| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 14 |
| Headlamp aim out of alignment | 8 |
| Parking brake: efficiency below requirements |3.7.B.7| | 8 |
| Registration plate lamp issues | 5 |
| Brake pipe excessively corroded | 3 |
| Rear brake binding | 3 |
| Rear brake disc in such a condition that it is seriously weakened | 3 |
| Brake hose excessively deteriorated | 3 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 3 |
| Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 3 |
| Rear parking brake recording little or no effort | 3 |
| Service brake: efficiency below requirements |3.7.B.7| | 3 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 3 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 3 |
| Brakes imbalanced across an axle | 3 |
| Registration plate issues | 2 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 2 |
| Offside Steering rack gaiter split |2.2.D.2d| | 2 |
| Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 2 |
| Offside Rear fog lamp not working |1.3.2b| | 2 |
| Offside Steering rack gaiter missing or no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 2 |
| Rear Brake cable insecure | 2 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 2 |
| Nearside Front Wheel bearing play so excessive it is likely to break up (5.1.3 (a) (ii)) | 2 |
| Nearside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Nearside Upper Stop lamp not working |1.2.1b| | 2 |
| Offside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 2 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 2 |
| Offside Rear brake caliper has restricted free movement |3.5.1k| | 2 |
| Mechanical brake component has restricted free movement | 2 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Upper Stop lamp not working |1.2.1b| | 1 |
| Front Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Offside Rear Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Windscreen wiper blade insecure | 1 |
| Offside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Front passenger seat insecure |6.2.3| | 1 |
| Nearside Rear Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Leaf spring has a deteriorated anchor pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Nearside Leaf spring has a deteriorated anchor pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Offside Rear Trailing arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear Trailing arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Driver`s door does not latch securely closed |6.2.B.1a| | 1 |
| Bonnet cannot be secured in the closed position |8.4.1| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Seat belt affected by an insecure seat fixing |5.2.1b| | 1 |
| Nearside Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear Leaf spring has excessive wear in an anchor pin and/or bush |2.4.B.2| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Offside Upper Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Lower Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outrigger to shocker (5.3.6 (a) (i)) | 1 |
| Offside Rear position lamp|s| incomplete |1.1.4a| | 1 |
| Nearside Rear Upper Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Electrical wiring damaged, likely to cause a short |1.9.2b| | 1 |
| Front Windscreen damaged and affecting the driver`s view of the road |3.2 |a| |ii|| | 1 |
| Nearside Rear Direction indicator not working |4.4.1 |a| |ii|| | 1 |
| Nearside Parking brake inoperative on one side Low Effort |1.4.1 |a|| | 1 |
| Offside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Nearside Rear Lower Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Offside Rear Lower Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Offside Rear Upper Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Electrical wiring insecure |1.9.2a| | 1 |
| Fuel pipe leaking |7.2.3| | 1 |
| Offside Front Exhaust system insecure (6.1.2 (a)) | 1 |
| Nearside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Stop lamp has less than 50% of the light sources illuminating |1.2.1b| | 1 |
| Nearside Rear position lamp|s| has less than 50% of the light sources illuminating |1.1.A.3b| | 1 |
| Nearside Rear Direction indicator excessively damaged so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
| Nearside Rear Rear position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Centre Front Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Nearside Front Windscreen wiper blade missing |8.2.2| | 1 |
| Exhaust system not adequately supported ALL RUBBER MOUNTS BROKEN |7.1.1| | 1 |
| Offside Rear Parking (secondary brake) on a single line braking system has no recorded effort at a wheel (1.3.1 (a) (ii)) | 1 |
| Front Fluid leaking continuously posing a serious risk to road safety (8.4.1 (a) (ii)) | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Windscreen washer not working | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Offside Rear Floor excessively deteriorated both sides (6.2.4 (a) (i)) | 1 |
| Nearside Rear Braking system leaking |3.6.A.1| | 1 |
| Nearside Rear brake disc excessively pitted |3.5.1h| | 1 |
| Offside Rear brake disc excessively pitted |3.5.1h| | 1 |
| Rear Brake disc significantly and obviously worn |1.1.14 |a| |i|| | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Offside Rear Brake load sensing valve linkage defective and function impaired (1.1.17 (a)) | 1 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Rear Tailgate cannot be secured in the closed position |6.4.1| | 1 |
| Nearside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Anti-lock braking system warning lamp indicates an ABS fault | 1 |
| Nearside Rear Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 1 |
| Battery insecure |1.9.1| | 1 |
| Offside Rear brake caliper leaking |3.6.A.1| | 1 |
| Offside Front Steering rack gaiter missing or no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Nearside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting jacking point/ under door sill |6.2.2 |d| |i|| | 1 |
| Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting jacking point/ under door sill |6.2.2 |d| |i|| | 1 |
| Rear Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen |3.5 |a|| | 1 |
| Driver`s view of the road through the swept area of the windscreen materially affected by an obstruction phone holder |3.1 |a| |ii|| | 1 |
| Nearside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting jacking point |6.2.2 |d| |i|| | 1 |
| Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting jacking point |6.2.2 |d| |i|| | 1 |
| Offside Rear Brake lever has restricted free movement |1.1.15 |e|| | 1 |
| Brake load sensing valve linkage defective and function impaired |3.6.E.3| | 1 |
| rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Offside Front Lower Suspension arm ball joint likely to become detached (5.3.4 (a) (ii)) | 1 |
| Fuel system component leaking |7.2.3| | 1 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Emissions not tested due to major oil leak and fuel leak |7.4.B.1| | 1 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded sill |2.4.A.3| | 1 |