| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 28 |
| Registration plate issues | 21 |
| Parking brake: efficiency below requirements |3.7.B.7| | 19 |
| Headlamp aim out of alignment | 17 |
| Brake pipe excessively corroded | 15 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 11 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 10 |
| Registration plate lamp issues | 10 |
| Rear parking brake recording little or no effort | 8 |
| Offside Rear fog lamp not working |1.3.2b| | 8 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 8 |
| Brakes imbalanced across an axle | 8 |
| Hazard warning switch faulty |1.4.B.1d| | 7 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 6 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 6 |
| Battery insecure |1.9.1| | 6 |
| Rear fog lamp tell tale not working |1.3.1b| | 6 |
| Rear fog lamp not working |1.3.2b| | 5 |
| Horn not working |1.6.2a| | 5 |
| Anti-lock braking system warning lamp indicates an ABS fault | 5 |
| Nearside Front Front position lamp|s| incorrect colour |1.1.A.3e| | 4 |
| Offside Front Front position lamp|s| incorrect colour |1.1.A.3e| | 4 |
| Nearside Headlamp not working on main beam |1.7.5a| | 4 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 4 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 4 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 4 |
| Service brake: efficiency below requirements |3.7.B.7| | 4 |
| Nearside Stop lamp not working |1.2.1b| | 3 |
| Offside Stop lamp not working |1.2.1b| | 3 |
| Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 3 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Hazard warning switch inoperative (4.4.2 (a) (ii)) | 3 |
| Rear brake disc excessively pitted |3.5.1h| | 3 |
| Nearside Side repeater missing |1.4.A.2b| | 3 |
| Offside Side repeater missing |1.4.A.2b| | 3 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 3 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 2 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 2 |
| Nearside Front Lower Suspension arm corroded and seriously weakened (5.3.3 (b) (i)) | 2 |
| Offside Front Lower Suspension arm corroded and seriously weakened (5.3.3 (b) (i)) | 2 |
| Steering column top bearing excessively worn |2.1.2c| | 2 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Offside Rear fog lamp missing |1.3.2a| | 2 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 2 |
| Exhaust catalytic converter missing where one was fitted as standard |7.1.3| | 2 |
| Rear Rear fog lamp not working |1.3.2b| | 2 |
| Parking brake lever has no reserve travel |3.1.6b| | 2 |
| Emissions not tested |7.0| | 2 |
| Nearside Rear Trailing arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Nearside Rear Direction indicators incorrect colour |1.4.A.2f| | 2 |
| Offside Rear Direction indicators incorrect colour |1.4.A.2f| | 2 |
| Rear brake disc in such a condition that it is seriously weakened | 2 |
| Rear fog lamp not working |4.5.1 |a| |ii|| | 2 |
| Nearside Front Side repeater missing |1.4.A.2b| | 2 |
| Offside Front Side repeater missing |1.4.A.2b| | 2 |
| Nearside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 2 |
| Rear fog lamp missing |1.3.2a| | 2 |
| Offside Headlamp not working on main beam |1.7.5a| | 2 |
| Nearside Front position lamp|s| incorrect colour |1.1.A.3e| | 2 |
| Offside Front position lamp|s| incorrect colour |1.1.A.3e| | 2 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 2 |
| Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 2 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 2 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Rear Direction indicators incorrect colour |1.4.A.2f| | 2 |
| Nearside Rear brake disc excessively pitted |3.5.1h| | 2 |
| Rear Rear fog lamp missing |1.3.2a| | 2 |
| Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Front position lamp|s| incorrect colour |1.1.A.3e| | 2 |
| Nearside front brake juddering severely |3.7.A.2b| | 2 |
| Offside front brake juddering severely |3.7.A.2b| | 2 |
| Front brake application uneven | 2 |
| Nearside Side repeater not working |1.4.A.2c| | 2 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Hazard warning switch missing |1.4.B.1d| | 2 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Offside Rear wheel bearing has excessive play |2.6.2| | 2 |
| Offside Rear Rear fog lamp missing |1.3.2a| | 2 |
| Windscreen wiper blade insecure | 2 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 2 |
| Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 2 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Nearside Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
| Offside Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
| Boot lid cannot be secured in the closed position (6.2.1 (e)) | 1 |
| Rear fog lamp missing (4.5.1 (a) (ii)) | 1 |
| Exhaust emissions carbon monoxide content excessive 4.7% (8.2.1.2 (b)) | 1 |
| Centre Stop lamp not working |1.2.1b| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Inner Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Inner Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Rear fog lamp switch missing |1.3.1a| | 1 |
| Front Headlamp not working on main beam |1.7.5a| | 1 |
| Front Steering rack damaged and unserviceable |2.2.C.1d| | 1 |
| Nearside Front Exhaust has a major leak of exhaust gases header |7.1.2| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Windscreen washer not working | 1 |
| Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Offside Rear Suspension component mounting prescribed area is inadequately repaired INNER WHEEL ARCH (5.3.6 (a) (i)) | 1 |
| Nearside Front Suspension arm corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Offside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Offside Front Upper Steering rack not properly attached bolt loose (2.1.2 (a) (i)) | 1 |
| Brake lever has abnormal movement of levers indicating excessive wear or maladjustment (1.1.15 (f)) | 1 |
| Service brake efficiency less than 50% of the required value (1.2.2 (a) (ii)) | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Hazard warning lamps inoperative (4.4.1 (e)) | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Upper Suspension arm ball joint likely to become detached (5.3.4 (a) (ii)) | 1 |
| Front brake disc in such a condition that it is seriously weakened | 1 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Nearside Front front brake juddering severely |3.7.A.2b| | 1 |
| Offside Front front brake juddering severely |3.7.A.2b| | 1 |
| Offside Front Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Centre Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement rear |2.4.G.2| | 1 |
| Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement rear |2.4.G.2| | 1 |
| Offside Rear Trailing arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Fuel pipe union leaking on filter |7.2.3| | 1 |
| Emissions not tested due to exh blowing |7.3.A.1| | 1 |
| Offside Front Brake pipe leaking |3.6.A.1| | 1 |
| Offside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Rear Exhaust has a part missing |7.1.1a| | 1 |
| Rear fog lamp tell tale missing |1.3.1b| | 1 |
| Nearside Rear Side repeater incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Side repeater incorrect colour |1.4.A.2f| | 1 |
| Nearside Rear Seat belt buckle damaged surround missing (7.1.2 (d)) | 1 |
| Stop lamp(s) not working both (4.3.1 (a) (ii)) | 1 |
| Hazard warning lamps not fitted (4.4.1 (d)) | 1 |
| Rear Exhaust silencer likely to become detached pipe detatched from silencer (8.1.1 (b) (ii)) | 1 |
| Emissions not tested (8.2.1.2 (d)) | 1 |
| Rear fog lamp switch faulty |1.3.1a| | 1 |
| Emissions not tested |8.2.1.2 |d|| | 1 |
| Offside Rear fog lamp not visible from a reasonable distance |1.1.6b| | 1 |
| Nearside Rear fog lamp not visible from a reasonable distance |1.1.6b| | 1 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Side repeater insecure |1.4.A.2b| | 1 |
| Battery insecure and likely to cause a short circuit (4.13 (a) (ii)) | 1 |
| Front Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Rear brake disc excessively pitted |3.5.1h| | 1 |
| Offside Rear Road wheel distorted |4.2.A.1a| | 1 |
| Front passenger door cannot be opened from inside the vehicle |6.2.3 |a|| | 1 |
| Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Offside Outer Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Central Upper Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Rear Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Nearside Rear Exhaust system insecure |6.1.2 |a|| | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Driver`s seat insecure |6.2.A.1| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Offside Front Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Offside Front Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Offside Front Front suspension has excessive play in a track control arm inner bush |2.5.B.2b| | 1 |
| Nearside Front Front suspension has excessive play in a track control arm inner bush |2.5.B.2b| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Rear Exhaust has a major leak of exhaust gases tailpipe |7.1.2| | 1 |
| Nearside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Trailing arm corroded and seriously weakened |2.4.G.1| | 1 |
| Offside Rear Trailing arm corroded and seriously weakened |2.4.G.1| | 1 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Steering rack gaiter split |2.2.D.2d| | 1 |
| Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 1 |
| Offside Rear Anti-roll bar linkage insecure and impairing directional stability (5.3.3 (a) (ii)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Horn control missing |1.6.1| | 1 |
| Exhaust engine idle speed too high |7.3.D.1| | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Fuel system component leaking under bonnet (6.1.3 (b) (i)) | 1 |
| Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Headlamp does not operate immediately when selected on dipped beam |1.7.4a| | 1 |
| Offside Headlamp does not operate immediately when selected on dipped beam |1.7.4a| | 1 |
| Nearside Headlamp does not operate immediately when selected on main beam |1.7.4a| | 1 |
| Offside Headlamp does not operate immediately when selected on main beam |1.7.4a| | 1 |
| Parking brake: efficiency below requirements |3.7.D.4| | 1 |
| Rear position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Side repeater missing |1.4.A.2b| | 1 |
| Nearside Front Lower Suspension arm rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Side repeater not working |1.4.A.2c| | 1 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Seat belt anchorage prescribed area is inadequately repaired |5.2.6| | 1 |
| Offside Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Nearside Rear Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Rear Mechanical brake component has restricted free movement | 1 |
| Front brake disc excessively pitted |3.5.1h| | 1 |
| Offside Front Brake hose bulging under pressure |3.6.B.3| | 1 |
| Nearside Front Brake hose bulging under pressure |3.6.B.3| | 1 |
| Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Service brake is causing the steering wheel to severely pull one way |3.7.C.2| | 1 |
| Front Service brake is causing the steering wheel to severely pull one way |3.7.C.2| | 1 |
| Nearside Front Power steering pipe|s| or hose|s| leaking |2.3.3b| | 1 |
| Hazard warning lamps inoperative |1.4.B.1b| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Front position lamp|s| adversely affected by the operation of another lamp both front side lamps flash with indicators |1.1.A.3f| | 1 |
| Front position lamp|s| incorrect colour must be white unless incorporated in a yellow headlamp |1.1.A.3e| | 1 |
| Rear Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar linkage cracked |2.4.G.1| | 1 |
| Nearside Rear Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Rear Anti-roll bar missing |2.4.G.1| | 1 |
| Nearside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Rear All position lamps adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Direction indicators flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Steering column will not lock in a fixed position |adjustable type| |2.1.2a| | 1 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 1 |
| Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Nearside Inner Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Inner Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |