| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 18 |
| Parking brake: efficiency below requirements |3.7.B.7| | 14 |
| Brake pipe excessively corroded | 13 |
| Registration plate issues | 10 |
| Registration plate lamp issues | 9 |
| Windscreen wiper does not clear the windscreen effectively | 7 |
| Rear parking brake recording little or no effort | 7 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 5 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 5 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 4 |
| Rear fog lamp not working |1.3.2b| | 3 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 3 |
| Rear brake binding | 3 |
| Supplementary restraint system warning lamp indicates a fault |7.1.6 |a|| | 3 |
| Parking brake lever has no reserve travel |3.1.6b| | 3 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 3 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 3 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 3 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Horn not working |1.6.2a| | 3 |
| Brake hose excessively deteriorated | 3 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 2 |
| Nearside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Nearside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Offside Front Position lamp not working |4.2.1 |a|| | 2 |
| Horn not working (7.7 (a)) | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Offside Front Brake back plate|s| securing device excessively deteriorated |3.5.1j| | 2 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 2 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 2 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Fluid suspension unit supply pipe corroded and seriously weakened |2.4.D.3| | 1 |
| Nearside Rear coil spring broken |2.4.C.1a| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Parking brake lever defective so that it cannot be satisfactorily operated |1.1.6 |d|| | 1 |
| Fuel pipe leaking excessively or a risk of fire front to rear |6.1.3 |b| |ii|| | 1 |
| Nearside Rear Brake linkage has restricted free movement |1.1.15 |e|| | 1 |
| Offside Rear Brake linkage has restricted free movement |1.1.15 |e|| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded outer sill |5.2.6| | 1 |
| Rear Mechanical brake component has restricted free movement | 1 |
| Nearside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Nearside Rear Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Nearside Rear Shock absorbers has a serious fluid leak | 1 |
| Centre Stop lamp has less than 50% of the light sources illuminating |1.2.1b| | 1 |
| Nearside Front Power steering pipe|s| or hose|s| leaking |2.3.3b| | 1 |
| Nearside Rear Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Rear Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Position lamp not working |4.2.1 |a| |ii|| | 1 |
| Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Main beam `tell-tale` not working |1.7.4c| | 1 |
| Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Fuel cap/sealing device missing |7.2.4a| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Offside Side repeater incorrect colour |4.4.3 |a|| | 1 |
| Offside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Offside Front Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Offside Front Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.A.3| | 1 |
| All direction indicators not working Unable to test lights (4.4.1 (a) (ii)) | 1 |
| Hazard warning lamps inoperative Unable to test lights (4.4.1 (e)) | 1 |
| Nearside Front Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Emissions unable to be completed Excessive lambda content (8.2.2.2 (e)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Nearside Front Lower Fluid suspension pipe leaking |2.4.D.2| | 1 |
| Nearside Front Lower Steering rack gaiter split |2.2.D.2d| | 1 |
| Headlamp switch faulty |1.7.1| | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Rear Brake hose twisted |3.6.B.4c| | 1 |
| Nearside Front Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Brakes imbalanced across an axle | 1 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 1 |
| Offside Rear Lower Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Nearside Front Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
| Windscreen has damage | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Anti-lock braking system warning lamp indicates an ABS fault | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sill (5.3.6 (a) (i)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Offside Rear Exhaust has a major leak of exhaust gases clamp corroded & split |6.1.2 |a|| | 1 |
| Offside Rear Fluid suspension unit deteriorated and likely to fail |2.4.D.1b| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Front All position lamps not working |1.1.A.3b| | 1 |
| Nearside Rear Suspension arm ball joint dust cover no longer prevents the ingress of dirt rose joint |5.3.4 |b| |ii|| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 1 |
| Nearside Front Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Side repeater incorrect colour white |1.4.A.2f| | 1 |
| Rear Fluid suspension unit supply pipe corroded and seriously weakened all rear |2.4.D.3| | 1 |
| Offside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Anti-roll bar ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt leaking grease |2.4.G.2| | 1 |
| Power steering pipe|s| or hose|s| leaking |2.3.3b| | 1 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Side repeater incorrect colour |1.4.A.2f| | 1 |
| Offside Side repeater incorrect colour |1.4.A.2f| | 1 |
| Nearside Rear Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Rear Fluid suspension unit interconnecting pipe corroded and seriously weakened |2.4.D.3| | 1 |
| Offside Rear Fluid suspension unit interconnecting pipe corroded and seriously weakened |2.4.D.3| | 1 |
| Nearside Front Braking system leaking |3.6.A.1| | 1 |
| Nearside Front Brake hose leaking |3.6.A.1| | 1 |
| Nearside Rear Brake pipe leaking on an air braking system |1.1.11 |b| |i|| | 1 |
| Brake performance not tested pipe leaking |1.2.1 |g|| | 1 |
| Offside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Rear Shock absorber casing corroded externally so the unit does not function |2.7.2a| | 1 |
| Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover missing |5.3.4 |b| |ii|| | 1 |
| Nearside Exhaust has a major leak of exhaust gases snapped off at rear (6.1.2 (a)) | 1 |
| Offside Rear passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 1 |
| Nearside Front Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Offside Front Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Front Fuel pipe insecure |7.2.1| | 1 |
| Offside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Offside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Offside Rear Lower Shock absorber has an excessively worn bush Bearing/bush |2.7.4| | 1 |
| Nearside Suspension arm rubber bush deteriorated resulting in excessive movement Rear bush of front arm |2.4.G.2| | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Side repeater insecure |1.4.A.2b| | 1 |
| Parking brake lever defective so that it cannot be satisfactorily operated |3.1.3c| | 1 |
| Offside Rear Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |