| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 14 |
| Registration plate lamp issues | 5 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 5 |
| Parking brake: efficiency below requirements |3.7.B.7| | 5 |
| Registration plate issues | 4 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 3 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 3 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 3 |
| Nearside Stop lamp not working |1.2.1b| | 3 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 3 |
| Parking brake lever has no reserve travel |3.1.6b| | 2 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Offside Steering rack gaiter split |2.2.D.2d| | 2 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Brakes imbalanced across an axle | 2 |
| Windscreen wiper does not clear the windscreen effectively | 2 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Windscreen washer not working | 2 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Rear brake binding | 2 |
| rear brake recording little or no effort |3.7.B.5a| | 2 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 2 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Nearside Headlamp not working on main beam |1.7.5a| | 2 |
| Offside Headlamp not working on main beam |1.7.5a| | 2 |
| Nearside Front Shock absorber insecure |2.7.2b| | 2 |
| Fuel system component leaking |7.2.3| | 1 |
| Nearside Rear Electrical wiring damaged and bare wires exposed |1.9.2c| | 1 |
| Nearside Bonnet cannot be secured in the closed position |8.4.1| | 1 |
| Nearside Front Ball joint has excessive play steering rack inner ball joint |2.2.B.1f| | 1 |
| Front Exhaust system insecure (6.1.2 (a)) | 1 |
| Fuel cap/sealing device ineffective (6.1.3 (b) (i)) | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Offside Front Ball joint has excessive play steering rack inner joint |2.2.B.1f| | 1 |
| Offside Rear coil spring broken |2.4.C.1a| | 1 |
| Fuel cap/sealing device does not fasten securely by positive means |7.2.4b| | 1 |
| Nearside Front Front position lamp|s| insecure |1.1.A.3a| | 1 |
| Fuel hose leaking |7.2.3| | 1 |
| Nearside Ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Headlamp insecure (4.1.1 (c)) | 1 |
| Nearside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Central Exhaust has a major leak of exhaust gases at join to rear silencer |6.1.2 |a|| | 1 |
| Offside Rear Brake pipe leaking on an air braking system |1.1.11 |b| |i|| | 1 |
| Offside Front Upper Suspension arm fractured marked yellow |5.3.3 |b| |ii|| | 1 |
| Offside Front Lower Suspension arm pin or bush excessively worn front bush |5.3.4 |a| |i|| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Suspension arm corroded and seriously weakened |2.4.G.1| | 1 |
| Nearside Front Lower Suspension arm corroded and seriously weakened |2.4.G.1| | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| Offside Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Upper Shock absorber insecure |2.7.2b| | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover insecure so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Emissions not tested vehicle over heating |8.2.1.2 |d|| | 1 |
| Direction indicators not working |1.4.A.2c| | 1 |
| Offside Front Indicator switch faulty |1.4.A.1| | 1 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 1 |
| Offside Front brake disc excessively pitted |3.5.1h| | 1 |
| Offside Rear Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Offside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Rear Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Steering rack damaged and unserviceable |2.2.C.1d| | 1 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt both front |2.1.3 |g| |ii|| | 1 |
| Anti-roll bar pin or bush excessively worn all |5.3.4 |a| |i|| | 1 |
| Nearside Rear Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Offside Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Nearside Front Lower Suspension arm ball joint likely to become detached lock nut insecure |5.3.4 |a| |ii|| | 1 |
| Nearside Front Upper Ball joint has excessive play |2.2.B.1f| | 1 |
| Centre Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Front Shock absorbers has negligible damping effect Both front shock absorbers not working. (5.3.2 (d)) | 1 |
| Rear parking brake recording little or no effort | 1 |
| Nearside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Emissions unable to be completed engine over heating (8.2.1.2 (d)) | 1 |
| Brake performance unable to be tested (1.2.1 (g)) | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Front Track rod end ball joint has excessive play inner rack joint (2.1.3 (b) (i)) | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Direction indicators not working |1.4.A.2c| | 1 |
| Nearside Front Direction indicators adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Steering rack damaged and unserviceable |2.2.C.1d| | 1 |
| Headlamp aim not tested |1.8.A.1c| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Drag link end loose |2.2.B.1d| | 1 |
| Brake pipe excessively corroded | 1 |
| Fuel system component insecure |7.2.1| | 1 |
| Nearside Rear position lamp|s| insecure |1.1.A.3a| | 1 |
| Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Suspension arm corroded and seriously weakened |2.4.G.1| | 1 |
| Nearside Front Hydraulic brake calliper leaking (1.1.16 (b) (i)) | 1 |
| Steering system excessively tight |2.2.D.1| | 1 |
| Nearside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Hazard warning switch inoperative (4.4.2 (a) (ii)) | 1 |
| Nearside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 1 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Offside Front Headlamp insecure |1.7.3| | 1 |
| Nearside Front Road wheel distorted |4.2.A.1a| | 1 |
| Offside Front Road wheel distorted |4.2.A.1a| | 1 |
| Nearside Rear Hydraulic brake cylinder leaking hydraulic fluid |3.6.A.1| | 1 |
| Fuel hose leaking ENGINE BAY HOSE (6.1.3 (b) (i)) | 1 |
| Offside Front Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Headlamp insecure |1.7.3| | 1 |
| Offside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Stop lamp excessively deteriorated so that it is not visible from a reasonable distance |1.2.1d| | 1 |
| Offside Stop lamp excessively deteriorated so that it is not visible from a reasonable distance |1.2.1d| | 1 |
| Position lamp not working All (4.2.1 (a) (ii)) | 1 |
| Position lamp switch does not operate in accordance with the requirements No lamps illuminate (4.2.2 (a)) | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Dipswitch does not operate immediately when selected on dipped beam (4.1.3 (b)) | 1 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 1 |
| Exhaust emissions - engine idle speed too high (8.2.1.2 (e)) | 1 |
| Offside Rear Brake hose connection leaking on an air braking system On suspension arm (1.1.12 (c) (i)) | 1 |
| Offside Seat belt anchorage prescribed area strength or continuity significantly reduced sill (7.1.1 (a) (i)) | 1 |
| Nearside Front Upper Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Horn not working |1.6.2a| | 1 |
| Nearside Front Upper Suspension component ball joint likely to become detached (5.3.4 (a) (ii)) | 1 |
| Fuel pipe leaking at rear (6.1.3 (b) (i)) | 1 |
| Offside Front Lower Suspension arm corroded and seriously weakened |2.4.G.1| | 1 |