| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 10 |
| Registration plate lamp issues | 8 |
| Windscreen wiper does not clear the windscreen effectively | 7 |
| Brake pipe excessively corroded | 7 |
| Service brake: efficiency below requirements |3.7.B.7| | 5 |
| Parking brake: efficiency below requirements |3.7.B.7| | 5 |
| Brakes imbalanced across an axle | 4 |
| Windscreen washer not working | 3 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Registration plate issues | 3 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Exhaust system not adequately supported |7.1.1| | 2 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Nearside Rear wheel bearing rough when rotated |2.6.1| | 2 |
| Brake load sensing valve linkage seized |3.6.E.3| | 2 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Battery insecure |1.9.1| | 2 |
| Brake hose excessively deteriorated | 2 |
| Nearside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Offside Rear wheel bearing rough when rotated |2.6.1| | 2 |
| Rear fog lamp tell tale not working |1.3.1b| | 2 |
| Offside front brake binding |3.7.B.1| | 2 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 2 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt split (2.1.3 (g) (ii)) | 1 |
| Offside Front Steering rack gaiter missing or no longer prevents the ingress of dirt split (2.1.3 (g) (ii)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Nearside Front Direction indicator obviously incorrectly positioned (4.4.3 (a)) | 1 |
| Nearside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings rear tow bar and spring mounts |6.1.B.2| | 1 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Rear Service brake effort inadequate at a wheel |1.2.1 |a| |i|| | 1 |
| Service brake efficiency less than 50% of the required value |1.2.2 |a| |ii|| | 1 |
| Rear brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
| Offside Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
| Service brake efficiency less than 50% of the required value (1.2.2 (a) (ii)) | 1 |
| Rear parking brake recording little or no effort | 1 |
| Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Windscreen has damage | 1 |
| Centre Stop lamp not working |1.2.1b| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Brake load sensing valve linkage defective and function impaired missing |3.6.E.3| | 1 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Central Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Exhaust has a major leak of exhaust gases tail pipe near mounting point (6.1.2 (a)) | 1 |
| Offside Rear Service brake lagging in operation 100 kg behind (1.2.1 (d)) | 1 |
| Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt insecure |6.1.7 |g| |ii|| | 1 |
| Offside Front Brake hose leaking on a hydraulic braking system (1.1.12 (c) (ii)) | 1 |
| Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced both rear section of sills chalked in yellow (6.1.1 (c) (i)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength at upper shocker mount chalked in yellow (5.3.6 (a) (i)) | 1 |
| Offside Upper Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Fuel system component leaking |7.2.3| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Outer Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Nearside Front Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Horn not working |1.6.2a| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Emissions not tested |7.4.B.1| | 1 |
| Offside All position lamps not working |1.1.A.3b| | 1 |
| Centre Front Upper Fuel hose leaking |7.2.3| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 1 |
| Body has a sharp edge caused by corrosion offside body panel |6.1.C.1| | 1 |
| Suspension component mounting prescribed area is excessively corroded nearside front outrigger/jacking point |2.4.A.3| | 1 |
| Suspension spring mounting prescribed area is excessively corroded nearside rear inner sill |2.4.A.3| | 1 |
| Suspension spring mounting prescribed area is excessively corroded offside rear outer sill |2.4.A.3| | 1 |
| Suspension spring mounting prescribed area is excessively corroded nearside rear inner valance |2.4.A.3| | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill |5.3.6 |a| |i|| | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill |5.3.6 |a| |i|| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Offside Front Brake pipe leaking on a hydraulic braking system on calliper (1.1.11 (b) (ii)) | 1 |
| Brake performance not tested (1.2.1 (g)) | 1 |
| Nearside Rear Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Body or chassis has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Body or chassis has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Offside Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded crossmember behind front wheel |2.4.A.3| | 1 |
| Nearside Front Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Brake pedal anti-slip provision missing (1.1.2 (c)) | 1 |
| Nearside Front Subframe mounting prescribed area excessively corroded significantly reducing structural strength marked yellow (5.3.6 (a) (i)) | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |