| Most common failures | No# failures |
|---|
| Parking brake: efficiency below requirements |3.7.B.7| | 29 |
| Rear parking brake recording little or no effort | 18 |
| Brakes imbalanced across an axle | 18 |
| Rear brake binding | 13 |
| Windscreen wiper does not clear the windscreen effectively | 13 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 8 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 7 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 7 |
| Registration plate lamp issues | 7 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 6 |
| Brake pipe excessively corroded | 5 |
| Horn not working |1.6.2a| | 5 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 5 |
| Headlamp aim out of alignment | 5 |
| Offside Headlamp not working on main beam |1.7.5a| | 4 |
| Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 4 |
| Offside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 3 |
| Parking brake lever has no reserve travel |3.1.6b| | 3 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 3 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Power steering pump leaking from a failed component |2.3.3b| | 3 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Nearside Rear Braking system leaking |3.6.A.1| | 3 |
| Nearside Stop lamp not working |1.2.1b| | 3 |
| Offside Rear Side repeater not working |1.4.A.2c| | 3 |
| Rear Mechanical brake component has restricted free movement | 3 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 3 |
| Rear brake application uneven | 3 |
| Brake hose excessively deteriorated | 2 |
| Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 2 |
| Nearside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
| Nearside Rear passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 2 |
| Offside Rear passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 2 |
| Nearside Front Wheel nut|s| missing |4.2.A.1e| | 2 |
| Offside Rear Wheel nut|s| missing |4.2.A.1e| | 2 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Service brake: efficiency below requirements |3.7.B.7| | 2 |
| Offside Front Side repeater not working |1.4.A.2c| | 2 |
| Offside Rear Braking system leaking |3.6.A.1| | 2 |
| Power steering inoperative |2.3.3a| | 2 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 2 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 2 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Power steering component|s| leaking |2.3.3b| | 2 |
| Offside Front Direction indicator not working |1.4.A.2c| | 2 |
| Nearside Headlamp not working on main beam |1.7.5a| | 2 |
| Central Exhaust system not adequately supported |7.1.1| | 2 |
| Windscreen washer not working | 2 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Torsion bar attachment bracket corroded and seriously weakened |2.4.E.4c| | 1 |
| Offside Torsion bar attachment bracket corroded and seriously weakened |2.4.E.4c| | 1 |
| Nearside Brake linkage has restricted free movement |3.5.1k| | 1 |
| Nearside Rear Brake linkage has restricted free movement |3.5.1k| | 1 |
| Speedometer cannot be illuminated. |6.7.3| | 1 |
| Offside Front Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Nearside Front Seat belt anchorage loose (7.1.1 (b)) | 1 |
| Brake pivot locking device missing |3.5.1l| | 1 |
| Windscreen wiper blade insecure | 1 |
| Windscreen washer control missing |8.2.1a| | 1 |
| Fuel cap/sealing device does not fasten securely by positive means |7.2.4b| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Offside Rear Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Nearside Rear Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Offside Direction indicators flashing less than 60 times a minute |1.4.A.2g| | 1 |
| Offside Front Lower Front suspension ball joint dust cover insecure so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Inner Track rod end ball pin shank loose |2.2.B.1c| | 1 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Nearside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Nearside Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Inner Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Inner Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Parking brake lever defective so that it cannot be satisfactorily operated |3.1.3c| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Centre Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Centre Fuel pipe leaking |7.2.3| | 1 |
| Offside Outer Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Front Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear Inner Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings behind rear arch |6.1.B.2| | 1 |
| Fuel cap/sealing device sealing washer deteriorated |7.2.4c| | 1 |
| Offside Lower Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Driver`s seat insecure |6.2.A.1| | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 1 |
| Offside Front brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Front Shock absorber insecure |2.7.2b| | 1 |
| Rear Brake rod locking device insecure |3.5.1l| | 1 |
| Nearside Rear Shock absorber missing |2.7.1b| | 1 |
| Position lamp switch faulty |1.1.A.1| | 1 |
| Nearside Rear Leaf spring deteriorated and seriously weakened |2.4.B.1a| | 1 |
| Offside Rear Leaf spring deteriorated and seriously weakened |2.4.B.1a| | 1 |
| Rear Parking brake lever is impeded in its travel |3.1.6c| | 1 |
| Nearside Front brake caliper has restricted free movement |3.5.1k| | 1 |
| Offside Front brake caliper has restricted free movement |3.5.1k| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Fuel hose leaking |7.2.3| | 1 |
| Nearside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Inner Front Upper Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Rear Brake pipe leaking |3.6.A.1| | 1 |
| Power steering pipe|s| or hose|s| excessively damaged |2.3.2| | 1 |
| Offside Front Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Outer Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Headlamp aim not tested |1.8.A.1c| | 1 |
| Rear An item not tested |Manual| | 1 |
| Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Outer Vehicle structure has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear An item not tested |Manual| | 1 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Offside Outer Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Inner Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Inner Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Inner Front Subframe mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Offside Outer Front Subframe mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Nearside Outer Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Leaf spring anchor bracket corroded and seriously weakened |2.4.B.6d| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Nearside Headlamp not working on main beam |4.1.1 |a| |ii|| | 1 |
| Offside Headlamp not working on main beam |4.1.1 |a| |ii|| | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment |1.1.6 |c|| | 1 |
| Offside Front Power steering pipe|s| or hose|s| leaking |2.3.3b| | 1 |
| Front Power steering pipe|s| or hose|s| leaking |2.3.3b| | 1 |
| Nearside Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Front brake application uneven | 1 |
| Brake pedal creeps down when held under pressure |3.3.B.1a| | 1 |
| Offside Front Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Brake hose damaged | 1 |
| Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Upper Suspension arm pin or bush excessively worn both bushings (5.3.4 (a) (i)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Headlamp not working on dipped beam both (4.1.1 (a) (ii)) | 1 |
| Exhaust emits clearly visible black smoke during acceleration |7.3.A.2c| | 1 |
| Exhaust engine idle speed too high |7.3.A.2a| | 1 |
| Nearside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Front Statutory seat belt missing |5.1.1| | 1 |
| Offside Front Statutory seat belt missing |5.1.1| | 1 |
| Offside Front Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Nearside Rear Side repeater not working |1.4.A.2c| | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis leg by spring mount (5.3.6 (a) (i)) | 1 |
| Power steering component leaking (2.1.5 (a)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength floor by spring mount (5.3.6 (a) (i)) | 1 |
| Power steering pump leaking from a failed component (2.3.3b) | 1 |
| Parking brake: efficiency below requirements (3.7.B.7) | 1 |
| Offside Front Vehicle structure has excessive corrosion which adversely affects braking or steering (6.1.A.1) | 1 |
| Power steering pump leaking from a failed component steering box leaking (2.3.3b) | 1 |
| Offside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Front brake excessively fluctuating | 1 |
| Nearside Front Front position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Rear Front position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Front Tie bar/rod rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Upper Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded outer sill |5.2.6| | 1 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded outer sill |5.2.6| | 1 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded outer sill |2.4.A.3| | 1 |
| Nearside Front Side repeater not working |1.4.A.2c| | 1 |
| Brake pedal anti-slip provision worn smooth |3.3.A.1b| | 1 |
| Offside Front Lower Suspension arm ball joint dust cover insecure so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Direction indicator not working |1.4.A.2c| | 1 |
| Brake master cylinder leaking hydraulic fluid |3.6.G.1f| | 1 |
| Power steering pipe|s| or hose|s| leaking |2.3.3b| | 1 |
| Offside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Direction indicators not working |1.4.A.2c| | 1 |
| Stop lamp not working |1.2.1b| | 1 |
| Offside Tie bar/rod rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| All position lamps not working |1.1.A.3b| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Rear Exhaust mounting missing |7.1.1b| | 1 |
| Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings valance |6.1.B.2| | 1 |
| Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings sill at front and rear |6.1.B.2| | 1 |
| Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings front of sill |6.1.B.2| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings inner wheel arch |6.1.B.2| | 1 |
| Steering system excessively tight |2.2.D.1| | 1 |
| Offside Front Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Body has a sharp edge caused by corrosion Off side rear wing |6.1.C.1| | 1 |
| Body has a sharp edge caused by corrosion Off side rear door |6.1.C.1| | 1 |
| Body has a sharp edge caused by corrosion Rear bumper |6.1.C.1| | 1 |
| Offside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt Outer |2.4.G.2| | 1 |
| Power steering pump drive system defective |2.3.6| | 1 |
| Nearside Front Body has a projection caused by damage trim |6.1.C.1| | 1 |
| Nearside Front Inner Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Offside Rear Battery insecure |1.9.1| | 1 |
| Offside Front Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Offside Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Exhaust emits excessive dense blue smoke during acceleration |7.3.A.2c| | 1 |
| Offside Front Anti-roll bar linkage insecurely attached |5.3.3 |a| |i|| | 1 |
| Nearside Outer Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Fuel tank leaking |7.2.3| | 1 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Inner Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Inner Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Centre Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Direction indicators flashing less than 60 times a minute |1.4.A.2g| | 1 |
| Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front position lamp|s| has less than 50% of the light sources illuminating |1.1.A.3b| | 1 |
| Horn not loud enough to be heard by another road user |1.6.2b| | 1 |
| Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Nearside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Front Inner Drag link end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Front Inner Drag link end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Rear Rear position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Service brake: efficiency below requirements |3.7.D.4| | 1 |
| Nearside Front Subframe mounting prescribed area is excessively corroded inner sill |2.4.A.3| | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Offside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Direction indicator adversely affected by the operation of another lamp All nearside (4.4.3 (b)) | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Rear Seat belt anchorage loose (7.1.1 (b)) | 1 |
| Nearside Front Outer Drag link end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Rear Leaf spring shackle pin or bush excessively worn rear bushes (5.3.4 (a) (i)) | 1 |
| Offside Rear Leaf spring shackle pin or bush excessively worn rear bushes (5.3.4 (a) (i)) | 1 |
| Nearside Integral body structure inadequately repaired such that structural rigidity is significantly reduced outer sill (6.1.1 (d) (i)) | 1 |
| Offside Integral body structure inadequately repaired such that structural rigidity is significantly reduced outer sill panel (6.1.1 (d) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area is inadequately repaired jacking point (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area is inadequately repaired jacking point (5.3.6 (a) (i)) | 1 |
| Steering linkage insecure to the extent there is excessive movement at the mountings steering idler bushes (2.1.3 (a) (ii)) | 1 |
| Hydraulic fluid leaking excessively brake fluid reservoir (8.4.1 (a) (i)) | 1 |