| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 5 |
| Headlamp aim out of alignment | 4 |
| Anti-lock braking system warning lamp indicates an ABS fault | 4 |
| Registration plate lamp issues | 4 |
| Rear brake disc in such a condition that it is seriously weakened | 3 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 3 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 3 |
| Front brake disc in such a condition that it is seriously weakened | 3 |
| Brake hose excessively deteriorated | 2 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Parking brake: efficiency below requirements |3.7.B.7| | 2 |
| Offside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Rear parking brake recording little or no effort | 2 |
| Service brake: efficiency below requirements |3.7.B.7| | 2 |
| Offside Front Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Horn not working (7.7 (a)) | 2 |
| Battery insecure |1.9.1| | 2 |
| Windscreen washer not working | 2 |
| Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 1 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Rear Passenger`s seat insecure |6.2.A.1| | 1 |
| Nearside Rear Seat belt affected by an insecure seat fixing |5.2.1b| | 1 |
| Rear Mechanical brake component has restricted free movement | 1 |
| Nearside Front Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Rear Braking system leaking |3.6.A.1| | 1 |
| Offside Rear Hydraulic brake cylinder leaking hydraulic fluid |3.6.A.1| | 1 |
| Brake load sensing valve inoperative |3.6.E.3| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| Driver`s airbag obviously defective |5.4.1| | 1 |
| Emergency exit window ???break glass` hammer missing |6.2.D.2| | 1 |
| Nearside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 1 |
| Nearside Rear Service brake has no recorded effort at a wheel (1.2.1 (a) (ii)) | 1 |
| Offside Rear Service brake has no recorded effort at a wheel (1.2.1 (a) (ii)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Front Service brake excessively binding x2 (1.2.1 (f)) | 1 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt SPLIT (6.1.7 (g) (ii)) | 1 |
| Offside Front Steering rack gaiter missing or no longer prevents the ingress of dirt INSECURE AND SPLIT (2.1.3 (g) (ii)) | 1 |
| Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt SPLIT (2.1.3 (g) (ii)) | 1 |
| Towbar component excessively corroded MAIN FRAME HOLED (6.1.6 (a)) | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.3| | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sill (5.3.6 (a) (i)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sill (5.3.6 (a) (i)) | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength jacking point (5.3.6 (a) (i)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength jacking point (5.3.6 (a) (i)) | 1 |
| Offside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Centre Stop lamp not working |1.3.2a| | 1 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Front Outer Seat belt anchorage prescribed area strength or continuity significantly reduced Sill (7.1.1 (a) (i)) | 1 |
| Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Front Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Upper Seat belt fluffed or frayed which has clearly weakened the webbing |5.1.B.3b| | 1 |
| Nearside Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Nearside Front Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Inner Rear Seat belt locking mechanism does not secure or release |5.1.B.6a| | 1 |
| Offside Outer Rear Seat belt retracting mechanism defective |5.1.B.6b| | 1 |
| Nearside Rear Seat belt retracting mechanism defective |5.1.B.6b| | 1 |
| Offside Seat belt damaged sufficient to significantly weakened the webbing |5.2.2a| | 1 |
| Offside Inner Rear Seat belt fluffed or frayed which has clearly weakened the webbing |5.1.B.3b| | 1 |
| Nearside Outer Rear Seat belt fluffed or frayed which has clearly weakened the webbing |5.1.B.3b| | 1 |
| Nearside Outer Rear Seat belt retracting mechanism defective |5.1.B.6b| | 1 |
| Rear Emergency exit door cannot be opened from outside the vehicle |6.2.D.1a| | 1 |
| Windscreen wiper blade deteriorated |6.1.2| | 1 |
| Rear Exhaust has a mounting that does not fully support the exhaust system |6.3.1b| | 1 |
| Offside Rear Rear reflector missing |1.4.1| | 1 |
| Offside Rear Exhaust has a mounting that does not fully support the exhaust system |6.3.1b| | 1 |
| Brake load sensing valve linkage obviously incorrectly adjusted |3.6.F.4| | 1 |
| Transmission brake efficiency below requirements |3.8.A.9/10| | 1 |
| Nearside Rear Parking brake lever defective so that it cannot be satisfactorily operated |3.1.3c| | 1 |
| Rear Brake valve has an excessive discharge of oil |3.6.E.1| | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner and outer sill |5.3.6 |a| |i|| | 1 |
| Supplementary restraint system warning lamp indicates a fault |7.1.6 |a|| | 1 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Brakes imbalanced across an axle | 1 |
| Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sill (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill (5.3.6 (a) (i)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner step area (5.3.6 (a) (i)) | 1 |
| Front Fuel hose leaking in front of fuel tank (6.1.3 (b) (i)) | 1 |
| Offside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |