| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 25 |
| Registration plate lamp issues | 24 |
| Headlamp aim out of alignment | 16 |
| Registration plate issues | 12 |
| Brakes imbalanced across an axle | 11 |
| Front brake disc in such a condition that it is seriously weakened | 6 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 6 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 5 |
| Rear brake binding | 5 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 5 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 4 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 4 |
| Horn not working |1.6.2a| | 4 |
| Offside Front Front constant velocity joint gaiter split |2.5.C.1a| | 3 |
| Nearside Stop lamp not working |1.2.1b| | 3 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 3 |
| Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 3 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 3 |
| Rear Brake load sensing valve linkage seized |3.6.E.3| | 3 |
| Hazard warning switch faulty |1.4.B.1d| | 3 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 3 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 3 |
| Service brake: efficiency below requirements |3.7.B.7| | 3 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Nearside Front Anti-roll bar linkage fractured |2.4.G.1| | 3 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 3 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 2 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 2 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 2 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 2 |
| Windscreen has damage | 2 |
| Nearside Front Front constant velocity joint gaiter split |2.5.C.1a| | 2 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 2 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 2 |
| Offside Front constant velocity joint gaiter split |2.5.C.1a| | 2 |
| Offside Rear wheel bearing rough when rotated |2.6.1| | 2 |
| Emissions not tested |7.0| | 2 |
| Nearside Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 2 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 2 |
| Offside Rear Upper Shock absorber has an excessively worn bush |2.7.4| | 2 |
| Parking brake: efficiency below requirements |3.7.B.7| | 2 |
| Brake pedal anti-slip provision worn smooth |3.3.A.1b| | 2 |
| Rear parking brake recording little or no effort | 2 |
| Offside Rear Stop lamp not working |1.2.1b| | 2 |
| Direction indicators not working |1.4.A.2c| | 2 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 2 |
| Nearside Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 2 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Centre Stop lamp not working |1.2.1b| | 2 |
| Nearside Rear wheel bearing rough when rotated |2.6.1| | 2 |
| Nearside Front Lower Suspension arm attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Offside rear brake excessively fluctuating |3.7.B.3| | 1 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
| Offside Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
| Emissions not tested |7.3.A.1| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Position lamp light intensity significantly reduced flickering (4.2.3 (a) (ii)) | 1 |
| Parking brake lever, pawl mechanism pivots or their associated mountings are insecure |3.1.4b| | 1 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Nearside Front Suspension arm pin or bush excessively worn lower arm front bush (5.3.4 (a) (i)) | 1 |
| Horn not working (7.7 (a)) | 1 |
| Offside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Rear Brake load sensing valve seized |3.6.E.3| | 1 |
| Front coil spring broken |2.4.C.1a| | 1 |
| Offside Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Seat belt affected by an insecure seat fixing |5.2.1b| | 1 |
| Offside Front Seat belt affected by an insecure seat fixing |5.2.1b| | 1 |
| Driver`s seat insecure |6.2.A.1| | 1 |
| Nearside Front Passenger`s seat insecure |6.2.A.1| | 1 |
| Brake load sensing valve linkage seized |3.6.E.3| | 1 |
| Offside Front Anti-roll bar linkage fractured |2.4.G.1| | 1 |
| Nearside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Front Direction indicators not working |1.4.A.2c| | 1 |
| Rear Direction indicators not working |1.4.A.2c| | 1 |
| Nearside Front Headlamp insecure |1.7.3| | 1 |
| Nearside Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Nearside Rear Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Offside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Offside Rear Service brake grabbing severely (1.2.1 (c)) | 1 |
| Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Front passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Nearside Rear reflector missing |1.5.1a| | 1 |
| Offside Front coil spring fractured |2.4.C.1a| | 1 |
| Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Horn not working |7.7 |a| |ii|| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Nearside Front Anti-roll bar linkage insecure and impairing directional stability |5.3.3 |a| |ii|| | 1 |
| Offside Front Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
| Nearside Front coil spring broken |2.4.C.1a| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Outer Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Outer Front Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Steering locking device insecure steering rack |2.2.C.1g| | 1 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Anti-roll bar linkage rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front Suspension arm has excessive play in a ball joint play detected with shaker plates |2.4.G.2| | 1 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Anti-roll bar linkage damaged and seriously weakened n/s and o/s front |2.4.G.1| | 1 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 1 |
| Offside Front Front position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Obligatory mirror missing |8.1.1| | 1 |
| Nearside Front Macpherson strut has excessive play in the sliding bush or gland |2.5.B.1b| | 1 |
| Offside Front Macpherson strut has excessive play in the sliding bush or gland |2.5.B.1b| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Offside Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Offside Front Macpherson strut damaged and seriously weakened |5.3.3 |b| |i|| | 1 |
| Exhaust carbon monoxide content at idle exceeds default limits |8.2.1.2 |b|| | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds default limits |8.2.1.2 |b|| | 1 |
| Nearside Rear Service brake effort inadequate at a wheel |1.2.1 |a| |i|| | 1 |
| Nearside Front Lower Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Exhaust engine idle speed too high |7.3.D.1| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Front constant velocity joint is excessively worn |2.5.C.1b| | 1 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Parking brake lever, pawl mechanism pivot|s| or their associated mountings locking device insecure |3.1.4b| | 1 |
| Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Nearside Front front brake juddering severely |3.7.A.2b| | 1 |
| Brake load sensing valve seized |3.6.E.3| | 1 |
| Centre Rear Upper Stop lamp not working |1.2.1b| | 1 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front coil spring inappropriately repaired |2.4.A.2| | 1 |
| Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 1 |
| Offside Front brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Headlamp insecure |1.7.3| | 1 |
| Battery insecure |1.9.1| | 1 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Front Anti-roll bar linkage severely distorted |2.4.G.1| | 1 |
| Brake load sensing valve linkage defective and function impaired |3.6.E.3| | 1 |
| Nearside Front coil spring fractured |2.4.C.1a| | 1 |
| Nearside Anti-roll bar linkage fractured |2.4.G.1| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Hazard warning switch missing |1.4.B.1d| | 1 |
| Rear Exhaust mounting missing |7.1.1b| | 1 |
| Nearside Rear Shock absorber has negligible damping effect |2.7.5| | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear fog lamp does not emit a steady red light |1.3.2e| | 1 |
| Nearside Front coil spring incomplete |2.4.C.1a| | 1 |
| Offside Front Anti-roll bar linkage missing |2.4.G.1| | 1 |
| Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
| Nearside Rear Upper Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Steering column universal joint has excessive play |2.1.5| | 1 |
| Nearside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Nearside Rear Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Offside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
| Windscreen wiper blade insecure | 1 |
| Offside Rear reflector missing |1.5.1a| | 1 |
| Offside Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Obligatory mirror missing |8.1.1| | 1 |
| Nearside Outer Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front Lower Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Centre Rear Seat belt retracting mechanism defective |5.2.5b| | 1 |