| Most common failures | No# failures |
|---|
| Parking brake: efficiency below requirements |3.7.B.7| | 9 |
| Headlamp aim out of alignment | 7 |
| Service brake: efficiency below requirements |3.7.B.7| | 7 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 7 |
| Windscreen wiper does not clear the windscreen effectively | 5 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 5 |
| Registration plate lamp issues | 5 |
| Horn not working |1.6.2a| | 3 |
| Nearside Rear Shock absorber has an excessively worn bush |2.7.4| | 2 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Rear parking brake recording little or no effort | 2 |
| Emissions not tested |7.0| | 2 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Brake load sensing valve linkage seized |3.6.E.3| | 2 |
| Brake pipe excessively corroded | 2 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Brake performance not tested (1.2.1 (g)) | 1 |
| Brake pedal has insufficient reserve travel (1.1.2 (a)) | 1 |
| Rear fog lamp switch inoperative (4.5.3 (a)) | 1 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Front Valve stem seriously damaged (5.2.3 (j)) | 1 |
| Nearside Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Fuel cap/sealing device sealing washer torn |7.2.4c| | 1 |
| Windscreen washer not working | 1 |
| Offside Headlamp reflector seriously defective |4.1.1 |b| |ii|| | 1 |
| Nearside Rear Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Front Service brake excessively binding |1.2.1 |f|| | 1 |
| Offside Front Service brake excessively binding |1.2.1 |f|| | 1 |
| Offside Rear Suspension component mounting prescribed area excessively damaged significantly reducing structural strength damper top mounting |5.3.6 |a| |i|| | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength |5.3.6 |a| |i|| | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength |5.3.6 |a| |i|| | 1 |
| Nearside Front Valve stem seriously damaged |4.1.D.1e| | 1 |
| Nearside Front Side repeater not working |1.4.A.2c| | 1 |
| Windscreen has damage | 1 |
| Nearside Rear Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
| Front Direction indicator not working |1.4.A.2c| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Radius arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Rear Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Offside Rear Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 1 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Exhaust engine idle speed too high |7.3.D.1| | 1 |
| Rear brake application uneven | 1 |
| Brakes imbalanced across an axle | 1 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Power steering fluid level below minimum |2.3.1| | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| front brake binding |3.7.B.1| | 1 |
| Fuel tank leaking |7.2.3| | 1 |
| Exhaust noise is clearly in excess of that emitted by a similar vehicle fitted with a standard silencer in average condition |7.1.4| | 1 |
| Offside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Nearside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Nearside Obligatory mirror missing (3.3 (a)) | 1 |
| Nearside Side repeater missing (4.4.1 (a) (ii)) | 1 |
| Nearside Front Direction indicator missing (4.4.1 (a) (ii)) | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 1 |
| Brake pedal anti-slip provision missing (1.1.2 (c)) | 1 |
| Offside Rear Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Nearside Rear Inner Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting cab within seat belt ancoridge |6.2.2 |d| |i|| | 1 |
| Nearside Front Inner Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting cab within seat belt anchorage |6.2.2 |d| |i|| | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits |8.2.1.2 |c|| | 1 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 1 |
| Nearside Rear Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength leaf spring mount (5.3.6 (a) (i)) | 1 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Horn emits two or more alternating tones |1.6.2d| | 1 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Vehicle structure has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Vehicle structure has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Exhaust has a part missing |7.1.1a| | 1 |
| Exhaust tailpipe not capable of allowing the emission probe to be inserted |7.3.D.1| | 1 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Offside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Rear Brake pipe inadequately supported |3.6.B.1| | 1 |
| Offside rear brake grabbing severely |3.7.A.5b| | 1 |
| Nearside Obligatory mirror insecure |8.1.1| | 1 |
| Rear reflector missing |1.5.1a| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Rear Brake load sensing valve seized |3.6.E.3| | 1 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Stop lamp excessively damaged so that it is not visible from a reasonable distance |1.2.1d| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Registration plate issues | 1 |
| Front position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Fuel hose leaking |7.2.3| | 1 |
| Outer Exhaust system not adequately supported |7.1.1| | 1 |