Most common failures | No# failures |
---|
Headlamp aim out of alignment | 987 |
Windscreen wiper does not clear the windscreen effectively | 756 |
Parking brake: efficiency below requirements |3.7.B.7| | 736 |
Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 715 |
Brake pipe excessively corroded | 550 |
Registration plate lamp issues | 477 |
Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 447 |
Rear parking brake recording little or no effort | 426 |
Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 362 |
Nearside Steering rack gaiter split |2.2.D.2d| | 331 |
Brake hose excessively deteriorated | 305 |
Emissions not tested |7.0| | 290 |
Offside Steering rack gaiter split |2.2.D.2d| | 287 |
Front Exhaust has a major leak of exhaust gases |7.1.2| | 263 |
Registration plate issues | 257 |
Brake load sensing valve linkage seized |3.6.E.3| | 235 |
Exhaust has a major leak of exhaust gases |7.1.2| | 225 |
Offside Stop lamp not working |1.2.1b| | 183 |
Brakes imbalanced across an axle | 181 |
Nearside Stop lamp not working |1.2.1b| | 180 |
Nearside Front Steering rack gaiter split |2.2.D.2d| | 172 |
Front Exhaust system not adequately supported |7.1.1| | 159 |
Parking brake lever has no reserve travel |3.1.6b| | 158 |
Fuel system component insecure |7.2.1| | 157 |
Offside Front Steering rack gaiter split |2.2.D.2d| | 152 |
Nearside Rear coil spring fractured |2.4.C.1a| | 148 |
Centre Exhaust has a major leak of exhaust gases |7.1.2| | 142 |
Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 141 |
Nearside Headlamp not working on main beam |1.7.5a| | 140 |
Rear brake binding | 138 |
Rear Exhaust has a major leak of exhaust gases |7.1.2| | 134 |
Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 131 |
Rear Brake load sensing valve linkage seized |3.6.E.3| | 130 |
Front brake disc in such a condition that it is seriously weakened | 128 |
Offside Headlamp not working on main beam |1.7.5a| | 118 |
Power steering component|s| leaking |2.3.3b| | 116 |
Service brake: efficiency below requirements |3.7.B.7| | 112 |
Offside Rear coil spring fractured |2.4.C.1a| | 111 |
Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 103 |
Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 103 |
Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 101 |
Offside Rear coil spring incomplete |2.4.C.1a| | 101 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 100 |
Centre Exhaust system not adequately supported |7.1.1| | 99 |
Centre Rear Statutory seat belt missing |5.1.1| | 97 |
Offside Front constant velocity joint gaiter split |2.5.C.1a| | 96 |
Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 94 |
Offside Front position lamp|s| not working |1.1.A.3b| | 93 |
Rear brake application uneven | 92 |
Exhaust system not adequately supported |7.1.1| | 92 |
Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 89 |
Nearside Rear coil spring incomplete |2.4.C.1a| | 85 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 85 |
Offside rear brake recording little or no effort |3.7.B.5a| | 85 |
Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 78 |
Brake hose has insufficient room to move | 73 |
Horn not working |1.6.2a| | 72 |
Offside Rear fog lamp not working |1.3.2b| | 70 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 70 |
Nearside Rear Stop lamp not working |1.2.1b| | 69 |
Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 69 |
Offside Track rod end ball joint has excessive play |2.2.B.1f| | 68 |
Exhaust engine idle speed too high |7.3.D.1| | 66 |
Windscreen has damage | 66 |
Nearside Windscreen wiper blade deteriorated |8.2.2| | 65 |
Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 63 |
Brake hose damaged | 62 |
Headlamp switch faulty |1.7.1| | 61 |
Offside Windscreen wiper blade deteriorated |8.2.2| | 58 |
Offside Rear Stop lamp not working |1.2.1b| | 57 |
Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 57 |
Offside Headlamp not working on dipped beam |1.7.5a| | 56 |
Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 56 |
Front brake application uneven | 53 |
Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 53 |
Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 48 |
Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 47 |
Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 45 |
Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 44 |
Front Exhaust mounting missing |7.1.1b| | 44 |
Bonnet cannot be secured in the closed position |8.4.1| | 44 |
Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 42 |
Offside Front Front constant velocity joint gaiter split |2.5.C.1a| | 42 |
Offside Front Windscreen wiper blade deteriorated |8.2.2| | 41 |
Rear Exhaust system not adequately supported |7.1.1| | 41 |
Offside Rear rear brake recording little or no effort |3.7.B.5a| | 41 |
Nearside Front Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 40 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 40 |
Offside Front Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 38 |
Windscreen wiper blade insecure | 38 |
Nearside Front Front constant velocity joint gaiter split |2.5.C.1a| | 36 |
Nearside Front Headlamp not working on main beam |1.7.5a| | 36 |
Offside Front Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 35 |
Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 35 |
Exhaust has part of the system excessively deteriorated |7.1.1a| | 35 |
Nearside Front Anti-roll bar linkage insecure |2.4.G.1| | 34 |
Offside Front Headlamp not working on main beam |1.7.5a| | 33 |
Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 32 |
Steering rack insecure |2.2.B.1a| | 32 |
Nearside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 31 |
Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 31 |
Offside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 31 |
Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 31 |
Rear Brake valve leaking |3.6.A.1| | 30 |
Exhaust mounting missing |7.1.1b| | 30 |
Power steering pump leaking from a failed component |2.3.3b| | 30 |
Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 30 |
Offside Rear Braking system leaking |3.6.A.1| | 29 |
Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 29 |
Offside Rear Rear fog lamp not working |1.3.2b| | 28 |
Nearside Front wheel bearing has excessive play |2.5.A.3c| | 28 |
Offside Side repeater not working |1.4.A.2c| | 27 |
Nearside Front Headlamp not working on dipped beam |1.7.5a| | 27 |
Offside Front Front position lamp|s| not working |1.1.A.3b| | 26 |
Offside Front Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 26 |
Nearside Side repeater not working |1.4.A.2c| | 26 |
Offside Front Upper Ball joint has excessive play |2.2.B.1f| | 26 |
Power steering component|s| leaking from a failed seal |2.3.3b| | 25 |
Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 25 |
Centre Exhaust mounting missing |7.1.1b| | 25 |
Front Headlamp not working on main beam |1.7.5a| | 25 |
Rear fog lamp tell tale not working |1.3.1b| | 24 |
Stop lamp remains on when the brakes are released | 24 |
Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 24 |
Headlamp not working on main beam |1.7.5a| | 23 |
Offside Rear wheel bearing rough when rotated |2.6.1| | 23 |
Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 23 |
Offside Outer Front constant velocity joint gaiter split |2.5.C.1a| | 23 |
Offside Steering rack insecure |2.2.B.1a| | 23 |
Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 22 |
Offside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 22 |
Exhaust tailpipe not capable of allowing the emission probe to be inserted |7.3.D.1| | 22 |
An item not tested |Manual| | 22 |
Nearside Rear coil spring cracked |2.4.C.1a| | 22 |
Offside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 21 |
Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 21 |
Nearside Front Upper Ball joint has excessive play |2.2.B.1f| | 21 |
Rear Exhaust has a part missing |7.1.1a| | 21 |
Rear brake disc in such a condition that it is seriously weakened | 20 |
Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 20 |
Nearside Outer Front constant velocity joint gaiter split |2.5.C.1a| | 20 |
Brake pedal anti-slip provision missing |3.3.A.1b| | 20 |
Statutory seat belt missing |5.1.1| | 19 |
Power steering pipe|s| or hose|s| leaking |2.3.3b| | 19 |
Nearside Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 19 |
Rear Fuel system component insecure |7.2.1| | 19 |
Power steering malfunctioning |2.3.3a| | 19 |
Offside Rear coil spring cracked |2.4.C.1a| | 19 |
Nearside Rear Braking system leaking |3.6.A.1| | 19 |
Stop lamp not working |1.2.1b| | 19 |
Offside Front Headlamp not working on dipped beam |1.7.5a| | 19 |
Front Exhaust has part of the system excessively deteriorated |7.1.1a| | 18 |
Brake valve leaking |3.6.A.1| | 18 |
Nearside Front Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 18 |
Rear Mechanical brake component has restricted free movement | 18 |
Centre Exhaust has part of the system excessively deteriorated |7.1.1a| | 18 |
Nearside Rear wheel bearing rough when rotated |2.6.1| | 18 |
Centre Statutory seat belt missing |5.1.1| | 18 |
Battery insecure |1.9.1| | 18 |
Offside Rear Brake load sensing valve linkage seized |3.6.E.3| | 17 |
Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 17 |
Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 16 |
Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 16 |
Rear Statutory seat belt missing |5.1.1| | 16 |
Offside Front front brake binding |3.7.B.1| | 16 |
Windscreen wiper blade deteriorated |8.2.2| | 16 |
Offside Steering rack gaiter insecure |2.2.D.2d| | 16 |
Nearside Front wheel bearing rough when rotated |2.5.A.2| | 16 |