| Most common failures | No# failures |
|---|
| Registration plate lamp issues | 19 |
| Windscreen wiper does not clear the windscreen effectively | 10 |
| Headlamp aim out of alignment | 8 |
| Rear parking brake recording little or no effort | 6 |
| Parking brake: efficiency below requirements |3.7.B.7| | 5 |
| Offside Front Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 5 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 4 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 4 |
| Rear brake disc in such a condition that it is seriously weakened | 4 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 3 |
| Nearside Stop lamp not working |1.2.1b| | 3 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 3 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 3 |
| Front brake disc in such a condition that it is seriously weakened | 3 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
| Nearside Front Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 3 |
| Centre Stop lamp not working |1.2.1b| | 2 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 2 |
| Service brake: efficiency below requirements |3.7.B.7| | 2 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Brake pipe excessively corroded | 2 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Anti-lock braking system warning lamp indicates an ABS fault | 2 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Nearside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 2 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Centre Rear Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Rear brake application uneven | 1 |
| Offside Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 1 |
| Nearside Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Rear coil spring broken |2.4.C.1a| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Offside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Front brake application uneven | 1 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Brakes imbalanced across an axle | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Rear brake binding | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Rear Position lamp adversely affected by the operation of another lamp (4.2.3 (c)) | 1 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Fuel cap/sealing device ineffective split (6.1.3 (b) (i)) | 1 |
| Rear Electrical wiring insecure and in contact with sharp edges on tail gate (4.11 (a) (ii)) | 1 |
| Rear Electrical wiring insulation so damaged or deteriorated it is likely to cause a short-circuit bare wires in tailgate (4.11 (c) (ii)) | 1 |
| Nearside Headlamp lens seriously defective (4.1.1 (b) (ii)) | 1 |
| Offside Headlamp lens seriously defective (4.1.1 (b) (ii)) | 1 |
| Exhaust system insecure both mountings broken (6.1.2 (a)) | 1 |
| Offside Front Lower Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn rear (5.3.4 (a) (i)) | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Centre Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 1 |
| Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 1 |
| Exhaust emits excessive smoke or vapour of any colour |7.4.B.4| | 1 |
| Steering lock fails to engage |2.1.4b| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Brake pedal has no servo assistance |3.3.B.2| | 1 |
| Offside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
| Brake pedal has insufficient reserve movement |3.3.A.5| | 1 |
| Offside Front Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Front Macpherson strut upper support bearing is rough in operation |2.5.B.1b| | 1 |
| Offside Front Macpherson strut upper support bearing is rough in operation |2.5.B.1b| | 1 |
| Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Front Position lamp not working |4.2.1 |a|| | 1 |
| Offside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Rear Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 1 |
| Offside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Nearside Front Upper Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Upper Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Front Anti-roll bar ball joint excessively worn o/s and n/s (5.3.4 (a) (i)) | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Exhaust emissions likely to be affected by an exhaust leak Front pipe cat (8.2.2.1 (b)) | 1 |
| Emissions not tested Exhaust blow (8.2.1.2 (d)) | 1 |
| Prop shaft likely to become detached Rubber coupling breaking up (6.1.7 (a) (ii)) | 1 |
| Offside Front Steering linkage ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Front constant velocity joint is insecure |2.5.C.1b| | 1 |
| Offside Rear Position lamp adversely affected by the operation of another lamp (4.2.3 (c)) | 1 |
| Offside Rear Stop lamp(s) adversely affected by the operation of another lamp (4.3.3 (b)) | 1 |
| Nearside Rear Lower Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Nearside Front Brake lining|s| less than 1.5 mm thick |3.5.1g| | 1 |
| Offside Front Brake lining|s| less than 1.5 mm thick |3.5.1g| | 1 |
| Registration plate issues | 1 |
| Rear Sub-frame attachment bracket/mounting corroded and its strength is seriously reduced |2.4.G.1| | 1 |
| Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Ball joint has excessive play |2.2.B.1f| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Rear brake disc excessively pitted |3.5.1h| | 1 |
| Offside Front Front constant velocity joint is insecure |2.5.C.1b| | 1 |
| Offside Front coil spring broken |2.4.C.1a| | 1 |
| Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.A.3| | 1 |