| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 15 |
| Parking brake: efficiency below requirements |3.7.B.7| | 11 |
| Registration plate lamp issues | 10 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 8 |
| Rear brake binding | 6 |
| Rear parking brake recording little or no effort | 6 |
| Windscreen wiper does not clear the windscreen effectively | 6 |
| Brakes imbalanced across an axle | 5 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 4 |
| Service brake: efficiency below requirements |3.7.B.7| | 4 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
| Windscreen washer not working | 4 |
| Registration plate issues | 3 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 3 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 3 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 3 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 3 |
| Nearside Front Steering rack gaiter split |2.2.D.2d| | 2 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 2 |
| Nearside Front Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Nearside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 2 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 2 |
| Rear Exhaust system not adequately supported |7.1.1| | 2 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Exhaust emissions hydrocarbon content excessive |8.2.1.2 |b|| | 2 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 2 |
| Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 2 |
| Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 2 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Parking brake lever has no reserve travel |3.1.6b| | 2 |
| Brake pipe excessively corroded | 2 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Fuel cap/sealing device missing |6.1.3 |b| |i|| | 2 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill |5.3.6 |a| |i|| | 2 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 2 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Power steering component|s| leaking |2.3.3b| | 2 |
| Front brake disc in such a condition that it is seriously weakened | 2 |
| Horn not working |1.6.2a| | 2 |
| Offside Headlamp not working on main beam |1.7.5a| | 2 |
| Exhaust system not adequately supported back box |7.1.1| | 1 |
| Offside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Brake hose excessively deteriorated | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Front Steering rack gaiter missing or no longer prevents the ingress of dirt gaiter insecure (2.1.3 (g) (ii)) | 1 |
| Nearside Rear Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Power steering pump leaking from a failed component |2.3.3b| | 1 |
| Nearside Headlamp cleaning device inoperative |1.7.2| | 1 |
| Offside Headlamp cleaning device inoperative |1.7.2| | 1 |
| Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Headlamp aim projected beam image is obviously incorrect offside & nearside aims showing kick-up to the right (4.1.2 (c)) | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Rear Brake pipe fouled by moving parts |3.6.B.2a| | 1 |
| Nearside Front brake caliper securing device missing |3.5.1j| | 1 |
| Nearside Fuel pipe leaking |7.2.3| | 1 |
| Nearside Rear wheel cylinder has restricted free movement |3.5.1k| | 1 |
| Offside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Inner Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Inner Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Outer Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded Outer. Sill |5.2.6| | 1 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded Inner. Sill |5.2.6| | 1 |
| Offside Rear Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Brake pedal anti-slip provision missing (1.1.2 (c)) | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Rear fog lamp light intensity significantly reduced (4.5.4 (a)) | 1 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Exhaust system insecure (6.1.2 (a)) | 1 |
| Emissions not tested (8.2.1.2 (d)) | 1 |
| Fuel pipe insecure (6.1.3 (a) (i)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Rear brake application uneven | 1 |
| Windscreen wiper not working motor not up to standards works very slow and holts on screen unable to vary speed |3.4 |a|| | 1 |
| Offside Front Lower Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
| Rear fog lamp switch inoperative (4.5.3 (a) (ii)) | 1 |
| Nearside Front Front passenger door cannot be opened from inside the vehicle (6.2.3 (a)) | 1 |
| Front passenger door cannot be opened from inside the vehicle (6.2.3 (a)) | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Power steering ram|s| leaking from a failed component |2.3.3b| | 1 |
| Offside Front Road wheel fixing missing |5.2.1 |a| |i|| | 1 |
| Offside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
| Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Oil leaking excessively from engine from engine (8.4.1 (a) (i)) | 1 |
| Offside Front Suspension component insecurely attached lower s/absorber locking washer not secure locked (5.3.3 (a) (i)) | 1 |
| Central Rear Seat belt likely to become detached in the event of a collision seat belt middle straps not connecting in its point (7.1.1 (a) (ii)) | 1 |
| Nearside Rear Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Front Seat belt buckle not functioning as intended |7.1.2 |d|| | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill |5.3.6 |a| |i|| | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sill |5.3.6 |a| |i|| | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sill/outer wheel arch |5.3.6 |a| |i|| | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner wheel arch |5.3.6 |a| |i|| | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner wheel arch |5.3.6 |a| |i|| | 1 |
| Nearside Rear Upper Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner wheel arch by fuel filler neck |5.3.6 |a| |i|| | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength of boot floor |5.3.6 |a| |i|| | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength of boot floor |5.3.6 |a| |i|| | 1 |
| Nearside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced inner wheel arch |7.1.1 |a| |i|| | 1 |
| Offside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced inner wheel arch |7.1.1 |a| |i|| | 1 |
| Nearside Rear Suspension component pin or bush excessively worn lower shock absorber bush |5.3.4 |a| |i|| | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Rear Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
| Exhaust emits excessive dense blue smoke during acceleration |7.3.A.2c| | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Offside Rear Other passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Horn not working (7.7 (a)) | 1 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Exhaust has a major leak of exhaust gases at tail box (6.1.2 (a)) | 1 |
| Nearside Rear Service brake has no recorded effort at a wheel (1.2.1 (a) (ii)) | 1 |
| Fuel pipe leaking |7.2.3| | 1 |
| Nearside Front Fuel hose leaking |7.2.3| | 1 |
| Nearside Rear Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Rear Mechanical brake component has restricted free movement | 1 |
| Centre Fuel system component insecure |7.2.1| | 1 |
| Offside Front Vehicle structure has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Vehicle structure has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Inner Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Direction indicators not working |1.4.A.2c| | 1 |
| Offside Direction indicators not working |1.4.A.2c| | 1 |
| Nearside Outer Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Direction indicators not working |1.4.A.2c| | 1 |
| Horn not working |7.7 |a| |ii|| | 1 |
| Offside Front Windscreen wiper not working (3.4 (a)) | 1 |
| Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
| Nearside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Offside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Offside Rear Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Steering rack damaged and unserviceable |2.2.C.1d| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Front Ball joint has excessive play |2.2.B.1f| | 1 |
| Bonnet cannot be secured in the closed position |3.1 |b| |i|| | 1 |
| Offside Obligatory mirror insecure |3.3 |b| |ii|| | 1 |
| Central Rear Seat belt missing clasp |7.1.2 |a|| | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sill |5.3.6 |a| |i|| | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner to outer sill |5.3.6 |a| |i|| | 1 |
| Offside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced inner wing |7.1.1 |a| |i|| | 1 |
| Nearside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced inner wing |7.1.1 |a| |i|| | 1 |
| Nearside Front Seat belt anchorage prescribed area strength or continuity significantly reduced floor |7.1.1 |a| |i|| | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength boot floor |5.3.6 |a| |i|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Nearside Rear Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Rear Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Battery insecure |1.9.1| | 1 |
| Offside Rear Suspension component mounting prescribed area is deliberately modified which significantly reduces the original strength |2.4.A.3| | 1 |
| Steering column flexible coupling is excessively deteriorated |2.1.5| | 1 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Power steering ram|s| leaking from a failed component |2.3.3b| | 1 |
| Rear fog lamp switch faulty |1.3.1a| | 1 |
| Steering column movement between the shaft and steering wheel |2.1.2b| | 1 |
| Nearside Front Headlamp aim beam image too far to the right |1.6.B4| | 1 |