| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 21 |
| Registration plate lamp issues | 16 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 15 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 11 |
| Headlamp aim out of alignment | 10 |
| Nearside Stop lamp not working |1.2.1b| | 7 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 7 |
| Offside Stop lamp not working |1.2.1b| | 7 |
| Parking brake: efficiency below requirements |3.7.B.7| | 6 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 6 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 6 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 5 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 5 |
| Brakes imbalanced across an axle | 5 |
| Brake pipe excessively corroded | 5 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 4 |
| Rear parking brake recording little or no effort | 4 |
| Horn not working |1.6.2a| | 4 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 4 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 4 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 4 |
| Hazard warning switch faulty |1.4.B.1d| | 4 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 4 |
| Windscreen washer not working | 3 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 3 |
| Centre Stop lamp not working |1.2.1b| | 3 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 3 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 3 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Offside Rear coil spring broken |2.4.C.1a| | 3 |
| Rear fog lamp not working |1.3.2b| | 3 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 3 |
| Offside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 2 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 2 |
| Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 2 |
| Windscreen has damage | 2 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
| Offside Outer Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Offside Rear coil spring fractured |2.4.C.1a| | 2 |
| Parking brake lever has no reserve travel |3.1.6b| | 2 |
| Power steering fluid level below minimum |2.3.1| | 2 |
| Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 2 |
| Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 2 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 2 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Hazard warning lamps inoperative |1.4.B.1b| | 2 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Anti-lock braking system warning lamp indicates an ABS fault | 2 |
| Offside Rear Body has a sharp edge caused by damage |6.1.C.1| | 2 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Nearside Parking (secondary brake) on a single line braking system has inadequate effort at a wheel (1.3.1 (a) (i)) | 1 |
| Nearside Front Shock absorbers has a serious fluid leak | 1 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Front Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Nearside Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Nearside Front Lower Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Lower Ball joint has excessive play |2.2.B.1f| | 1 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 1 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Front brake disc in such a condition that it is seriously weakened | 1 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 1 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Offside Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Front Upper Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Front Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Nearside Outer Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Outer Front Lower Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Offside Headlamp insecure |1.7.3| | 1 |
| Offside Front Brake hose leaking |3.6.A.1| | 1 |
| Fuel system component leaking pipe (6.1.3 (b) (i)) | 1 |
| Nearside Prop shaft joint constant velocity boot no longer prevents the ingress of dirt clip (6.1.7 (g) (ii)) | 1 |
| Brake pedal creeps down while the pedal is held under pressure |3.3.B.1a| | 1 |
| Nearside Outer Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Outer Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Emissions not tested |7.0| | 1 |
| Rear brake binding | 1 |
| Nearside Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Front Windscreen damaged and affecting the drivers view of the road (3.2 (a) (ii)) | 1 |
| Offside Front Upper Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 1 |
| Nearside Front Upper Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Exhaust carbon monoxide content at idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Nearside Rear Body panel damaged and likely to cause injury wheel arch |6.2.1 |a| |i|| | 1 |
| Offside Rear Body panel damaged and likely to cause injury lamp [sharp edges ] |6.2.1 |a| |i|| | 1 |
| Offside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear All direction indicators adversely affected by the operation of another lamp (4.4.3 (b)) | 1 |
| Nearside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear All position lamps adversely affected by the operation of another lamp (4.2.3 (c)) | 1 |
| Nearside Rear Stop lamp(s) adversely affected by the operation of another lamp (4.3.3 (b)) | 1 |
| Nearside Rear Direction indicator adversely affected by the operation of another lamp (4.4.3 (b)) | 1 |
| Nearside Front Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Offside Front Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
| Nearside Front Trailing arm attachment bracket/mounting damaged and its strength is seriously reduced box section damaged |2.4.G.1| | 1 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt Clip Loose |6.1.7 |g| |ii|| | 1 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt Clip Missing |6.1.7 |g| |ii|| | 1 |
| Power steering component|s| leaking pressure switch |2.3.3b| | 1 |
| Nearside Front Stop lamp not working |1.2.1b| | 1 |
| Nearside Lower Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Offside Rear position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Macpherson strut has excessive movement at the upper attachment |2.5.A.1c| | 1 |
| Rear Seat belt attachment fitting badly deteriorated |5.2.3| | 1 |
| Offside Rear position lamp|s| adversely affected by the operation of another lamp bad earth |1.1.A.3f| | 1 |
| Windscreen wiper blade insecure | 1 |
| Offside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Nearside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt drop link |2.4.G.2| | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt drop link |2.4.G.2| | 1 |
| Rear brake disc in such a condition that it is seriously weakened | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Front Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Obligatory mirror insecure |8.1.1| | 1 |
| Nearside Rear coil spring broken |2.4.C.1a| | 1 |
| Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Rear fog lamp adversely affected by the operation of another lamp |1.3.2f| | 1 |
| Nearside Rear Seat belt insecurely fixed to the seat |5.2.1a| | 1 |
| Registration plate issues | 1 |
| Exhaust fumes causing a danger to health of persons on board |6.1.2 |b| |ii|| | 1 |
| Front Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Driver`s seat insecure |6.2.5 |a| |ii|| | 1 |
| Nearside Front Service brake has no recorded effort at a wheel |1.2.1 |a| |ii|| | 1 |
| Nearside Rear Service brake has no recorded effort at a wheel |1.2.1 |a| |ii|| | 1 |
| Offside Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Offside Position lamp not working |4.2.1 |a|| | 1 |
| Front Exhaust emissions likely to be affected by an exhaust leak |8.2.1.1 |b|| | 1 |
| Brake fluid not visible |1.1.10 |d| |iii|| | 1 |
| Brake fluid significantly below minimum mark |1.1.10 |d| |ii|| | 1 |
| Power steering malfunctioning |2.1.5 |a|| | 1 |
| Nearside Rear Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
| Offside Rear Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
| Offside Front Upper Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Power steering pipe/hose modification unsafe hose rubbing on pump pulley |2.1.5 |f| |i|| | 1 |
| Nearside Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Nearside Steering rack has excessive free play detected at the steering wheel to the extent that safe steering is affected |steering rack fitted| inner steering arm |2.3 |a| |ii|| | 1 |
| Offside Obligatory mirror seriously damaged, affecting the rear view |3.3 |b| |ii|| | 1 |
| Horn not working |7.7 |a| |ii|| | 1 |
| Offside Rear Position lamp not working |4.2.1 |a|| | 1 |
| Offside Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 1 |
| Nearside Front Brake disc significantly and obviously worn |1.1.14 |a| |i|| | 1 |
| Offside Front Brake disc significantly and obviously worn |1.1.14 |a| |i|| | 1 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Offside Front Anti-roll bar ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Ball joint has excessive play inner steering |2.2.B.1f| | 1 |
| Offside Rear Braking system leaking |3.6.A.1| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Power steering pump insecure |2.3.6| | 1 |
| Power steering pump drive system defective |2.3.6| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Brake hose damaged | 1 |
| Offside Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Front passenger seat insecure |6.2.3| | 1 |
| Nearside Rear Statutory seat belt missing |5.1.1| | 1 |
| Offside Rear Statutory seat belt missing |5.1.1| | 1 |
| Nearside Front Statutory seat belt of the wrong type. |5.1.1| | 1 |
| Offside Front Statutory seat belt of the wrong type. |5.1.1| | 1 |
| Rear passenger door does not latch securely closed |6.2.B.1a| | 1 |
| Offside Rear fog lamp not working |1.3.2b| | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Offside Rear Coil spring not correctly located |2.4.C.2| | 1 |
| Offside Outer Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Inner Rear brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Rear Position lamp adversely affected by the operation of another lamp |4.2.3 |c|| | 1 |
| Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt insecure |6.1.7 |g| |ii|| | 1 |
| Offside Front Lower Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Trailer electrical socket damaged so that lead cannot be securely connected |1.9.3b| | 1 |
| Nearside Parking brake inoperative on one side cable snapped (1.4.1 (a)) | 1 |
| Offside Parking brake inoperative on one side cable snapped (1.4.1 (a)) | 1 |
| Central Brake cable damaged (1.1.15 (a)) | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength jacking point (5.3.6 (a) (i)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength jacking point (5.3.6 (a) (i)) | 1 |
| Nearside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Suspension rod corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Rear Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Rear Axle swivel pins and bushes swivel pin and/or bush excessively worn trailing arm bush (5.1.2 (b) (i)) | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |