| Most common failures | No# failures |
|---|
| Registration plate issues | 22 |
| Headlamp aim out of alignment | 11 |
| Brake pipe excessively corroded | 9 |
| Windscreen wiper does not clear the windscreen effectively | 6 |
| Horn not working |1.6.2a| | 6 |
| Anti-lock braking system warning lamp indicates an ABS fault | 4 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 4 |
| Parking brake: efficiency below requirements |3.7.B.7| | 4 |
| Driver`s airbag obviously defective |5.4.1| | 3 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 3 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 3 |
| Offside Rear Other passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 2 |
| Windscreen washer not working | 2 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 2 |
| Supplementary restraint system warning lamp indicates a fault |7.1.6 |a|| | 2 |
| Parking brake inoperative on one side both sides (1.4.1 (a)) | 2 |
| Brake fluid warning lamp illuminated |3.6.G.2| | 2 |
| Brake hose has insufficient room to move | 2 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 2 |
| Nearside Rear Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Brake performance not tested brake binding (1.2.1 (g)) | 1 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Braking system leaking reservoir / master cylinder / pipes & hoses wet with fluid |1.1.3 |d|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Offside Rear Seat belt buckle not functioning as intended (7.1.2 (d)) | 1 |
| Electronic stability control warning lamp indicates a fault (7.12 (e)) | 1 |
| Electronic braking system warning device indicates a fault (1.7 (b)) | 1 |
| Nearside Front Suspension unit modified so that its function is affected (5.3.5 (b) (i)) | 1 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
| Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Engine MIL inoperative or indicates a malfunction indicates a malfunction (8.2.1.2 (h)) | 1 |
| Offside Rear Parking (secondary brake) on a single line braking system has inadequate effort at a wheel (1.3.1 (a) (i)) | 1 |
| Nearside Front Suspension arm attachment bracket/mounting insecure (5.3.3 (a) (i)) | 1 |
| Fuel cap/sealing device ineffective (6.1.3 (b) (i)) | 1 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Passenger`s airbag obviously defective |5.4.1| | 1 |
| Nearside Headlamp missing |1.7.3| | 1 |
| Nearside Side repeater missing |1.4.A.2b| | 1 |
| Offside Front Direction indicators not working |1.4.A.2c| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 1 |
| Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Central Rear Statutory seat belt missing secure / release mechanism |5.1.1| | 1 |
| Nearside Front Outline marker lamp not working |4.2.1 |a|| | 1 |
| Nearside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Front Air suspension has no suspension movement |2.4.D.5| | 1 |
| Rear Air suspension has no suspension movement |2.4.D.5| | 1 |
| Nearside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Front Power steering malfunctioning steering heavy (2.1.5 (a)) | 1 |
| Front Bonnet primary retaining device insecure (3.1 (c)) | 1 |
| Front Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 1 |
| Front Headlamp cleaning device inoperative |1.7.2| | 1 |
| Offside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Lower Suspension component ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Electrical wiring insecure abs sensor wiring insecure and fouling suspension components |1.9.2a| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Rear parking brake recording little or no effort | 1 |
| Central Rear Seat belt buckle missing (7.1.2 (d)) | 1 |
| Direction indicators not working |1.4.A.2c| | 1 |
| Rear Driver`s airbag obviously defective |5.4.1| | 1 |
| Windscreen has damage | 1 |
| Nearside Front Trailing arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Electronic stability system warning lamp indicates a fault |3.4.1c| | 1 |
| Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Offside Rear Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Offside Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| All position lamps not working |1.1.A.3b| | 1 |
| Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Electronic parking brake warning indicates a malfunction (1.1.6 (e)) | 1 |
| Nearside Front Brake hose excessively twisted (1.1.12 (b) (ii)) | 1 |
| Nearside Front Side repeater excessively deteriorated so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
| Nearside Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Electronic stability control warning lamp indicates a fault |7.12 |e|| | 1 |
| Offside Front Headlamp adversely affected by the operation of another lamp |1.7.5c| | 1 |
| Offside Rear Seat belt flexible stalk deteriorated likely to lead to failure under load stalk button no function |5.2.4a| | 1 |
| Nearside Rear Seat belt flexible stalk deteriorated likely to lead to failure under load stalk button no function |5.2.4a| | 1 |
| Nearside Front Lower Suspension component ball joint excessively worn spring control arm (5.3.4 (a) (i)) | 1 |
| Nearside Side repeater incorrect colour |1.4.A.2f| | 1 |
| Offside Side repeater incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |