| Most common failures | No# failures |
|---|
| Brake pipe excessively corroded | 22 |
| Parking brake: efficiency below requirements |3.7.B.7| | 15 |
| Headlamp aim out of alignment | 15 |
| Registration plate lamp issues | 14 |
| Windscreen wiper does not clear the windscreen effectively | 13 |
| Registration plate issues | 9 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 7 |
| Anti-lock braking system warning lamp indicates an ABS fault | 6 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 5 |
| Brakes imbalanced across an axle | 5 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 5 |
| Service brake: efficiency below requirements |3.7.B.7| | 5 |
| Windscreen has damage | 5 |
| Nearside Stop lamp not working |1.2.1b| | 4 |
| Offside Headlamp not working on main beam |1.7.5a| | 4 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 4 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 3 |
| Battery insecure |1.9.1| | 3 |
| Rear parking brake recording little or no effort | 3 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Nearside Front position lamp|s| incorrect colour |1.1.A.3e| | 3 |
| Offside Front position lamp|s| incorrect colour |1.1.A.3e| | 3 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Horn not working (7.7 (a)) | 2 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 2 |
| Rear brake disc in such a condition that it is seriously weakened | 2 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 2 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 2 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 2 |
| Nearside Rear Direction indicators not working |1.4.A.2c| | 2 |
| Offside Rear brake disc excessively pitted |3.5.1h| | 2 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner wing (5.3.6 (a) (i)) | 2 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 2 |
| Rear brake binding | 2 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 2 |
| Offside Front Direction indicator not working |1.4.A.2c| | 2 |
| Nearside Side repeater missing |1.4.A.2b| | 2 |
| Offside Side repeater missing |1.4.A.2b| | 2 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Nearside Rear brake disc excessively pitted |3.5.1h| | 2 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 2 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 1 |
| Offside Front Side repeater not working |1.4.A.2c| | 1 |
| Nearside Front brake disc excessively scored |3.5.1h| | 1 |
| Offside Front brake disc excessively scored |3.5.1h| | 1 |
| Exhaust noise is clearly in excess of that emitted by a similar vehicle fitted with a standard silencer in average condition |7.1.4| | 1 |
| Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Nearside Rear Brake disc contaminated axle oil |1.1.14 |b|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Rear fog lamp missing |1.3.2a| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Horn not working |1.6.2a| | 1 |
| Obligatory mirror does not provide a view to the rear |8.1.2b| | 1 |
| Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Front Road wheel badly damaged |4.2.A.1a| | 1 |
| Offside Rear Road wheel badly damaged |4.2.A.1a| | 1 |
| Front Hazard warning switch missing |1.4.B.1d| | 1 |
| Battery insecure and likely to fall from carrier |4.13 |a| |ii|| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Nearside Rear Direction indicator likely to become detached (4.4.1 (c) (ii)) | 1 |
| Offside Rear Direction indicator likely to become detached (4.4.1 (c) (ii)) | 1 |
| Offside Rear Suspension arm fractured (5.3.3 (b) (ii)) | 1 |
| Exhaust carbon monoxide content at idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Offside Rear Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Offside Rear Hazard warning lamps inoperative (4.4.1 (e)) | 1 |
| Offside Front Anti-roll bar attachment bracket/mounting fractured inner bracket broken (5.3.3 (b) (ii)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength wheel arch (5.3.6 (a) (i)) | 1 |
| Brake lever has insufficient reserve travel (1.1.2 (a)) | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced inner wheel arch (7.1.1 (a) (i)) | 1 |
| Steering wheel has movement relative to the column indicating looseness (2.2.1 (a) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength floor area (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength floor area (5.3.6 (a) (i)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Offside Front Anti-roll bar fractured broken (5.3.3 (b) (ii)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner wing corroded (5.3.6 (a) (i)) | 1 |
| Nearside Front position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Front position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Nearside Front Seat belt not functioning as intended (7.1.2 (c)) | 1 |
| Offside Front Seat belt not functioning as intended (7.1.2 (c)) | 1 |
| Nearside Rear Seat belt not functioning as intended (7.1.2 (c)) | 1 |
| Offside Rear Seat belt not functioning as intended (7.1.2 (c)) | 1 |
| Rear Fuel pipe leaking (6.1.3 (b) (i)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Rear Service brake has no recorded effort at a wheel (1.2.1 (a) (ii)) | 1 |
| Exhaust noise is clearly in excess of that emitted by a similar vehicle fitted with a standard silencer in average condition (8.1.1 (a)) | 1 |
| Exhaust catalytic converter obviously defective (8.2.1.1 (a)) | 1 |
| Exhaust catalytic converter obviously modified (8.2.1.1 (a)) | 1 |
| Nearside Front Suspension component mounting prescribed area is inadequately repaired (5.3.6 (a) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area is inadequately repaired (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area is inadequately repaired (5.3.6 (a) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sill (5.3.6 (a) (i)) | 1 |
| Power steering pipe/hose leaking (2.1.5 (a)) | 1 |
| Nearside Front Brake hose twisted |3.6.B.4c| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded inner wing |2.4.A.3| | 1 |
| Front brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Side repeater incorrect colour |1.4.A.2f| | 1 |
| Offside Side repeater incorrect colour |1.4.A.2f| | 1 |
| Rear fog lamp switch missing |1.3.1a| | 1 |
| Offside Rear fog lamp missing |1.3.2a| | 1 |
| Nearside Power steering component|s| leaking rack area |2.3.3b| | 1 |
| Driver`s seat insecure |6.2.A.1| | 1 |
| Nearside Front Side repeater incorrect colour |1.4.A.2f| | 1 |
| Offside Front Side repeater incorrect colour |1.4.A.2f| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Exhaust emits excessive dense blue smoke during acceleration |7.3.A.2c| | 1 |
| Centre Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Rear reflector missing |1.5.1a| | 1 |
| Offside Front Direction indicators not working |1.4.A.2c| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Steering rack insecure |2.2.B.1a| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a| |ii|| | 1 |
| Direction indicators not working |1.4.A.2c| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| Offside Side repeater not working |1.4.A.2c| | 1 |
| Offside Front Battery insecure |1.9.1| | 1 |
| Parking brake: efficiency below requirements |3.7.D.4| | 1 |
| Oil leaking excessively from transmission (8.4.1 (a) (i)) | 1 |
| Nearside Rear Anti-roll bar pin or bush excessively worn d bush (5.3.4 (a) (i)) | 1 |
| brake disc excessively pitted |3.5.1h| | 1 |
| front brake juddering severely |3.7.A.2b| | 1 |
| Steering rack has excessive free play detected at the steering wheel (steering rack fitted) (2.3 (a) (i)) | 1 |
| Offside Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Rear Brake relay lever has restricted free movement |3.5.1k| | 1 |
| Offside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Anti-lock braking system warning lamp does not illuminate |3.4.1b| | 1 |
| Front Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Front Brake hose twisted |3.6.B.4c| | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Suspension arm corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Hazard warning switch inoperative (4.4.2 (a) (ii)) | 1 |
| Nearside Rear Inner Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting sill wheel arch (6.2.2 (d) (i)) | 1 |
| Offside Rear Inner Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting wheel arch (6.2.2 (d) (i)) | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Horn not working |7.7 |a| |ii|| | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Front Valve stem seriously damaged |5.2.3 |j|| | 1 |
| Nearside Rear Valve stem seriously damaged |5.2.3 |j|| | 1 |
| Offside Rear Valve stem seriously damaged |5.2.3 |j|| | 1 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 1 |
| Offside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| Power steering pipe|s| or hose|s| leaking |2.3.3b| | 1 |
| Steering column top mounting bracket insecure |2.1.2d| | 1 |
| Steering column top bearing excessively worn |2.1.2c| | 1 |
| Steering rack insecure |2.2.B.1a| | 1 |