| Most common failures | No# failures |
|---|
| Parking brake: efficiency below requirements |3.7.B.7| | 47 |
| Headlamp aim out of alignment | 24 |
| Rear parking brake recording little or no effort | 18 |
| Windscreen wiper does not clear the windscreen effectively | 16 |
| Parking brake lever has no reserve travel |3.1.6b| | 15 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 11 |
| Service brake: efficiency below requirements |3.7.B.7| | 11 |
| Rear brake binding | 9 |
| Brakes imbalanced across an axle | 6 |
| Registration plate lamp issues | 6 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 5 |
| Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 4 |
| Offside Steering rack gaiter split |2.2.D.2d| | 4 |
| Registration plate issues | 4 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 4 |
| Stop lamp remains on when the brakes are released | 4 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
| Anti-lock braking system warning lamp indicates an ABS fault | 4 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 3 |
| Battery insecure |1.9.1| | 3 |
| Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 3 |
| Rear brake disc in such a condition that it is seriously weakened | 3 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 3 |
| Stop lamp not working |1.2.1b| | 3 |
| Offside Rear fog lamp not working |1.3.2b| | 3 |
| Rear brake disc excessively pitted |3.5.1h| | 2 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 2 |
| Emissions not tested |7.0| | 2 |
| Rear fog lamp not working |1.3.2b| | 2 |
| Rear Mechanical brake component has restricted free movement | 2 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 2 |
| Windscreen washer not working | 2 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Horn not working |1.6.2a| | 2 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 2 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 2 |
| Exhaust emissions hydrocarbon content excessive (8.2.1.2 (b)) | 2 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 2 |
| Nearside Front Steering rack gaiter split |2.2.D.2d| | 2 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 2 |
| Offside front brake binding |3.7.B.1| | 2 |
| Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 2 |
| Offside Rear An item not tested |Manual| | 2 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 2 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 2 |
| Brake pedal anti-slip provision worn smooth |3.3.A.1b| | 1 |
| Front brake disc excessively pitted |3.5.1h| | 1 |
| Nearside front brake juddering severely |3.7.A.2b| | 1 |
| Offside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Brake lever has abnormal movement of levers indicating maladjustment |3.5.1f| | 1 |
| Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded and offside rail, in centre |2.4.A.3| | 1 |
| Nearside Front front brake binding |3.7.B.1| | 1 |
| Offside Front front brake binding |3.7.B.1| | 1 |
| Nearside Rear front brake binding |3.7.B.1| | 1 |
| Offside Rear front brake binding |3.7.B.1| | 1 |
| Nearside Rear Lower Suspension arm corroded and seriously weakened |2.4.G.1| | 1 |
| Offside Rear Lower Suspension arm corroded and seriously weakened |2.4.G.1| | 1 |
| Brake pedal spongy |3.3.B.1b| | 1 |
| Nearside front brake binding and offside |3.7.B.1| | 1 |
| Nearside Front Service brake excessively binding |1.2.1 |f|| | 1 |
| Offside Front Service brake excessively binding |1.2.1 |f|| | 1 |
| Nearside Rear Hydraulic fluid leaking excessively from brake caliper |8.4.1 |a| |i|| | 1 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 1 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 1 |
| Offside Direction indicators not in good working order |function impaired| |1.5.A1b| | 1 |
| Rear Stop lamp excessively damaged so that it is not visible from a reasonable distance |1.2.1d| | 1 |
| Front brake disc in such a condition that it is seriously weakened | 1 |
| Offside Headlamp insecure |1.7.3| | 1 |
| Brake hose damaged | 1 |
| Offside Inner Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Nearside Rear Lower Suspension arm attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Rear Service brake has no recorded effort at a wheel BOTH (1.2.1 (a) (ii)) | 1 |
| Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Brake performance not tested (1.2.1 (g)) | 1 |
| Parking brake inoperative on one side BOTH (1.4.1 (a)) | 1 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Rear Brake pipe leaking |3.6.A.1| | 1 |
| Nearside Front suspension has a suspension upper ball joint securing nut not locked |2.5.B.1a| | 1 |
| Offside Front suspension has a suspension upper ball joint securing nut not locked |2.5.B.1a| | 1 |
| Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Front Steering system fouling brake hose on anti roll bar on lock (2.1.4 (a)) | 1 |
| Exhaust emissions - engine idle speed too high (8.2.1.2 (e)) | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| front brakes release unevenly |3.7.B.4| | 1 |
| Hazard warning switch insecure |1.4.B.1d| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Sub-frame corroded and seriously weakened |2.4.G.1| | 1 |
| Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Offside Rear Sub-frame corroded and seriously weakened by master cylinder and bulkhead |2.4.G.1| | 1 |
| Offside Rear Braking system leaking |3.6.A.1| | 1 |
| Nearside Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
| Offside Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
| Nearside Inner Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Rear fog lamp switch faulty |1.3.1a| | 1 |
| Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Front brake excessively fluctuating | 1 |
| Offside Side repeater has a product on the light source so it is not visible from a reasonable distance |1.4.A.2e| | 1 |
| Offside Brake cable has restricted free movement |3.5.1k| | 1 |
| Offside Front An item not tested |Manual| | 1 |
| Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Offside Front Suspension arm corroded and seriously weakened |2.4.G.1| | 1 |
| Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Rear Coil spring not correctly located |2.4.C.2| | 1 |
| Nearside Front Suspension arm ball joint likely to become detached (5.3.4 (a) (ii)) | 1 |
| Battery insecure and likely to cause a short circuit (4.13 (a) (ii)) | 1 |
| Nearside Rear Vehicle structure is cracked, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Sub-frame corroded and seriously weakened |2.4.G.1| | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Brake fluid warning lamp inoperative |3.6.G.2| | 1 |
| Brake pedal has no servo assistance |3.3.B.2| | 1 |
| Brake pedal has insufficient reserve movement |3.3.A.5| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Side repeater not working |1.4.A.2c| | 1 |
| Nearside Side repeater excessively damaged so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
| Windscreen washer control is inaccessible to the driver |8.2.1a| | 1 |
| Windscreen wiper control is inaccessible to the driver |8.2.1a| | 1 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Brake cable locking device insecure |3.5.1l| | 1 |
| Nearside Rear brake caliper leaking |3.6.A.1| | 1 |
| Nearside Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
| Offside Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
| Nearside Inner Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Direction indicator flashing less than 60 times a minute |1.4.A.2g| | 1 |
| Steering rack damaged and unserviceable |2.2.C.1d| | 1 |
| Centre Front Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Upper Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Centre Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Driver`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Offside Driver`s seat insecure |6.2.A.1| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Direction indicator flashing less than 60 times a minute |1.4.A.2g| | 1 |
| brake disc excessively pitted |3.5.1h| | 1 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Brake hose has insufficient room to move | 1 |
| Nearside Front Front suspension has excessive movement at a tie bar joint |2.5.A.1c| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Side repeater missing |1.4.A.2b| | 1 |
| Offside Side repeater missing |1.4.A.2b| | 1 |
| Nearside Front Suspension arm attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| rear parking |secondary| brakes imbalanced | 1 |
| Offside Front Macpherson strut cracked |2.4.G.1| | 1 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Hazard warning switch inoperative (4.4.2 (a) (ii)) | 1 |
| Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
| Brake hose excessively deteriorated | 1 |
| Offside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Speedometer cannot be illuminated (7.8 (c) (ii)) | 1 |
| Speedometer clearly inoperative (7.8 (b) (ii)) | 1 |
| Main beam tell-tale not working (4.9.1 (a) (ii)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Fluid leak harmful to the environment or a risk to other road users (8.4.1 (a) (i)) | 1 |
| Offside Front Lower Sub-frame corroded and seriously weakened |2.4.G.1| | 1 |
| Nearside Front Lower Sub-frame corroded and seriously weakened |2.4.G.1| | 1 |
| Nearside Front Upper Sub-frame corroded and seriously weakened |2.4.G.1| | 1 |
| Offside Front Upper Sub-frame corroded and seriously weakened |2.4.G.1| | 1 |
| Offside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Front passenger door does not latch securely closed |6.2.B.1a| | 1 |
| Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Fuel system component leaking |7.2.3| | 1 |
| Offside Rear Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 1 |
| Exhaust emits dense blue smoke at idle |7.3.A.2b| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded inner wheel arch area |2.4.A.3| | 1 |