Most common failures | No# failures |
---|
Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 86 |
Headlamp aim out of alignment | 72 |
Windscreen wiper does not clear the windscreen effectively | 28 |
Registration plate lamp issues | 25 |
Brake hose excessively deteriorated | 16 |
Offside Rear fog lamp not working |1.3.2b| | 14 |
Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 14 |
Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 12 |
Registration plate issues | 10 |
Brakes imbalanced across an axle | 10 |
Parking brake: efficiency below requirements |3.7.B.7| | 9 |
Rear fog lamp not working |1.3.2b| | 8 |
Brake pipe excessively corroded | 8 |
Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 7 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 7 |
Offside Rear Rear fog lamp not working |1.3.2b| | 7 |
Anti-lock braking system warning lamp indicates an ABS fault | 7 |
Exhaust Lambda reading after 2nd fast idle outside specified limits |8.2.1.2 |c|| | 6 |
Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 6 |
Parking brake lever has no reserve travel |3.1.6b| | 5 |
Horn not working |1.6.2a| | 5 |
Rear fog lamp tell tale not working |1.3.1b| | 5 |
Nearside Rear position lamp|s| not working |1.1.A.3b| | 5 |
Offside Stop lamp not working |1.2.1b| | 4 |
Offside Front Brake hose bulging under pressure |3.6.B.3| | 4 |
Nearside Stop lamp not working |1.2.1b| | 4 |
Nearside Steering rack gaiter split |2.2.D.2d| | 4 |
Offside Steering rack gaiter split |2.2.D.2d| | 4 |
Nearside Front Brake hose bulging under pressure |3.6.B.3| | 3 |
Rear brake disc in such a condition that it is seriously weakened | 3 |
Nearside Headlamp aim beam image kick up to the offside |1.8| | 3 |
Offside Headlamp aim beam image kick up to the offside |1.8| | 3 |
Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 3 |
Offside Rear Stop lamp not working |1.2.1b| | 3 |
Parking brake efficiency below requirements |1.4.2 |a| |i|| | 3 |
Service brake: efficiency below requirements |3.7.B.7| | 3 |
Rear brake binding | 3 |
Nearside Rear Stop lamp not working |1.2.1b| | 3 |
Offside Front Steering rack gaiter split |2.2.D.2d| | 3 |
Nearside Side repeater not working |1.4.A.2c| | 2 |
Horn not working (7.7 (a) (ii)) | 2 |
Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 2 |
Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 2 |
Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 2 |
Nearside Front Brake hose leaking |3.6.A.1| | 2 |
Rear fog lamp not working |4.5.1 |a| |ii|| | 2 |
Nearside Outer Rear position lamp|s| not working |1.1.A.3b| | 2 |
Main beam `tell-tale` not working |1.7.4c| | 2 |
Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
Nearside Headlamp insecure |1.7.3| | 2 |
Parking brake efficiency below requirements (1.4.2 (a) (i)) | 2 |
Front Headlamp not working on dipped beam |1.7.5a| | 2 |
Offside Rear position lamp|s| not working |1.1.A.3b| | 2 |
Stop lamp not working |1.2.1b| | 2 |
Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 2 |
Offside Headlamp insecure |1.7.3| | 2 |
Nearside Headlamp not working on main beam |1.7.5a| | 2 |
Rear parking brake recording little or no effort | 2 |
Offside Front position lamp|s| insecure |1.1.A.3a| | 2 |
Nearside Front Headlamp insecure |1.7.3| | 2 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
Offside Front Headlamp insecure |1.7.3| | 2 |
Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 2 |
Exhaust carbon monoxide content at idle exceeds default limits (8.2.1.2 (b)) | 2 |
Rear Exhaust system not adequately supported |7.1.1| | 1 |
Rear fog lamp does not emit a steady red light (4.5.4 (a)) | 1 |
Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
Nearside Headlamp insecure (4.1.1 (c)) | 1 |
Exhaust mounting missing |7.1.1b| | 1 |
Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
Nearside Front Side repeater not working |4.4.1 |a| |ii|| | 1 |
Rear fog lamp switch faulty |1.3.1a| | 1 |
Nearside Front Upper Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Front Upper Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Nearside Front Braking system leaking |3.6.A.1| | 1 |
Offside Track rod end loose |2.2.B.1d| | 1 |
Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
Nearside Rear Macpherson strut corroded and seriously weakened |2.4.G.1| | 1 |
Headlamp switch faulty |1.7.1| | 1 |
Offside Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength shell just in front of suspension arm mount |5.3.6 |a| |i|| | 1 |
Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Front Bonded suspension unit deteriorated and cannot function as intended |2.4.F.3| | 1 |
Centre Exhaust system not adequately supported |7.1.1| | 1 |
Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Rear Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.A.3| | 1 |
Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
Windscreen washer not working | 1 |
Nearside Front coil spring fractured |2.4.C.1a| | 1 |
Rear Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
Power steering ram|s| leaking from a failed component |2.3.3b| | 1 |
Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
Nearside Rear Brake pipe leaking |3.6.A.1| | 1 |
Nearside Inner Rear position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Outer Stop lamp not working |1.2.1b| | 1 |
Offside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Offside Stop lamp|s| adversely affected by the operation of another lamp |4.3.3 |b|| | 1 |
Offside Rear Position lamp adversely affected by the operation of another lamp |4.2.3 |c|| | 1 |
Front Windscreen wiper not working |3.4 |a|| | 1 |
Exhaust carbon monoxide content after 2nd fast idle exceeds default limits |8.2.1.2 |b|| | 1 |
Exhaust carbon monoxide content at idle exceeds default limits |8.2.1.2 |b|| | 1 |
Bonnet cannot be secured in the closed position |8.4.1| | 1 |
Power steering pipe|s| or hose|s| leaking from a joint |2.3.3b| | 1 |
Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Offside Front coil spring fractured |2.4.C.1a| | 1 |
Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Front Braking system leaking joint from metal to flexi pipe |3.6.A.1| | 1 |
Brake pedal creeps down when held under pressure |3.3.B.1a| | 1 |
Brake reservoir fluid level decreases after several pedal applications |3.3.C.1| | 1 |
Parking brake efficiency below requirements o/s and n/s (1.4.2 (a) (i)) | 1 |
Offside Front Brake back plate|s| locking device insecure |3.5.1l| | 1 |
Nearside Position lamp has a product on the lens or light source which shows white light to the rear |4.2.3 |b| |ii|| | 1 |
Steering rack has excessive free play detected at the steering wheel |steering rack fitted| o/s and n/s |2.3 |a| |i|| | 1 |
Front Brake disc significantly and obviously worn |1.1.14 |a| |i|| | 1 |
Nearside Rear Direction indicator not working |4.4.1 |a| |ii|| | 1 |
Brake pedal not releasing correctly and functionality of brakes affected feedback through pedal |1.1.2 |b| |ii|| | 1 |
Front Headlamp not working on main beam |1.7.5a| | 1 |
Offside Rear Inner Position lamp not working |4.2.1 |a| |ii|| | 1 |
Nearside Rear Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
Oil leaking excessively from engine |8.4.1 |a| |i|| | 1 |
Oil leaking excessively from transmission |8.4.1 |a| |i|| | 1 |
Ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Rear Brake hose bulging under pressure |3.6.B.3| | 1 |
Nearside Front Hydraulic brake calliper damaged inner to outer pipe unions (1.1.16 (a) (i)) | 1 |
Offside Front Hydraulic brake calliper excessively weakened by corrosion inner to outer pipe unions (1.1.16 (d) (i)) | 1 |
Nearside Rear Hydraulic brake calliper excessively weakened by corrosion inner to outer pipe unions (1.1.16 (d) (i)) | 1 |
Offside Rear Hydraulic brake calliper excessively weakened by corrosion inner to outer pipe unions (1.1.16 (d) (i)) | 1 |
Steering column top bearing excessively worn |2.1.2c| | 1 |
Offside Rear coil spring cracked |2.4.C.1a| | 1 |
Nearside Front Steering system has a road wheel fouling a part of the vehicle |2.2.D.2a| | 1 |
Nearside Front Lower Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Nearside Front Brake pipe leaking |3.6.A.1| | 1 |
Nearside Front Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Offside Front Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
Nearside Rear Brake pipe connection leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
Offside Rear Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
Nearside Rear Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
Nearside Rear Outer Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting sill (6.2.2 (d) (i)) | 1 |
Offside Rear Outer Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting sill (6.2.2 (d) (i)) | 1 |
Boot lid cannot be secured in the closed position (6.2.1 (e)) | 1 |
Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Offside Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
Offside Rear Fuel pipe insecure |7.2.1| | 1 |
Nearside Rear Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Front Steering rack damaged and unserviceable |2.2.C.1d| | 1 |
Windscreen wiper not working |3.4 |a|| | 1 |
Nearside Front Passenger`s seat insecure |6.2.6 |a| |ii|| | 1 |
Emissions not tested |7.0| | 1 |
Nearside Rear Brake back plate|s| securing device missing |3.5.1j| | 1 |
Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
Nearside Inner Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
Nearside Front suspension has excessive play in a pin or bush of an upper wishbone inner bearing |2.5.B.1a| | 1 |
Offside Front suspension has excessive play in a pin or bush of an upper wishbone inner bearing |2.5.B.1a| | 1 |
Nearside Front Front position lamp|s| does not face the front |1.1.A.3a| | 1 |
Offside Front Front position lamp|s| does not face the front |1.1.A.3a| | 1 |
Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
Offside Rear position lamp|s| incomplete |1.1.4a| | 1 |
Front Steering rack gaiter split |2.2.D.2d| | 1 |
Nearside Rear Shock absorber has negligible damping effect |2.7.5| | 1 |
Offside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Obligatory mirror insecure |8.1.1| | 1 |
Offside Obligatory mirror does not provide a view to the rear |8.1.2b| | 1 |
Front Headlamp aim beam image kick up to the offside |1.8| | 1 |
Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
Nearside Front position lamp|s| insecure |1.1.A.3a| | 1 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
Offside Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
Nearside Front Upper Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Front Upper Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Front Anti-roll bar attachment bracket/mounting cracked |2.4.G.1| | 1 |
Offside Front Obligatory mirror does not provide a view to the rear |8.1.2b| | 1 |
Nearside Front coil spring incomplete |2.4.C.1a| | 1 |
Offside Front coil spring incomplete |2.4.C.1a| | 1 |
Offside Rear Boot lid component likely to become detached spoiler not attached |6.2.1 |a| |ii|| | 1 |
Nearside Front Anti-roll bar linkage pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
Offside Front Anti-roll bar linkage pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
Nearside Rear Drive shaft which forms part of the suspension coupling gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.4.G.4e| | 1 |
Offside Rear Drive shaft which forms part of the suspension coupling gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.4.G.4e| | 1 |
Nearside Rear fog lamp not working |1.3.2b| | 1 |
Nearside Front Steering rack gaiter split |2.2.D.2d| | 1 |
Exhaust emissions Lambda reading after 2nd fast idle outside specified limits 1.26. |7.3.D.3| | 1 |
Exhaust hydrocarbon content after 2nd fast idle exceeds default limits |8.2.1.2 |b|| | 1 |
Horn not working |7.7 |a| |ii|| | 1 |
Steering rack insecure |2.2.B.1a| | 1 |
Steering rack damaged and unserviceable |2.2.C.1d| | 1 |
Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
Power steering inoperative |2.3.3a| | 1 |
Nearside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Offside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Nearside Front Steering rack gaiter insecure |2.2.D.2d| | 1 |
Nearside Front Power steering pipe|s| or hose|s| leaking |2.3.3b| | 1 |
Headlamp aim not tested |1.8.A.1c| | 1 |
Offside Headlamp not working on main beam |1.7.5a| | 1 |
Nearside Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
Offside Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
Windscreen damaged and affecting the driver`s view of the road |3.2 |a| |ii|| | 1 |
Nearside Rear Shock absorbers has a serious fluid leak | 1 |
Offside Obligatory mirror does not provide a view to the rear |3.3 |c|| | 1 |
Parking brake lever has excessive movement indicating incorrect adjustment |1.1.6 |c|| | 1 |
Nearside Brake cable guide defective and affecting operation park brake cable |1.1.15 |d|| | 1 |
Offside Rear Brake cable guide defective and affecting operation park brake cable |1.1.15 |d|| | 1 |
Nearside Rear Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
Nearside Front Power steering pipe|s| or hose|s| leaking from a joint |2.3.3b| | 1 |
Offside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
Nearside Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
Offside Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
Power steering pipe|s| or hose|s| leaking |2.3.3b| | 1 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
Nearside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
Offside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
Nearside Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
Offside Rear Exhaust system not adequately supported |7.1.1| | 1 |
Offside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Offside Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Nearside Front Brake hose connection leaking on a hydraulic braking system caliper banjo bolt |1.1.12 |c| |ii|| | 1 |
Offside Front Brake hose connection leaking on an air braking system caliper banjo bolt |1.1.12 |c| |i|| | 1 |
Brake performance not tested |1.2.1 |g|| | 1 |
Exhaust catalytic converter missing where one was fitted as standard (8.2.1.1 (a)) | 1 |
Offside Front brake disc excessively pitted |3.5.1h| | 1 |
Driver`s airbag obviously defective |5.4.1| | 1 |
Offside Front Direction indicator not working |1.4.A.2c| | 1 |
Driver`s airbag missing |5.4.1| | 1 |
Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
Offside Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
Hazard warning switch faulty |1.4.B.1d| | 1 |
Fuel cap/sealing device sealing washer missing |7.2.4c| | 1 |