Most common failures | No# failures |
---|
Parking brake: efficiency below requirements |3.7.B.7| | 21 |
Headlamp aim out of alignment | 16 |
Rear parking brake recording little or no effort | 15 |
Registration plate lamp issues | 15 |
Windscreen wiper does not clear the windscreen effectively | 14 |
Exhaust has a major leak of exhaust gases |7.1.2| | 9 |
Brakes imbalanced across an axle | 9 |
Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 8 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 7 |
Offside Headlamp not working on dipped beam |1.7.5a| | 7 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 7 |
Nearside front brake binding |3.7.B.1| | 7 |
Brake hose excessively deteriorated | 7 |
Parking brake lever has no reserve travel |3.1.6b| | 6 |
Offside Front front brake binding |3.7.B.1| | 5 |
Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
Offside rear brake recording little or no effort |3.7.B.5a| | 5 |
Offside front brake binding |3.7.B.1| | 5 |
Service brake: efficiency below requirements |3.7.B.7| | 5 |
Front Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 4 |
Nearside Front front brake binding |3.7.B.1| | 4 |
Rear Exhaust system not adequately supported |7.1.1| | 4 |
Rear brake application uneven | 3 |
Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
Parking brake: efficiency below requirements |3.7.C.1b| | 3 |
Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
Nearside Headlamp not working on main beam |1.7.5a| | 3 |
Centre Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 3 |
Offside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 2 |
Brake pipe excessively corroded | 2 |
Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Offside Rear position lamp|s| not working |1.1.A.3b| | 2 |
Offside Stop lamp not working |1.2.1b| | 2 |
Exhaust system not adequately supported |7.1.1| | 2 |
Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
Nearside Stop lamp not working |1.2.1b| | 2 |
Rear brake disc excessively pitted |3.5.1h| | 2 |
Nearside Rear Seat belt retracting mechanism defective |5.2.5b| | 2 |
Front brake application uneven | 2 |
rear brakes release unevenly |3.7.B.4| | 2 |
Offside Front Braking system leaking |3.6.A.1| | 2 |
Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 2 |
Rear brake binding | 2 |
Nearside Front Service brake grabbing severely |3.7.C.2| | 2 |
Offside Headlamp not working on main beam |1.7.5a| | 2 |
Service brake: efficiency below requirements |3.7.C.1a| | 2 |
Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
Nearside Rear brake caliper leaking |3.6.A.1| | 2 |
Exhaust engine idle speed too high |7.3.A.2a| | 1 |
Braking system leaking |3.6.A.1| | 1 |
Offside Rear Lower Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
Offside Front Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
Offside Front Shock absorber casing corroded externally so the unit does not function |2.7.2a| | 1 |
Nearside Front Shock absorber casing corroded externally so the unit does not function |2.7.2a| | 1 |
Nearside An item not tested |Manual| | 1 |
Offside An item not tested |Manual| | 1 |
Nearside rear brakes release unevenly |3.7.B.4| | 1 |
Offside passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 1 |
Offside Front Suspension arm ball joint dust cover insecure so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Brake pipe inadequately supported |3.6.B.1| | 1 |
Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Front Exhaust system not adequately supported |7.1.1| | 1 |
Nearside Front Service brake juddering severely |3.7.C.2| | 1 |
Offside Front Service brake juddering severely |3.7.C.2| | 1 |
Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Dipswitch operation does not extinguish all main beam headlamps leaving at least one pair of dipped beam headlamps |1.7.4b| | 1 |
Nearside Front Valve stem seriously damaged |4.1.D.1e| | 1 |
Offside Front Valve stem seriously damaged |4.1.D.1e| | 1 |
Nearside Rear Valve stem seriously damaged |4.1.D.1e| | 1 |
Offside Rear Valve stem seriously damaged |4.1.D.1e| | 1 |
Nearside Rear wheel bearing rough when rotated |2.6.1| | 1 |
Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
Nearside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Front position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Offside Rear reflector missing |1.5.1a| | 1 |
Nearside Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
Nearside Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Inner Front Headlamp not working on main beam |1.7.5a| | 1 |
Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 1 |
Exhaust emits dense blue smoke at idle |7.3.A.2b| | 1 |
Nearside Rear Stop lamp not working |1.2.1b| | 1 |
Offside Rear Stop lamp not working |1.2.1b| | 1 |
Nearside Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
Steering wheel retaining device insecure |2.1.6| | 1 |
Nearside Steering locking device missing |2.2.C.1g| | 1 |
Rear Brake pipe inadequately supported |3.6.B.1| | 1 |
Rear Brake performance not tested |3.7.A.1| | 1 |
Nearside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Offside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
Offside Outer Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Inner Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Registration plate issues | 1 |
Offside Front Position lamp not working |4.2.1 |a|| | 1 |
Power steering component|s| leaking |2.3.3b| | 1 |
Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
Brake pedal creeps down when held under pressure |3.3.B.1a| | 1 |
Nearside Front Steering pivot point has excessive play |2.2.B.1g| | 1 |
Offside Rear Suspension arm corroded and seriously weakened |2.4.G.1| | 1 |
Offside Front Sub-frame corroded and seriously weakened |2.4.G.1| | 1 |
front brakes release unevenly |3.7.B.4| | 1 |
Nearside front brake recording little or no effort |3.7.B.5a| | 1 |
Offside front brake recording little or no effort |3.7.B.5a| | 1 |
Brake pedal feels spongy with the vacuum fully depleted |3.3.C.2| | 1 |
Nearside Outer Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Offside Outer Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside Inner Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Outer Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Rear Service brake grabbing severely |3.7.C.2| | 1 |
Nearside Upper Steering component is not secure to the vehicle structure |2.2.B.1a| | 1 |
Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
Nearside Front brake caliper has restricted free movement |3.5.1k| | 1 |
Offside Front brake caliper has restricted free movement |3.5.1k| | 1 |
Offside Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Offside Rear Braking system leaking |3.6.A.1| | 1 |
Brake performance not tested |3.7.A.1| | 1 |
Rear Exhaust system insecure (6.1.2 (a)) | 1 |
Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
Offside Rear Rear wheel bearing rough when rotated |2.6.1| | 1 |
Offside Rear brake disc contaminated by oil |3.5.1h| | 1 |
Offside Rear Trailing arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Rear Parking brake lever has no reserve travel |3.1.6b| | 1 |
Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Offside Front Service brake grabbing severely |3.7.C.2| | 1 |
Direction indicator adversely affected by the operation of another lamp inter acting |1.4.A.2h| | 1 |
Offside Rear Rear position lamp|s| adversely affected by the operation of another lamp interacting with indercator |1.1.A.3f| | 1 |
Offside Rear Suspension arm attachment bracket/mounting nut missing |2.4.G.1| | 1 |
Offside Rear Braking system leaking brake discs & pads contaminated with oil or brakefluid |3.6.A.1| | 1 |
Offside Upper Ball joint has excessive play |2.2.B.1f| | 1 |
Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
Nearside Front Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
Offside Direction indicators not working both front and rear stay on |1.4.A.2c| | 1 |
Nearside Front Upper Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
Driver`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
Nearside Front Passenger`s seat insecure |6.2.A.1| | 1 |
Offside Front Brake hose excessively damaged |3.6.B.4d| | 1 |
Offside Rear Suspension component mounting prescribed area is deliberately modified which significantly reduces the original strength |2.4.A.3| | 1 |
Nearside Rear Suspension component mounting prescribed area is deliberately modified which significantly reduces the original strength |2.4.A.3| | 1 |
Nearside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Offside Front Suspension arm locating pin locking device missing |2.4.G.3b| | 1 |
An item not tested |Manual| | 1 |
Nearside Inner Rear Exhaust system not adequately supported |7.1.1| | 1 |
Parking brake lever, pawl mechanism pivot|s| retaining device insecure |3.1.4b| | 1 |
Centre Exhaust mounting missing |7.1.1b| | 1 |
Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
Nearside Rear Direction indicator flashing less than 60 times a minute |1.4.A.2g| | 1 |
Offside Front Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
Nearside Inner Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Offside Inner Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside Rear Lower Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Nearside Front Lower Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Nearside Rear Lower Exhaust has a part missing |7.1.1a| | 1 |
Nearside Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Offside Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Hazard warning switch faulty |1.4.B.1d| | 1 |
Offside Rear brake disc has restricted free movement |3.5.1j| | 1 |
Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Horn not working |1.6.2a| | 1 |
Offside Rear Brake pipe leaking |3.6.A.1| | 1 |
Steering column top mounting bracket insecure |2.1.2d| | 1 |
Offside Indicator tell tale inoperative |1.4.A.2a| | 1 |
Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Nearside Front Tie bar/rod ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Front Tie bar/rod ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Nearside Rear Trailing arm rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Rear Trailing arm rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |