| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 43 |
| Brake pipe excessively corroded | 17 |
| Registration plate lamp issues | 14 |
| Rear parking brake recording little or no effort | 12 |
| Windscreen wiper does not clear the windscreen effectively | 10 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 10 |
| Parking brake: efficiency below requirements |3.7.B.7| | 8 |
| Rear brake binding | 8 |
| Rear brake application uneven | 7 |
| Brakes imbalanced across an axle | 7 |
| Hazard warning switch faulty |1.4.B.1d| | 6 |
| Rear fog lamp tell tale not working |1.3.1b| | 5 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 4 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 4 |
| Nearside Headlamp not working on main beam |1.7.5a| | 4 |
| Offside Headlamp not working on main beam |1.7.5a| | 4 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 4 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 4 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 4 |
| Horn not working |1.6.2a| | 4 |
| Nearside Front Steering rack gaiter split |2.2.D.2d| | 4 |
| Nearside Front Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Offside Front Side repeater not working |1.4.A.2c| | 3 |
| Offside Rear fog lamp not working |1.3.2b| | 3 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 3 |
| Nearside Side repeater not working |1.4.A.2c| | 3 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 3 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
| Nearside Exhaust mounting missing |7.1.1b| | 3 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 3 |
| Brake hose excessively deteriorated | 3 |
| Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 3 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 2 |
| Offside Rear passenger seat cannot be secured in the upright position. |6.2.3| | 2 |
| Nearside Rear passenger seat cannot be secured in the upright position. |6.2.3| | 2 |
| Driver`s seat insecure |6.2.A.1| | 2 |
| Fuel cap/sealing device sealing washer deteriorated |7.2.4c| | 2 |
| Offside Front Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Direction indicators not working |1.4.A.2c| | 2 |
| Offside Steering rack gaiter split |2.2.D.2d| | 2 |
| Registration plate issues | 2 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Exhaust system not adequately supported |7.1.1| | 2 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
| Offside Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 2 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 2 |
| Headlamp aim not tested |1.8.A.1c| | 2 |
| Parking brake lever has no reserve travel |3.1.6b| | 2 |
| Rear Fuel pipe leaking |7.2.3| | 2 |
| Battery insecure |1.9.1| | 2 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Offside Side repeater not working |1.4.A.2c| | 2 |
| Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 2 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Brake pedal creeps down when held under pressure |3.3.B.1a| | 2 |
| Nearside Rear Shock absorbers has a serious fluid leak | 2 |
| Windscreen washer not working | 2 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 2 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 2 |
| Offside Front Drag link end ball joint has excessive play |2.2.B.1f| | 2 |
| Offside Hazard warning tell tale not working correctly |1.4.B.1e| | 2 |
| Offside Front Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 2 |
| Horn not working |7.7 |a| |ii|| | 2 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 1 |
| Nearside Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Brake pipe leaking |3.6.A.1| | 1 |
| Nearside Front passenger door does not latch securely closed |6.2.B.1a| | 1 |
| Headlamp switch faulty |1.7.1| | 1 |
| Rear Fuel hose leaking |7.2.3| | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Power steering component|s| leaking |2.3.3b| | 1 |
| Brake pedal anti-slip provision incomplete |3.3.A.1b| | 1 |
| Nearside Rear Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Offside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 1 |
| Nearside Rear Braking system leaking |3.6.A.1| | 1 |
| Offside Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Front Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Offside Front brake caliper leaking |3.6.A.1| | 1 |
| Rear passenger seat cannot be secured in the upright position. |6.2.3| | 1 |
| Offside Headlamp aim beam image too far to the right |1.6.B4| | 1 |
| Nearside Front Exhaust mounting missing |7.1.1b| | 1 |
| Offside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Emissions unable to be completed (8.2.1.2 (d)) | 1 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Nearside Front Outer Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Rear Rear fog lamp tell-tale not working (4.9.1 (a) (ii)) | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Nearside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Offside Rear Service brake lagging in operation (1.2.1 (d)) | 1 |
| Nearside Rear Brake cable has restricted free movement |3.5.1k| | 1 |
| Nearside rear brake grabbing severely |3.7.A.5b| | 1 |
| Offside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
| Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Seat belt affected by an insecure seat fixing |5.2.1b| | 1 |
| Offside Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Side repeater not working |1.4.A.2c| | 1 |
| Steering system excessively tight |2.2.D.1| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Offside Front Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
| Offside Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Nearside Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Front Upper Shock absorber has an excessively worn shock absorber pivot |2.7.4| | 1 |
| Nearside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Offside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Braking system leaking |3.6.A.1| | 1 |
| Nearside Rear Brake hose leaking |3.6.A.1| | 1 |
| Offside Front Steering rack gaiter missing or no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Nearside Rear Trailing arm attachment bracket/mounting corroded and its strength is seriously reduced |2.4.G.1| | 1 |
| Rear fog lamp tell-tale missing (4.9.1 (a) (ii)) | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Headlamp light intensity severely reduced Both Headlights |4.1.4 |a|| | 1 |
| Offside Front Inner Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Nearside Rear Anti-roll bar attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Front Brake pedal spongy |3.3.B.1b| | 1 |
| Front Horn not working |1.6.2a| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Rear Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 1 |
| Nearside Front Anti-roll bar linkage fractured |2.4.G.1| | 1 |
| Offside Front Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Front Brake pipe fouled by moving parts |3.6.B.2a| | 1 |
| Bonnet retaining device ineffective |8.4.2| | 1 |
| Direction indicator excessively damaged so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
| Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Lower Suspension component pin or bush excessively worn radius arm bush (5.3.4 (a) (i)) | 1 |
| Offside Rear Lower Suspension component pin or bush excessively worn radius arm bush (5.3.4 (a) (i)) | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Nearside Front Suspension arm cracked |2.4.G.1| | 1 |
| Nearside Front Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Front Inner Steering pivot point has excessive play Rack end play |2.2.B.1g| | 1 |
| Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Fuel pipe leaking |7.2.3| | 1 |
| Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Centre Rear Exhaust mounting missing |7.1.1b| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front brake disc excessively scored |3.5.1h| | 1 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 1 |
| Rear Exhaust mounting missing |7.1.1b| | 1 |
| Nearside Front Brake back plate|s| securing device excessively deteriorated |3.5.1j| | 1 |
| Offside Front Brake back plate|s| securing device excessively deteriorated |3.5.1j| | 1 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
| Nearside Front Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Hazard warning tell tale not working correctly |1.4.B.1e| | 1 |
| Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Bonnet cannot be secured in the closed position |8.4.1| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Emissions not tested |7.3.A.1| | 1 |
| Offside Front Driver`s seat insecure |6.2.A.1| | 1 |
| Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Lower Seat belt attachment fitting badly deteriorated corroded through |5.2.3| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Headlamp adversely affected by the operation of another lamp |1.7.5c| | 1 |
| Power steering pipe|s| or hose|s| leaking |2.3.3b| | 1 |
| Fuel hose leaking |7.2.3| | 1 |
| Nearside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement D-bush |2.4.G.2| | 1 |
| Exhaust carbon monoxide content at idle exceeds default limits |8.2.1.2 |b|| | 1 |
| Hazard warning switch inoperative |4.4.2 |a| |ii|| | 1 |
| Offside Front Wheel bearing has excessive play |5.1.3 |a| |i|| | 1 |
| Offside Front Inner Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Offside Rear coil spring fractured |2.4.C.1a| | 1 |
| Front Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
| Nearside Front Anti-roll bar linkage attachment bracket/mounting likely to fail |5.3.3 |b| |ii|| | 1 |
| Offside Front Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Front Upper Suspension component ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Offside Front Upper Suspension component ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Upper Steering column has excessive movement up and down bush |2.2.2 |a|| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |