| Most common failures | No# failures |
|---|
| Parking brake: efficiency below requirements |3.7.B.7| | 16 |
| Brakes imbalanced across an axle | 11 |
| Rear parking brake recording little or no effort | 9 |
| Service brake: efficiency below requirements |3.7.B.7| | 8 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 6 |
| Registration plate lamp issues | 5 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 4 |
| Brake hose excessively deteriorated | 4 |
| Headlamp aim out of alignment | 4 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 3 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 3 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 3 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 3 |
| Nearside Front Steering rack gaiter split |2.2.D.2d| | 2 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 2 |
| Rear brake binding | 2 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Offside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Front Side repeater not working |1.4.A.2c| | 2 |
| Offside Rear Lower Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Rear Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Brake servo defective or ineffective (1.1.10 (a) (i)) | 1 |
| Windscreen washer not working | 1 |
| Windscreen wiper not working (3.4 (a)) | 1 |
| Nearside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Lower Steering column flexible coupling is excessively deteriorated (2.2.2 (c)) | 1 |
| Front Fuel pipe leaking |7.2.3| | 1 |
| Offside Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Offside Rear Fuel pipe union leaking |7.2.3| | 1 |
| Nearside Front Headlamp missing |1.7.3| | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Nearside Front Tie bar/rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Headlamp insecure |1.7.3| | 1 |
| Nearside Headlamp insecure |1.7.3| | 1 |
| Offside Front Brake actuating linkage mounting prescribed area is excessively corroded |3.3.A.2| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Side repeater incorrect colour |1.4.A.2f| | 1 |
| Nearside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt nearside of the centre |2.2.C.1c| | 1 |
| Nearside Subframe mounting prescribed area is excessively corroded Outer sill, marked yellow |2.4.A.3| | 1 |
| Offside Subframe mounting prescribed area is excessively corroded Outer sill, marked yellow |2.4.A.3| | 1 |
| Nearside Suspension spring mounting prescribed area is excessively corroded Outer sill, marked yellow |2.4.A.3| | 1 |
| Offside Suspension spring mounting prescribed area is excessively corroded Outer sill, marked yellow |2.4.A.3| | 1 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded Inner wheel arch, marked yellow
|5.2.6| | 1 |
| Nearside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Lower Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Horn not working |1.6.2a| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Nearside Rear Service brake has no recorded effort at a wheel |1.2.1 |a| |ii|| | 1 |
| Nearside Front Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Stop lamp not working nj/side rear |1.2.1b| | 1 |
| Stop lamp not working o/side rear |1.2.1b| | 1 |
| Bonnet cannot be secured in the closed position |8.4.1| | 1 |
| Offside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Exhaust engine idle speed too high not enough fuel |7.3.A.2a| | 1 |
| Offside Rear Rear fog lamp missing |1.3.2a| | 1 |
| Nearside Front Drag link end ball joint dust cover insecure so that it no longer prevents the ingress of dirt rear cover marked in yellow |2.2.C.1c| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Brake pipe excessively corroded | 1 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Inner Front Body has a projection caused by corrosion |6.1.C.1| | 1 |
| Stop lamp remains on when the brakes are released | 1 |
| Front front brake binding |3.7.B.1| | 1 |
| Offside Rear front brake binding |3.7.B.1| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Rear Shock absorbers has a serious fluid leak Both (5.3.2 (b)) | 1 |
| Nearside Rear Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Nearside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Exhaust emissions hydrocarbon content excessive (8.2.1.2 (b)) | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Brake pedal creeps down while the pedal is held under pressure |3.3.B.1a| | 1 |
| Offside Front Radius arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Service brake efficiency less than 50% of the required value (1.2.2 (a) (ii)) | 1 |
| Offside Integral body structure strengthening plate or fastening so insecure that structural rigidity is seriously reduced front to rear floor patch repairs. (6.1.1 (b) (ii)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Brake cable insecure (1.1.15 (c)) | 1 |
| Nearside Integral body structure strengthening plate or fastening so insecure that structural rigidity is seriously reduced the front to rear floor to outer sill patch repairs. (6.1.1 (b) (ii)) | 1 |
| Windscreen wiper does not clear the windscreen effectively | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Intermediate drop arm pivot housing casing has relative movement to chassis/bodywork (2.1.2 (a) (ii)) | 1 |
| Offside Front Steering component mounting prescribed area is excessively corroded Inner arch (2.1.2 (e) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Coil cup (5.3.6 (a) (i)) | 1 |
| Steering column top mounting bracket insecure |2.1.2d| | 1 |
| Exhaust emits dense blue smoke at idle |7.3.A.2b| | 1 |
| Nearside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Offside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Offside Front Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Steering component is not secure to the vehicle structure |2.2.B.1a| | 1 |