| Most common failures | No# failures |
|---|
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 20 |
| Parking brake: efficiency below requirements |3.7.B.7| | 14 |
| Headlamp aim out of alignment | 13 |
| Registration plate lamp issues | 12 |
| Windscreen wiper does not clear the windscreen effectively | 10 |
| Brakes imbalanced across an axle | 9 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 8 |
| Rear brake binding | 8 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 7 |
| Service brake: efficiency below requirements |3.7.B.7| | 6 |
| Registration plate issues | 6 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 6 |
| Rear parking brake recording little or no effort | 5 |
| Centre Exhaust system not adequately supported |7.1.1| | 4 |
| Parking brake lever has no reserve travel |3.1.6b| | 4 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 4 |
| Horn not working |1.6.2a| | 3 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Front Exhaust system not adequately supported |7.1.1| | 3 |
| Offside Headlamp not working on main beam |1.7.5a| | 3 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 3 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 3 |
| Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 2 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Front brake disc excessively pitted |3.5.1h| | 2 |
| Nearside Headlamp not working on main beam |1.7.5a| | 2 |
| Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Brake performance not tested |3.7.A.1| | 2 |
| Nearside front brake binding |3.7.B.1| | 2 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 2 |
| Offside Front Upper Ball joint has excessive play |2.2.B.1f| | 2 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Exhaust emissions hydrocarbon content excessive (8.2.1.2 (b)) | 2 |
| Windscreen wiper not working (3.4 (a)) | 2 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Fuel system component leaking |7.2.3| | 2 |
| Offside Front Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Nearside Direction indicators flashing less than 60 times a minute |1.4.A.2g| | 1 |
| Rear Suspension arm attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Offside Rear Suspension spring mounting prescribed area is fractured |2.4.A.3| | 1 |
| Speedometer cannot be illuminated. |6.7.3| | 1 |
| Offside Front Upper Steering wheel locking device insecure |2.1.6| | 1 |
| Nearside Rear Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings floor |6.1.B.2| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings floor |6.1.B.2| | 1 |
| Nearside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Rear Valve stem seriously damaged |4.1.D.1e| | 1 |
| Nearside Rear Valve stem seriously misaligned |4.1.D.1e| | 1 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front Upper Steering locking device missing steering arm nut |2.2.C.1g| | 1 |
| Brake hydraulic reservoir fluid level below minimum level empty |3.6.G.1b| | 1 |
| Rear Exhaust system not adequately supported bracket not connected |7.1.1| | 1 |
| Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Nearside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Rear Towbar component excessively corroded |6.6.1| | 1 |
| Nearside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Rear Brake pipe leaking |3.6.A.1| | 1 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 1 |
| Road wheel badly damaged |4.2.A.1a| | 1 |
| Nearside Front position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Inner Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Position lamp switch does not illuminate the front and rear position lamps with a single operation |1.1.A.2| | 1 |
| Offside Front Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Steering column top bearing excessively worn |2.1.2c| | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength by coil spring mounting (5.3.6 (a) (i)) | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength by suspension arm (5.3.6 (a) (i)) | 1 |
| Nearside Front Direction indicators not working |1.4.A.2c| | 1 |
| Nearside front brakes release unevenly |3.7.B.4| | 1 |
| Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Offside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Front Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Direction indicators flashing less than 60 times a minute |1.4.A.2g| | 1 |
| Horn sounds harsh or grating |1.6.2e| | 1 |
| Offside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Nearside Front Service brake excessively binding |1.2.1 |f|| | 1 |
| Offside Front Service brake excessively binding |1.2.1 |f|| | 1 |
| Service brake efficiency less than 50% of the required value |1.2.2 |a| |ii|| | 1 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
| Stop lamp not working |1.2.1b| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded floor |5.2.6| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Obligatory mirror missing |8.1.1| | 1 |
| Front Fuel system component leaking |7.2.3| | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Nearside Front suspension has excessive play in a upper suspension ball joint marked, |2.5.B.1a| | 1 |
| Offside Rear Wheel nut|s| loose |4.2.A.1e| | 1 |
| Nearside Front brake caliper has restricted free movement |3.5.1k| | 1 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Exhaust carbon monoxide content at idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Nearside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Headlamp not working on main beam Both (4.1.1 (a) (ii)) | 1 |
| Oil leaking excessively from engine (8.4.1 (a) (i)) | 1 |
| Rear Exhaust mounting missing |7.1.1b| | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength floor |5.3.6 |a| |i|| | 1 |
| Brake hose excessively deteriorated | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Mechanical brake component locking device missing |3.5.1l| | 1 |
| Offside Front Mechanical brake component locking device missing |3.5.1l| | 1 |
| Offside Rear Braking system leaking |3.6.A.1| | 1 |
| Nearside Rear Lower Shock absorber insecure |2.7.2b| | 1 |
| Driver`s seat insecure |6.2.A.1| | 1 |
| Nearside Front Upper Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Hazard warning tell tale not working correctly |1.4.B.1e| | 1 |
| Hazard warning switch faulty hazards very dim and to fast |1.4.B.1d| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Brake pedal has no servo assistance |3.3.B.2| | 1 |
| Offside Front Inner Suspension spring mounting prescribed area is excessively corroded wing |2.4.A.3| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded floor |2.4.A.3| | 1 |
| Offside Headlamp insecure |1.7.3| | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Offside Front front brake binding |3.7.B.1| | 1 |
| Brake pedal anti-slip provision incomplete |3.3.A.1b| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Exhaust emits visible black smoke at idle |7.3.A.2b| | 1 |
| rear parking |secondary| brakes imbalanced | 1 |
| Rear brake application uneven | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Battery insecure box brocken |1.9.1| | 1 |
| Offside Rear Inner Suspension component mounting prescribed area is excessively corroded sill |2.4.A.3| | 1 |
| Offside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Trailing arm corroded and seriously weakened |2.4.G.1| | 1 |
| Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Rear brake caliper leaking |3.6.A.1| | 1 |
| Nearside Front Upper Ball joint has excessive play |2.2.B.1f| | 1 |