| Most common failures | No# failures |
|---|
| Parking brake: efficiency below requirements |3.7.B.7| | 86 |
| Headlamp aim out of alignment | 60 |
| Rear parking brake recording little or no effort | 53 |
| Windscreen wiper does not clear the windscreen effectively | 45 |
| Horn not working |1.6.2a| | 32 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 31 |
| Offside Steering rack gaiter split |2.2.D.2d| | 29 |
| Parking brake lever has no reserve travel |3.1.6b| | 29 |
| Registration plate lamp issues | 28 |
| Service brake: efficiency below requirements |3.7.B.7| | 25 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 24 |
| Brake pipe excessively corroded | 18 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 17 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 15 |
| Nearside Front Steering rack gaiter split |2.2.D.2d| | 14 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 14 |
| Offside Stop lamp not working |1.2.1b| | 13 |
| Offside Rear fog lamp not working |1.3.2b| | 12 |
| Nearside Stop lamp not working |1.2.1b| | 12 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 11 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 10 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 9 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 9 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 8 |
| Anti-lock braking system warning lamp indicates an ABS fault | 8 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 8 |
| Brakes imbalanced across an axle | 8 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 7 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 5 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 5 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 5 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 5 |
| Nearside Steering rack insecure |2.2.B.1a| | 5 |
| Rear fog lamp not working |1.3.2b| | 4 |
| Hazard warning switch faulty |1.4.B.1d| | 4 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 4 |
| Registration plate issues | 4 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 4 |
| Rear brake application uneven | 4 |
| Exhaust tailpipe not capable of allowing the emission probe to be inserted |7.3.D.1| | 3 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 3 |
| Nearside Front Steering component mounting prescribed area is fractured |2.2.C.1h| | 3 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 3 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 3 |
| Horn not working (7.7 (a)) | 3 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 3 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 3 |
| Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 3 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
| Offside front brake binding |3.7.B.1| | 3 |
| Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 3 |
| Exhaust engine idle speed too high |7.3.D.1| | 3 |
| Rear Exhaust system not adequately supported |7.1.1| | 3 |
| Rear Mechanical brake component has restricted free movement | 3 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Nearside Rear wheel bearing rough when rotated |2.6.1| | 2 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 2 |
| Emissions not tested |7.0| | 2 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Exhaust catalytic converter missing where one was fitted as standard |7.1.3| | 2 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 2 |
| Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
| Offside Rear brake caliper has restricted free movement |3.5.1k| | 2 |
| Parking brake: efficiency below requirements |3.7.D.4| | 2 |
| Front brake application uneven | 2 |
| Rear brake binding | 2 |
| Exhaust noise is clearly in excess of that emitted by a similar vehicle fitted with a standard silencer in average condition |7.1.4| | 2 |
| Offside Rear Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
| Nearside front brake binding |3.7.B.1| | 2 |
| Brake fluid warning lamp illuminated |3.6.G.2| | 2 |
| Battery insecure |1.9.1| | 2 |
| Nearside Rear brake caliper has restricted free movement |3.5.1k| | 2 |
| Windscreen wiper blade insecure | 2 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 2 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 2 |
| Front brake excessively fluctuating | 2 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 2 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 2 |
| Windscreen has damage | 1 |
| Nearside Front Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Ball joint has excessive play |2.2.B.1f| | 1 |
| Front Vehicle structure has an inadequate repair which adversely affects braking or steering |6.1.A.1| | 1 |
| Tie bar/rod attachment bracket/mounting rivet missing |2.4.G.1| | 1 |
| Centre Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Front Direction indicator incomplete |1.5.A1b| | 1 |
| Front Power steering pipe|s| or hose|s| leaking |2.3.3b| | 1 |
| Nearside Headlamp insecure |1.7.3| | 1 |
| Nearside Headlamp aim not tested |1.8.A.1c| | 1 |
| Anti-lock braking system warning lamp does not illuminate |3.4.1b| | 1 |
| Offside Rear brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Rear Radius arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Radius arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Exhaust has a part missing |7.1.1a| | 1 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Rear Anti-roll bar linkage fractured |2.4.G.1| | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Steering rack has excessive free play detected at the steering wheel (steering rack fitted) steering rack bush x2 worn (2.3 (a) (i)) | 1 |
| Offside Front Steering rack has excessive free play detected at the steering wheel (steering rack fitted) (2.3 (a) (i)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Fuel system component leaking |7.2.3| | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sill/ inner wheel arch (5.3.6 (a) (i)) | 1 |
| Rear Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Offside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
| Brake pedal anti-slip provision worn smooth |3.3.A.1b| | 1 |
| Hazard warning lamps inoperative |1.4.B.1b| | 1 |
| Offside Inner Front constant velocity joint is excessively worn |2.5.C.1b| | 1 |
| Nearside Rear Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
| Rear Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Position lamp not working both front (4.2.1 (a) (ii)) | 1 |
| Position lamp not working both rear (4.2.1 (a) (ii)) | 1 |
| All direction indicators not working (4.4.1 (a) (ii)) | 1 |
| Hazard warning lamps inoperative (4.4.1 (e)) | 1 |
| Headlamp not working on dipped beam both front (4.1.1 (a) (ii)) | 1 |
| Headlamp not working on main beam both (4.1.1 (a) (ii)) | 1 |
| Offside Front Suspension arm pin or bush excessively worn front bush (5.3.4 (a) (i)) | 1 |
| Brake pedal anti-slip provision missing (1.1.2 (c)) | 1 |
| Parking brake inoperative on one side offside low (1.4.1 (a)) | 1 |
| Exhaust carbon monoxide content at idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Exhaust catalytic converter missing where one was fitted as standard (8.2.1.1 (a)) | 1 |
| Nearside Inner Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Exhaust emits excessive dense blue smoke during acceleration |7.3.A.2c| | 1 |
| Nearside Front Steering rack insecure |2.2.B.1a| | 1 |
| Nearside Rear Shock absorbers has a serious fluid leak | 1 |
| Offside Rear Shock absorbers has a serious fluid leak | 1 |
| Nearside Front Shock absorbers has a serious fluid leak | 1 |
| Nearside Front Wheel bearing play so excessive that directional control is impaired (5.1.3 (a) (ii)) | 1 |
| Offside Rear Road wheel badly distorted (5.2.2 (c) (i)) | 1 |
| Nearside Front Direction indicator likely to become detached (4.4.1 (c) (ii)) | 1 |
| Nearside Side repeater incorrect colour |1.4.A.2f| | 1 |
| Offside Side repeater incorrect colour |1.4.A.2f| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Offside Rear Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Rear Upper Coil spring mounting corroded and seriously weakened (5.3.1 (b) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Floorpan (5.3.6 (a) (i)) | 1 |
| Offside Front Outer Seat belt anchorage prescribed area strength or continuity significantly reduced Sill (7.1.1 (a) (i)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Floorpan (5.3.6 (a) (i)) | 1 |
| Nearside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Arch (5.3.6 (a) (i)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Under arch (5.3.6 (a) (i)) | 1 |
| Front Suspension component mounting prescribed area is excessively corroded cross member |2.4.A.3| | 1 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded floor |5.2.6| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| rear parking |secondary| brakes imbalanced | 1 |
| Nearside Front Direction indicator flashing less than 60 times a minute |1.4.A.2g| | 1 |
| Nearside Rear Direction indicator flashing less than 60 times a minute |1.4.A.2g| | 1 |
| Rear fog lamp switch faulty |1.3.1a| | 1 |
| Front Anti-roll bar linkage has excessive play in a pin/bush both |2.4.G.2| | 1 |
| Offside Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits |8.2.1.2 |c|| | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment |1.1.6 |c|| | 1 |
| Horn not working |7.7 |a| |ii|| | 1 |
| Offside Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Nearside Rear position lamp|s| has a product on the light source so it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Rear position lamp|s| has a product on the lens so it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Stop lamp has less than 50% of the light sources illuminating |1.2.1b| | 1 |
| Driver`s seat insecure |6.2.A.1| | 1 |
| Front Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Rear Stop lamp not working |1.2.1b| | 1 |
| Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Nearside Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Rear fog lamp obviously incorrectly positioned |1.3.2a| | 1 |
| Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
| Nearside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Nearside Rear Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
| Nearside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Nearside Front Anti-roll bar linkage fractured |2.4.G.1| | 1 |
| Nearside Front Power steering component|s| leaking steering rack |2.3.3b| | 1 |
| Offside Front Upper Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Offside Rear Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced inner sill corroded (6.1.1 (c) (i)) | 1 |
| Offside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced Floor (6.1.1 (c) (i)) | 1 |
| Offside Steering rack gaiter missing or no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Offside Front Shock absorbers has a serious fluid leak | 1 |
| Offside Rear Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sill and floor (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sill (5.3.6 (a) (i)) | 1 |
| Nearside Front Seat belt anchorage prescribed area strength or continuity significantly reduced floor (7.1.1 (a) (i)) | 1 |
| Offside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced inner arch (6.1.1 (c) (i)) | 1 |
| Nearside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced inner arch (6.1.1 (c) (i)) | 1 |
| Nearside Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Nearside Steering component mounting prescribed area is fractured |2.2.C.1h| | 1 |
| Offside Rear Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings inner sill |6.1.B.2| | 1 |
| Offside Front coil spring corroded so that its cross sectional area is reduced and seriously weakened |2.4.C.1b| | 1 |
| Offside Rear Anti-roll bar linkage fractured |5.3.3 |b| |ii|| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Anti-roll bar missing |2.4.G.1| | 1 |
| Parking brake lever ratchet mechanism is excessively worn |3.1.5| | 1 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Inner Headlamp insecure |1.7.3| | 1 |
| Nearside Rear passenger seat cannot be secured in the upright position. |6.2.3| | 1 |
| Offside Rear passenger seat cannot be secured in the upright position. |6.2.3| | 1 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Front Track rod end loose |2.2.B.1d| | 1 |
| Rear brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Front Headlamps matched pair are not the same colour |1.7.6| | 1 |
| Nearside Rear Road wheel badly damaged |4.2.A.1a| | 1 |
| Offside Inner Rear Tie bar/rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Inner Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Inner Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Rear Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Passenger`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Nearside Front Steering retaining device insecure |2.2.C.1g| | 1 |
| Nearside Inner Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Inner Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Steering component is not secure to the vehicle structure |2.2.B.1a| | 1 |
| Nearside Power steering component|s| leaking from a failed seal |2.3.3b| | 1 |
| Rear brake disc in such a condition that it is seriously weakened | 1 |
| Nearside Rear Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Offside Obligatory mirror insecure |8.1.1| | 1 |
| Rear position lamp|s| incomplete |1.1.4a| | 1 |
| Stop lamp not working |1.2.1b| | 1 |
| Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Steering wheel retaining device insecure |2.1.6| | 1 |
| Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Nearside Front Direction indicators not working |1.4.A.2c| | 1 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 1 |
| Offside Front Obligatory mirror missing (3.3 (a)) | 1 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 1 |
| Exhaust has a major leak of exhaust gases backbox join to centre pipe (6.1.2 (a)) | 1 |
| Nearside Front Inner Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced arch (6.1.1 (c) (i)) | 1 |
| Offside Front Subframe mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Brake pedal anti-slip provision incomplete |3.3.A.1b| | 1 |
| Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings Front crossmember/front engine mount prescribed area. |6.1.B.2| | 1 |
| Offside Front Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Electronic stability system warning lamp indicates a fault |3.4.1c| | 1 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Centre Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Rear Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Ball joint has excessive play |2.2.B.1f| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Nearside Front Direction indicators missing |1.4.A.2b| | 1 |
| Offside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Brake actuating linkage mounting prescribed area is excessively corroded |3.3.A.2| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Nearside Anti-roll bar linkage fractured |2.4.G.1| | 1 |
| Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Offside Rear Anti-roll bar linkage insecurely attached (5.3.3 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill........ (5.3.6 (a) (i)) | 1 |