
| Offside Parking brake lever defective so that it cannot be satisfactorily operated |3.1.3c| | 1 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Inner Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
| Nearside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Offside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Nearside Front Brake hose inappropriately repaired |3.6.A.3| | 1 |
| Offside Rear rear brake grabbing severely |3.7.A.5b| | 1 |
| Nearside rear brake juddering severely |3.7.A.5b| | 1 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Front Lower Suspension component ball joint likely to become detached Screw cup loose on hub threads[ worn hub threads?] (5.3.4 (a) (ii)) | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Rear Sub-frame attachment rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Steering rack gaiter missing or no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Nearside Front front brake juddering severely |3.7.A.2b| | 1 |
| Offside Rear Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Front Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Nearside Rear Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Hazard warning lamps inoperative |1.4.B.1b| | 1 |
| Offside Front Position lamp not working |4.2.1 |a|| | 1 |
| All direction indicators not working |4.4.1 |a| |ii|| | 1 |
| Nearside Front Steering rack has excessive free play detected at the steering wheel |steering rack fitted| |2.3 |a| |i|| | 1 |
| Offside Front Sub-frame corroded and seriously weakened |5.3.3 |b| |i|| | 1 |
| Nearside Rear Subframe mounting prescribed area excessively corroded significantly reducing structural strength outer sill |5.3.6 |a| |i|| | 1 |
| Offside Rear Service brake has no recorded effort at a wheel |1.2.1 |a| |ii|| | 1 |
| Offside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Rear Service brake lagging in operation (1.2.1 (d)) | 1 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 1 |
| Offside Rear Suspension unit damaged or deteriorated and function affected (5.3.5 (b) (i)) | 1 |
| Offside Rear Brake lever has restricted free movement (1.1.15 (e)) | 1 |
| Nearside Front Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Rear Brake pipe fouled by moving parts |3.6.B.2a| | 1 |
| Offside Front Suspension component mounting prescribed area is deliberately modified which significantly reduces the original strength |2.4.A.3| | 1 |
| Offside Rear Brake linkage has restricted free movement |3.5.1k| | 1 |
| Front Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Direction indicators not working |1.4.A.2c| | 1 |
| Stop lamp not working both |1.2.1b| | 1 |
| Front brake excessively fluctuating | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| front brakes release unevenly |3.7.B.4| | 1 |
| Front Headlamps matched pair are incorrectly positioned |1.7.3| | 1 |
| Front Steering rack damaged and unserviceable |2.2.C.1d| | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
| Stop lamp|s| all not working |4.3.1 |a| |iii|| | 1 |
| Nearside Front Position lamp light intensity significantly reduced |4.2.3 |a| |ii|| | 1 |
| Offside Rear Wheel bearing has excessive play |5.1.3 |a| |i|| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Inner Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Offside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Nearside Front An item not tested |Manual| | 1 |
| Position lamp switch faulty |1.1.A.1| | 1 |
| Headlamp switch faulty |1.7.1| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Sub-frame attachment bracket/mounting corroded and its strength is seriously reduced |2.4.G.1| | 1 |
| Steering system excessively tight |2.2.D.1| | 1 |
| Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Nearside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Front Exhaust system not adequately supported |7.1.1| | 1 |
| Front Position lamp not working nearside and offside |4.2.1 |a|| | 1 |
| Nearside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength front and rear of inner arch |5.3.6 |a| |i|| | 1 |
| Nearside Front Steering rack has excessive free play detected at the steering wheel |steering rack fitted| steering arm |2.3 |a| |i|| | 1 |
| Nearside Front Wheel bearing has excessive play |5.1.3 |a| |i|| | 1 |
| Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| rear brake recording little or no effort |3.7.B.5a| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Nearside Inner Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Outer Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Suspension arm locating pin locking device missing |2.4.G.3b| | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Inner Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |