| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 23 |
| Parking brake lever has no reserve travel |3.1.6b| | 10 |
| Windscreen wiper does not clear the windscreen effectively | 10 |
| Battery insecure |1.9.1| | 5 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 5 |
| Rear fog lamp not working |1.3.2b| | 3 |
| Rear fog lamp tell tale not working |1.3.1b| | 3 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Rear Stop lamp not working |1.2.1b| | 2 |
| Brake hose has insufficient room to move | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Front brake excessively fluctuating | 2 |
| Registration plate issues | 2 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 2 |
| Registration plate lamp issues | 2 |
| Battery insecure and likely to cause a short circuit |4.13 |a| |ii|| | 2 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Rear brake excessively fluctuating | 2 |
| Front brake application uneven | 2 |
| Brakes imbalanced across an axle | 2 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 2 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 2 |
| Nearside Rear brake caliper leaking |3.6.A.1| | 1 |
| Offside Rear Fuel system component leaking leakage from filter |7.2.3| | 1 |
| Offside Front Macpherson strut has excessive movement at the upper attachment |2.5.A.1c| | 1 |
| Fuel cap/sealing device sealing washer torn |7.2.4c| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Anti-lock braking system warning lamp indicates an ABS fault | 1 |
| Nearside Front Macpherson strut has excessive movement in the upper support bearing assembly |2.5.B.1b| | 1 |
| Nearside Front Macpherson strut damaged and seriously weakened |2.4.G.1| | 1 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
| Nearside Body component damaged and likely to cause injury mirror housing |6.2.1 |a| |i|| | 1 |
| Rear Passenger`s seat insecure seat base |6.2.6 |a| |ii|| | 1 |
| Central Rear Seat belt retracting mechanism defective |7.1.2 |e|| | 1 |
| Offside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
| Offside Rear Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Rear brake disc in such a condition that it is seriously weakened | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Centre Rear Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Front Upper Macpherson strut pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Rear Braking system leaking |3.6.A.1| | 1 |
| Headlamp light source and lamp not compatible o s and n s |4.1.4 |c|| | 1 |
| Offside Side repeater not working |4.4.1 |a| |ii|| | 1 |
| Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Hazard warning switch inoperative |4.4.2 |a| |ii|| | 1 |
| Nearside Front Wheel bearing has excessive play |5.1.3 |a| |i|| | 1 |
| Nearside Front Shock absorbers has a serious fluid leak | 1 |
| Brake lever has abnormal movement of levers indicating excessive wear or maladjustment |1.1.15 |f|| | 1 |
| Nearside rear brake excessively fluctuating |3.7.B.3| | 1 |
| Offside rear brake excessively fluctuating |3.7.B.3| | 1 |
| Fuel system component leaking fuel filter |7.2.3| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Fuel tank leaking filler pipe also? |7.2.3| | 1 |
| Fuel system component leaking filter |7.2.3| | 1 |
| Rear fog lamp switch faulty |1.3.1a| | 1 |
| Exhaust system not adequately supported existing ones also perished |7.1.1| | 1 |
| Fuel tank leaking |7.2.3| | 1 |
| Offside Headlamp not working on main beam |4.1.1 |a| |ii|| | 1 |
| Offside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 1 |
| Horn not working |1.6.2a| | 1 |
| Rear Direction indicator incorrect colour both |1.4.A.2f| | 1 |
| Exhaust system not adequately supported rubber mounts gone |7.1.1| | 1 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| Rear fog lamp switch missing (4.5.3 (a) (ii)) | 1 |
| Nearside Front Shock absorbers insecurely attached central retaining ring nut (5.3.2 (a) (i)) | 1 |
| Offside Front Road wheel fixing missing (5.2.1 (a) (i)) | 1 |
| Nearside Front Macpherson strut fractured (5.3.3 (b) (ii)) | 1 |
| Nearside Rear Hydraulic brake cylinder leaking hydraulic fluid (1.1.16 (b) (i)) | 1 |
| Rear Exhaust system insecure mount broken (6.1.2 (a)) | 1 |
| Front Exhaust silencer insecure clamp loose (8.1.1 (b) (i)) | 1 |
| Offside Front Shock absorbers insecurely attached bottom bolt loose (5.3.2 (a) (i)) | 1 |
| Offside Rear Parking (secondary brake) on a single line braking system has inadequate effort at a wheel (1.3.1 (a) (i)) | 1 |
| Brake lever has insufficient reserve travel (1.1.2 (a)) | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Hazard warning switch inoperative (4.4.2 (a) (ii)) | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Front Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
| Offside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Battery insecure and likely to cause a short circuit (4.13 (a) (ii)) | 1 |
| Offside Front Upper Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt and lower (5.3.4 (b) (ii)) | 1 |
| Nearside Front Upper Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt and lower (5.3.4 (b) (ii)) | 1 |
| Nearside Rear Parking (secondary brake) on a single line braking system has inadequate effort at a wheel (1.3.1 (a) (i)) | 1 |
| Nearside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced outer sill (7.1.1 (a) (i)) | 1 |
| Offside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced outer sill (7.1.1 (a) (i)) | 1 |
| Nearside Front Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Macpherson strut mounting fractured Strut separated from mounting. (5.3.3 (b) (ii)) | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment Goes to the stop without locking out. (1.1.6 (c)) | 1 |
| Front Power steering pipe/hose leaking PAS cooling pipe in front of AC condenser (2.1.5 (a)) | 1 |
| Rear Exhaust system insecure Both rubber mounts broken (6.1.2 (a)) | 1 |
| Nearside Rear Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Offside Rear Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Central Rear Lower Exhaust shield missing where fitted as original equipment creating a risk of fire loose (6.1.3 (e)) | 1 |
| Central Rear Lower Rear fog lamp lens defective such that emitted light is adversely affected (4.5.1 (b) (ii)) | 1 |
| Offside Front Upper Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 1 |
| Offside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced Sill (6.1.1 (c) (i)) | 1 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Fuel pipe leaking Fuel pipe to tank (6.1.3 (b) (i)) | 1 |
| Offside Front Suspension arm pin or bush excessively worn front bush (5.3.4 (a) (i)) | 1 |
| Nearside Front Suspension arm pin or bush excessively worn front bush (5.3.4 (a) (i)) | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |