| Most common failures | No# failures |
|---|
| Parking brake: efficiency below requirements |3.7.B.7| | 13 |
| Headlamp aim out of alignment | 8 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 8 |
| Brakes imbalanced across an axle | 8 |
| Rear parking brake recording little or no effort | 8 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 6 |
| Windscreen wiper does not clear the windscreen effectively | 5 |
| Rear brake binding | 4 |
| Registration plate lamp issues | 4 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 4 |
| Horn not working |1.6.2a| | 4 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Service brake: efficiency below requirements |3.7.B.7| | 3 |
| Lower Steering column flexible coupling is excessively deteriorated |2.1.5| | 3 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 2 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Rear Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Windscreen washer not working | 2 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Rear fog lamp tell tale not working |1.3.1b| | 2 |
| Offside Front Power steering component|s| leaking from a failed seal |2.3.3b| | 2 |
| Rear brake application uneven | 2 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 2 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Inner Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Steering column flexible coupling is excessively deteriorated |2.1.5| | 2 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Rear fog lamp adversely affected by the operation of another lamp brings on reverse light (4.5.4 (b)) | 1 |
| Dipswitch does not operate immediately when selected on main beam (4.1.3 (b)) | 1 |
| Offside Front Seat belt buckle not functioning as intended (7.1.2 (d)) | 1 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Service brake efficiency less than 50% of the required value (1.2.2 (a) (ii)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Front Lower Suspension arm ball joint dust cover missing (5.3.4 (b) (ii)) | 1 |
| Nearside Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength arch |5.3.6 |a| |i|| | 1 |
| Nearside Headlamp not working on main beam |4.1.1 |a| |ii|| | 1 |
| Offside Headlamp not working on main beam |4.1.1 |a| |ii|| | 1 |
| Nearside Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
| Nearside Front Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
| Offside Front Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
| Offside Inner Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
| Offside Front coil spring fractured |2.4.C.1a| | 1 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Horn control missing |1.6.1| | 1 |
| Offside Rear Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear Tie bar/rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Vehicle structure has a modification which adversely affects braking or steering |6.1.A.1| | 1 |
| Nearside Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Upper Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Wheel bearing has excessive play |5.1.3 |a| |i|| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Power steering component|s| leaking |2.3.3b| | 1 |
| Nearside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Front Radius arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Radius arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Power steering component|s| leaking from a failed seal |2.3.3b| | 1 |
| Steering column top mounting bracket insecure |2.1.2d| | 1 |
| Nearside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Nearside Rear Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Lower Torque/reaction arm has a deteriorated rubber bush resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Lower Torque/reaction arm has a deteriorated rubber bush resulting in excessive movement |2.4.G.2| | 1 |
| Rear Torque/reaction arm has a deteriorated rubber bush resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Panhard rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Panhard rod rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Windscreen has a combination of minor damage areas which restrict the drivers view |8.3.1c| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Lower Steering column cracked and unserviceable |2.2.C.1d| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Offside Steering arm fractured and unserviceable |2.2.C.1d| | 1 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Seat belt anchorage prescribed area strength or continuity significantly reduced outer sill (7.1.1 (a) (i)) | 1 |
| Brake hose excessively deteriorated | 1 |
| Offside Front Brake hose excessively damaged (1.1.12 (b) (ii)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Front Inner Suspension rod pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Front Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Nearside Lower Ball joint has excessive play |2.2.B.1f| | 1 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 1 |
| Lower Steering component cracked and unserviceable |2.2.C.1d| | 1 |
| Offside Front Bumper insecure |6.1.4 |a| |i|| | 1 |
| Nearside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits |8.2.1.2 |b|| | 1 |
| Nearside Rear All position lamps not working |1.1.A.3b| | 1 |
| Nearside Rear Position lamp not working |4.2.1 |a|| | 1 |
| Oil leaking excessively from engine |8.4.1 |a| |i|| | 1 |
| Central Rear Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Seat belt anchorage prescribed area strength or continuity significantly reduced Both sides inner sills |7.1.1 |a| |i|| | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Outer sill |5.3.6 |a| |i|| | 1 |
| Nearside Front Macpherson strut damaged and seriously weakened |5.3.3 |b| |i|| | 1 |
| rear parking |secondary| brakes imbalanced | 1 |
| Nearside Outer Seat belt anchorage likely to become detached in the event of a collision corroded & holed at base of B post (7.1.1 (a) (ii)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill corroded & holed (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area is corroded to the extent that control of the vehicle is likely to be adversely affected corroded & holed (5.3.6 (a) (ii)) | 1 |
| Nearside Rear Outer Suspension component mounting prescribed area is inadequately repaired sill - not contiuously welded (5.3.6 (a) (i)) | 1 |
| Offside Rear Outer Suspension component mounting prescribed area is inadequately repaired sill - not contiuously welded (5.3.6 (a) (i)) | 1 |
| Offside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Rear Exhaust system insecure exhaust rubber missing (6.1.2 (a)) | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Rear Tie bar/rod attachment bracket/mounting corroded and its strength is seriously reduced |2.4.G.1| | 1 |
| Offside Rear Tie bar/rod attachment bracket/mounting corroded and its strength is seriously reduced |2.4.G.1| | 1 |
| Rear Mechanical brake component has restricted free movement | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Steering column shaft has excessive end float |2.1.3| | 1 |
| Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
| Offside Steering linkage ball joint worn to the extent there is a serious risk of detachment (2.1.3 (b) (ii)) | 1 |
| Nearside Steering linkage ball joint worn to the extent there is a serious risk of detachment (2.1.3 (b) (ii)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 1 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| An item not tested |Manual| | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Parking brake recording little or no effort |3.7.D.3a| | 1 |
| Offside Side repeater not working |1.4.A.2c| | 1 |
| Nearside Front Power steering component|s| leaking from a failed seal |2.3.3b| | 1 |
| Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Nearside Rear Outer Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Inner Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Rear Trailing arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Trailing arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Suspension component mounting prescribed area is fractured |2.4.A.3| | 1 |
| Offside Power steering pipe|s| or hose|s| leaking |2.3.3b| | 1 |
| Steering column flexible coupling locking device insecure |2.1.6| | 1 |
| Offside Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Rear Fuel hose insecure |7.2.1| | 1 |
| Nearside Front Electrical wiring insecure |1.9.2a| | 1 |
| Offside Front Electrical wiring damaged, likely to cause a short |1.9.2b| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Battery insecure |1.9.1| | 1 |
| Nearside Front coil spring broken |2.4.C.1a| | 1 |
| Nearside Rear Braking system leaking |3.6.A.1| | 1 |
| Nearside Rear Suspension arm attachment bracket/mounting corroded and seriously weakened |5.3.3 |b| |i|| | 1 |
| Offside Rear Suspension arm attachment bracket/mounting corroded and seriously weakened |5.3.3 |b| |i|| | 1 |
| Emissions not tested exhaust leaking at rear silencer joint. |8.2.1.2 |d|| | 1 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |