Most common failures | No# failures |
---|
Parking brake: efficiency below requirements |3.7.B.7| | 34 |
Windscreen wiper does not clear the windscreen effectively | 20 |
Headlamp aim out of alignment | 16 |
Rear parking brake recording little or no effort | 13 |
Registration plate lamp issues | 12 |
Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 7 |
Offside Front position lamp|s| not working |1.1.A.3b| | 6 |
Horn not working |1.6.2a| | 5 |
Service brake: efficiency below requirements |3.7.B.7| | 4 |
Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 4 |
Parking brake lever has no reserve travel |3.1.6b| | 4 |
Brake pipe excessively corroded | 4 |
Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 3 |
Service brake efficiency below requirements (1.2.2 (a) (i)) | 3 |
Parking brake efficiency below requirements (1.4.2 (a) (i)) | 3 |
Hazard warning switch faulty |1.4.B.1d| | 3 |
Parking brake efficiency below requirements |1.4.2 |a| |i|| | 3 |
Rear brake disc in such a condition that it is seriously weakened | 3 |
Centre Stop lamp not working |1.2.1b| | 3 |
Brakes imbalanced across an axle | 3 |
Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 3 |
Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 3 |
Offside Rear fog lamp not working |1.3.2b| | 3 |
Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 3 |
Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
Offside Rear position lamp|s| not working |1.1.A.3b| | 2 |
Offside Stop lamp not working |1.2.1b| | 2 |
Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 2 |
Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 2 |
Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
Rear fog lamp tell tale not working |1.3.1b| | 2 |
Nearside front brake binding |3.7.B.1| | 2 |
Offside front brake binding |3.7.B.1| | 2 |
Offside Parking brake inoperative on one side (1.4.1 (a)) | 2 |
Nearside Front wheel bearing rough when rotated |2.5.A.2| | 2 |
Nearside Rear wheel bearing rough when rotated |2.6.1| | 2 |
Nearside Front Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
Rear brake binding | 2 |
Horn not working |7.7 |a| |ii|| | 2 |
Anti-lock braking system warning lamp indicates an ABS fault | 2 |
Nearside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
Nearside Rear Braking system leaking brake pipe |3.6.A.1| | 1 |
Nearside Front Lower Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Nearside Front Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
Nearside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
Offside Steering rack gaiter split |2.2.D.2d| | 1 |
Rear Anti-roll bar insecure |2.4.G.1| | 1 |
Rear Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt both outer |2.4.G.2| | 1 |
Brake fluid warning lamp illuminated |3.6.G.2| | 1 |
Brake pedal creeps down while the pedal is held under pressure |3.3.B.1a| | 1 |
Nearside Front position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Offside Brake cable has restricted free movement |3.5.1k| | 1 |
Offside Front position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
Offside Front Steering rack gaiter missing or no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Fuel cap/sealing device does not fasten securely by positive means |7.2.4b| | 1 |
Brake pedal anti-slip provision worn smooth |3.3.A.1b| | 1 |
Front brake application uneven | 1 |
Offside front brakes release unevenly |3.7.B.4| | 1 |
Rear brake application uneven | 1 |
rear brakes release unevenly |3.7.B.4| | 1 |
Brake pedal has no servo assistance |3.3.B.2| | 1 |
Nearside Rear Rear wheel bearing rough when rotated |2.6.1| | 1 |
Fuel system component leaking |7.2.3| | 1 |
Nearside Headlamp insecure |1.7.3| | 1 |
Power steering pipe|s| or hose|s| leaking |2.3.3b| | 1 |
Offside Front Upper Headlamp insecure |1.7.3| | 1 |
Nearside Rear Leaf spring damaged and permanently distorted |2.4.B.1a| | 1 |
Offside Rear Leaf spring deteriorated and seriously weakened |2.4.B.1a| | 1 |
Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
Emissions not tested |7.0| | 1 |
Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings side panel base in close proximity to body strengthening inserts / supports corroded |6.1.B.2| | 1 |
Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced outer sill (6.1.1 (c) (i)) | 1 |
Offside Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced outer sill (6.1.1 (c) (i)) | 1 |
Rear Brake disc significantly and obviously worn corroded |1.1.14 |a| |i|| | 1 |
Nearside Rear brake disc excessively pitted |3.5.1h| | 1 |
Offside Rear brake disc excessively pitted |3.5.1h| | 1 |
Nearside Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Windscreen has damage | 1 |
Nearside Outer Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 1 |
Offside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
Front Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
Nearside Front Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Nearside Front Brake pipe inadequately supported |3.6.B.1| | 1 |
Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
Offside Rear fog lamp does not emit a steady red light |4.5.4 |a|| | 1 |
Offside Rear Direction indicator adversely affected by the operation of another lamp |4.4.3 |b|| | 1 |
Windscreen washer not working | 1 |
Nearside Side repeater not working (4.4.1 (a) (ii)) | 1 |
Dipswitch does not operate immediately when selected on dipped beam (4.1.3 (b)) | 1 |
Front brake disc in such a condition that it is seriously weakened | 1 |
Offside Front Service brake excessively binding |1.2.1 |f|| | 1 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
Rear fog lamp not working |1.3.2b| | 1 |
Offside Front front brake binding |3.7.B.1| | 1 |
Hazard warning switch inoperative (4.4.2 (a) (ii)) | 1 |
Offside Rear wheel bearing rough when rotated |2.6.1| | 1 |
Offside Parking brake inoperative on one side |1.4.1 |a|| | 1 |
Nearside Rear Outer Anti-roll bar pin or bush excessively worn missing |5.3.4 |a| |i|| | 1 |
Nearside Rear Wheel bearing rough when rotated |5.1.3 |b| |i|| | 1 |
Brake cable has restricted free movement cable siezed |3.5.1k| | 1 |
Offside Rear Anti-roll bar linkage has excessive play in a pin/bush link rod bush |2.4.G.2| | 1 |
Nearside Rear brake caliper has restricted free movement |3.5.1k| | 1 |
Centre Rear Stop lamp not working |1.2.1b| | 1 |
Front Fuel pipe leaking |7.2.3| | 1 |
Exhaust system not adequately supported |7.1.1| | 1 |
Offside Rear Brake cable has restricted free movement not moving at brake caliper lever |1.1.15 |e|| | 1 |
Offside Rear Parking brake inoperative on one side 20kgs brake force off side only 200gks brake force advise inspection on both sides |1.4.1 |a|| | 1 |
Nearside Rear Anti-roll bar linkage insecure |2.4.G.1| | 1 |
Offside Rear brake caliper has restricted free movement |3.5.1k| | 1 |
Offside Parking brake lever has no reserve travel |3.1.6b| | 1 |
Offside Side repeater not working |1.4.A.2c| | 1 |
Brake hose excessively deteriorated | 1 |
Lower Steering column universal joint has excessive play |2.1.5| | 1 |
Nearside Front Lower Seat belt anchorage prescribed area is excessively corroded outer sill |5.2.6| | 1 |
Nearside Front Subframe mounting prescribed area is deliberately modified which significantly reduces the original strength |2.4.A.3| | 1 |
Offside Front Subframe mounting prescribed area is deliberately modified which significantly reduces the original strength |2.4.A.3| | 1 |
Offside Upper Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Power steering pipe|s| or hose|s| fouling other parts of the vehicle fouling offside driveshaft inner cv joint. Also the inner cv joints touches or runs very close to the engine block. |2.3.2| | 1 |
Nearside Front Suspension component mounting prescribed area is deliberately modified which significantly reduces the original strength subframe mount |2.4.A.3| | 1 |
Offside Front Suspension component mounting prescribed area is deliberately modified which significantly reduces the original strength subframe mount |2.4.A.3| | 1 |
Nearside Front Suspension component mounting prescribed area is inadequately repaired inner sill |2.4.A.3| | 1 |
Offside Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
Offside Steering rack gaiter missing or no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
Nearside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
Nearside Front Upper Ball joint has excessive play |2.2.B.1f| | 1 |
Offside Front Upper Ball joint has excessive play |2.2.B.1f| | 1 |
Offside Front Lower Ball joint has excessive play |2.2.B.1f| | 1 |
Offside Rear position lamp|s| incomplete |1.1.4a| | 1 |
Offside Front Lower Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Offside Front Lower Shock absorber insecure |2.7.2b| | 1 |
Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Nearside Front Headlamp insecure |1.7.3| | 1 |
Offside Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
Offside All position lamps not working |1.1.A.3b| | 1 |
Nearside Rear Lower Rear reflector missing (4.8.2 (a) (ii)) | 1 |
Nearside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Nearside Rear Anti-roll bar linkage pin or bush likely to become detached |5.3.4 |a| |ii|| | 1 |
Centre Front Fuel pipe union leaking |7.2.3| | 1 |
Hazard warning switch inoperative |4.4.2 |a| |ii|| | 1 |
Offside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
Indicator switch insecure |1.4.A.1| | 1 |
Registration plate issues | 1 |
Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
Direction indicators not working |1.4.A.2c| | 1 |
Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
Offside Inner Ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Stop lamp not working |1.2.1b| | 1 |
Centre Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Power steering pipe|s| or hose|s| leaking from a joint |2.3.3b| | 1 |
Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
Offside Rear Direction indicator lens defective such that the emitted light is adversely affected (4.4.1 (b) (ii)) | 1 |
Horn not working (7.7 (a) (ii)) | 1 |
Nearside Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner and outer sill (5.3.6 (a) (i)) | 1 |
Offside Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner and outer sill (5.3.6 (a) (i)) | 1 |
Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength jacking point (5.3.6 (a) (i)) | 1 |
Nearside Parking brake inoperative on one side |1.4.1 |a|| | 1 |
Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
Nearside Front Suspension arm inappropriately repaired |2.4.A.2| | 1 |
Nearside Front Anti-roll bar insecure |2.4.G.1| | 1 |
Brake performance not tested |3.7.A.1| | 1 |
Horn not working (7.7 (a)) | 1 |
Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner and outer sill (5.3.6 (a) (i)) | 1 |
Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner and outer sill (5.3.6 (a) (i)) | 1 |
Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength jack point (5.3.6 (a) (i)) | 1 |
Hazard warning switch missing |1.4.B.1d| | 1 |
Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Nearside Side repeater not working |1.4.A.2c| | 1 |
Power steering component leaking rack (2.1.5 (a)) | 1 |
Nearside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 1 |
Oil leaking excessively from engine (8.4.1 (a) (i)) | 1 |
Offside Rear Anti-roll bar linkage rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Rear Anti-roll bar rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Offside Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
Service brake efficiency less than 50% of the required value |1.2.2 |a| |ii|| | 1 |
Supplementary restraint system warning lamp indicates a fault |7.1.6 |a|| | 1 |
Offside Side repeater not working |4.4.1 |a| |ii|| | 1 |
Brake pedal has insufficient reserve travel service brake |1.1.2 |a|| | 1 |