Most common failures | No# failures |
---|
Parking brake: efficiency below requirements |3.7.B.7| | 35 |
Registration plate lamp issues | 25 |
Rear parking brake recording little or no effort | 25 |
Brakes imbalanced across an axle | 19 |
Headlamp aim out of alignment | 14 |
Windscreen wiper does not clear the windscreen effectively | 14 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 12 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 10 |
Nearside Stop lamp not working |1.2.1b| | 10 |
Service brake: efficiency below requirements |3.7.B.7| | 10 |
Rear brake binding | 8 |
Brake hose excessively deteriorated | 8 |
Offside Stop lamp not working |1.2.1b| | 8 |
Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 7 |
Parking brake lever has no reserve travel |3.1.6b| | 6 |
Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 6 |
Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 5 |
Exhaust has a major leak of exhaust gases |7.1.2| | 5 |
Stop lamp not working |1.2.1b| | 5 |
Rear brake application uneven | 5 |
Nearside Headlamp not working on main beam |1.7.5a| | 5 |
Hazard warning lamps inoperative |1.4.B.1b| | 4 |
Centre Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
Nearside front brake binding |3.7.B.1| | 3 |
Nearside Rear Stop lamp not working |1.2.1b| | 3 |
Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
Horn not working |1.6.2a| | 3 |
Parking brake efficiency below requirements |1.4.2 |a| |i|| | 3 |
Parking brake: efficiency below requirements |3.7.C.1b| | 3 |
Direction indicators not working |1.4.A.2c| | 3 |
Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 3 |
Offside Rear rear brake recording little or no effort |3.7.B.5a| | 3 |
Offside Headlamp not working on dipped beam |1.7.5a| | 3 |
Nearside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 3 |
All position lamps adversely affected by the operation of another lamp |1.1.A.3f| | 3 |
Nearside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
Hazard warning switch faulty |1.4.B.1d| | 2 |
Nearside rear parking |secondary| brake grabbing severely |3.7.B.6b| | 2 |
Brake pipe inadequately clipped |3.6.B.1| | 2 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
Offside Front Braking system leaking |3.6.A.1| | 2 |
Nearside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
Fuel pipe leaking |7.2.3| | 2 |
Front brake application uneven | 2 |
Offside Front Headlamp not working on main beam |1.7.5a| | 2 |
Front Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Offside Headlamp not working on main beam |4.1.1 |a| |ii|| | 2 |
Nearside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 2 |
Offside Front Direction indicator not working |1.4.A.2c| | 2 |
Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Offside Front Seat belt retracting mechanism defective |5.2.5b| | 2 |
Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Brake hose has insufficient room to move | 2 |
Offside Rear Direction indicator not working |1.4.A.2c| | 2 |
Offside Headlamp not working on main beam |1.7.5a| | 2 |
Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
Offside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Brake pipe excessively corroded | 2 |
Offside rear brake recording little or no effort |3.7.B.5a| | 2 |
Nearside Inner Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Offside Inner Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Registration plate issues | 2 |
Nearside Rear passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 2 |
Offside front brake binding |3.7.B.1| | 2 |
Offside Front Upper Intermediate drop arm insecure |2.2.B.1a| | 1 |
Offside Front Brake hose leaking |3.6.A.1| | 1 |
Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Headlamp insecure |1.7.3| | 1 |
Nearside Rear Brake pedal excessively corroded |3.3.A.1a| | 1 |
Offside Rear Brake pedal excessively corroded |3.3.A.1a| | 1 |
Rear Exhaust has a major leak of exhaust gases box |7.1.2| | 1 |
Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 1 |
Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
Speedometer clearly inoperative |6.7.2| | 1 |
Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
Offside Rear brake caliper leaking |3.6.A.1| | 1 |
Offside Steering locking device missing |2.2.C.1g| | 1 |
Stop lamp|s| all not working |4.3.1 |a| |iii|| | 1 |
Nearside Rear Service brake effort inadequate at a wheel |1.2.1 |a| |i|| | 1 |
Nearside Parking brake inoperative on one side |1.4.1 |a|| | 1 |
Nearside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
Braking system leaking |3.6.A.1| | 1 |
Nearside Front Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Rear Hydraulic brake cylinder leaking hydraulic fluid |3.6.A.1| | 1 |
Nearside Front Braking system leaking |3.6.A.1| | 1 |
Front suspension locking device missing |2.5.A.4| | 1 |
Nearside Outer Body or chassis has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Outer Body or chassis has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
Offside Front Upper Ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Nearside Front Lower Ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Offside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
Brake performance not tested |3.7.A.1| | 1 |
Service brake: efficiency below requirements |3.7.C.1a| | 1 |
Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Exhaust emits visible black smoke at idle |7.3.A.2b| | 1 |
rear parking |secondary| brakes imbalanced | 1 |
Brake pedal anti-slip provision missing |3.3.A.1b| | 1 |
Nearside Front position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Nearside Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside Rear brake disc excessively scored |3.5.1h| | 1 |
Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Front Steering locking device missing |2.2.C.1g| | 1 |
All position lamps not working |4.2.1 |a|| | 1 |
Nearside Headlamp light source and lamp not compatible |4.1.4 |c|| | 1 |
Offside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
Nearside Headlamp not working on main beam |4.1.1 |a| |ii|| | 1 |
Central Exhaust has a major leak of exhaust gases center box and pipe |6.1.2 |a|| | 1 |
Offside Front Vehicle structure is deformed and structural rigidity is significantly reduced floor to wheel arch |6.1.1 |a| |i|| | 1 |
Offside Rear Suspension component mounting prescribed area excessively damaged significantly reducing structural strength |5.3.6 |a| |i|| | 1 |
Offside Suspension component mounting prescribed area excessively corroded significantly reducing structural strength floor to seal |5.3.6 |a| |i|| | 1 |
Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
Offside Front An item not tested |Manual| | 1 |
Hazard warning tell tale not working correctly |1.4.B.1e| | 1 |
Offside Rear Coil spring mounting corroded and seriously weakened |2.4.C.3c| | 1 |
Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
Offside Steering locking device missing Track rod end. (2.1.3 (d)) | 1 |
Nearside Front Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
Windscreen washer not working | 1 |
Nearside Front Upper Suspension component ball joint excessively worn |5.3.4 |a| |i|| | 1 |
Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Offside Front Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Front Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
Exhaust mounting missing |7.1.1b| | 1 |
Rear Service brake has no recorded effort at a wheel both (1.2.1 (a) (ii)) | 1 |
Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
Nearside Rear wheel bearing rough when rotated |2.6.1| | 1 |
Offside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Steering box insecure |2.2.B.1a| | 1 |
Offside Rear Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Brake master cylinder fluid level below minimum level |3.6.G.1e| | 1 |
Nearside Rear Brake performance not tested |3.7.A.1| | 1 |
Driver`s seat insecure |6.2.A.1| | 1 |
Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Front Headlamp not working on main beam both |1.7.5a| | 1 |
Centre Seat belt anchorage prescribed area is excessively corroded outer sill |5.2.6| | 1 |
Offside Rear Suspension component mounting prescribed area is excessively corroded outer sill |2.4.A.3| | 1 |
Nearside Rear Suspension spring mounting prescribed area is excessively corroded chassis section |2.4.A.3| | 1 |
Offside Rear Suspension spring mounting prescribed area is excessively corroded chassis section |2.4.A.3| | 1 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded inner chassis section |2.4.A.3| | 1 |
Offside Rear Suspension component mounting prescribed area is excessively corroded inner chassis section |2.4.A.3| | 1 |
Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Offside Driver`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
Nearside Front Upper Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Horn not working |7.7 |a| |ii|| | 1 |
Nearside Front Steering linkage ball joint ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
Offside Front Steering linkage ball joint ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
Parking |secondary brake| on a single line braking system imbalanced across an axle Axle 1 |1.3.1 |b| |i|| | 1 |
Nearside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
Offside Rear brake disc contaminated by oil |3.5.1h| | 1 |
Nearside Rear brake disc contaminated by oil |3.5.1h| | 1 |
Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Offside Seat belt retracting mechanism defective |5.2.5b| | 1 |
Nearside Seat belt retracting mechanism defective |5.2.5b| | 1 |
Front Front position lamp|s| not working |1.1.A.3b| | 1 |
Front Front position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
Rear Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Offside Front Suspension component mounting prescribed area is excessively corroded chassis |2.4.A.3| | 1 |
Nearside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Nearside Rear Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
Offside Rear Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
Nearside Rear Lower Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
Offside Rear Lower Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
Offside Rear Hydraulic brake calliper leaking (1.1.16 (b) (i)) | 1 |
Offside Front Brake hose twisted |3.6.B.4c| | 1 |
Rear Brake pipe inadequately supported |3.6.B.1| | 1 |
Nearside Headlamp adversely affected by the operation of another lamp dipped beam dims on main beam |1.7.5c| | 1 |
Offside Rear Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
Offside Rear Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
Nearside Intermediate drop arm insecure |2.2.B.1a| | 1 |
Nearside Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 1 |
Rear Exhaust system not adequately supported |7.1.1| | 1 |
Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings front and rear floors |6.1.B.2| | 1 |
Nearside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
Rear Body insecure and dangerous to other road users bumper |6.1.B.1b| | 1 |
Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Offside Inner Front Headlamp not working on main beam |1.7.5a| | 1 |
Offside Seat belt anchorage prescribed area strength or continuity significantly reduced |7.1.1 |a| |i|| | 1 |
Service brake efficiency below requirements |1.2.2 |a| |i|| | 1 |
Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
Nearside Outer Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Parking brake: efficiency below requirements |3.7.D.4| | 1 |
Brake pedal creeps down when held under pressure |3.3.B.1a| | 1 |
Offside Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
Offside Rear Parking brake inoperative on one side lower effort (1.4.1 (a)) | 1 |
Parking brake lever has excessive movement indicating incorrect adjustment no reserve travel (1.1.6 (c)) | 1 |
Nearside Rear Rear reflector missing (4.8.2 (a) (ii)) | 1 |
Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
Parking (secondary brake) on a single line braking system imbalanced across an axle Axle 1 (1.3.1 (b) (i)) | 1 |
Nearside Front Ball joint has excessive play |2.2.B.1f| | 1 |
Offside Front Ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
Offside Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
Offside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
Offside Rear Tie bar/rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
Offside Rear Wheel stud|s| missing |4.2.A.1e| | 1 |
Brake fluid warning lamp inoperative |3.6.G.2| | 1 |
Offside Front Upper Front suspension has a suspension upper ball joint securing nut loose bolt broken |2.5.B.1a| | 1 |
Nearside Front Steering pivot point has excessive play |2.2.B.1g| | 1 |
Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside front brake juddering severely |3.7.A.2b| | 1 |
Offside front brake juddering severely |3.7.A.2b| | 1 |
An item not tested |Manual| | 1 |
Brake servo leaking |3.6.C.1c| | 1 |
Offside Front Steering linkage ball joint ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
Nearside Rear Outer Suspension component mounting prescribed area excessively damaged significantly reducing structural strength and offside , behind chrome trims (5.3.6 (a) (i)) | 1 |
Nearside Inner Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Inner Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Nearside Inner Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Offside Inner Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
Offside Rear Front position lamp|s| not working |1.1.A.3b| | 1 |
Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Windscreen has damage | 1 |
Position lamp switch faulty |1.1.A.1| | 1 |
Nearside Front position lamp|s| not in good working order |function impaired| |1.1.4a| | 1 |
Nearside Rear Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Rear Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
front brakes release unevenly |3.7.B.4| | 1 |
Nearside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
Offside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
Offside Front Upper Suspension component ball joint excessively worn |5.3.4 |a| |i|| | 1 |