| Most common failures | No# failures |
|---|
| Brake pipe excessively corroded | 12 |
| Parking brake: efficiency below requirements |3.7.B.7| | 9 |
| Headlamp aim out of alignment | 8 |
| Windscreen wiper does not clear the windscreen effectively | 7 |
| Brakes imbalanced across an axle | 6 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 5 |
| Registration plate issues | 5 |
| Registration plate lamp issues | 4 |
| Battery insecure |1.9.1| | 4 |
| Rear parking brake recording little or no effort | 4 |
| Offside Headlamp not working on main beam |1.7.5a| | 4 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 3 |
| Offside Rear fog lamp missing |1.3.2a| | 3 |
| Service brake: efficiency below requirements |3.7.B.7| | 3 |
| Rear fog lamp not working |1.3.2b| | 3 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 3 |
| Offside Rear fog lamp not working |1.3.2b| | 2 |
| Centre Stop lamp not working |1.2.1b| | 2 |
| Driver`s seat cannot be secured in the upright position. |6.2.A.2| | 2 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Horn not working |1.6.2a| | 2 |
| Exhaust noise is clearly in excess of that emitted by a similar vehicle fitted with a standard silencer in average condition |7.1.4| | 2 |
| Rear Exhaust system not adequately supported |7.1.1| | 2 |
| Emissions not tested |7.0| | 2 |
| Brake performance not tested |3.7.A.1| | 2 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 2 |
| Nearside Front position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 2 |
| Offside Front position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 2 |
| Nearside Front position lamp|s| incorrect colour |1.1.A.3e| | 2 |
| Offside Front position lamp|s| incorrect colour |1.1.A.3e| | 2 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Parking brake lever has no reserve travel |3.1.6b| | 2 |
| Windscreen washer not working | 2 |
| Offside Rear Parking brake inoperative on one side R H |1.4.1 |a|| | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect L H |4.1.2 |c|| | 1 |
| Nearside Headlamp not working on main beam L H |4.1.1 |a| |ii|| | 1 |
| Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Exhaust emissions carbon monoxide content excessive |8.2.1.2 |b|| | 1 |
| Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
| Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Headlamp does not operate immediately when selected on dipped beam |1.7.4a| | 1 |
| Headlamp aim not tested |1.8.A.1c| | 1 |
| Nearside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
| Offside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
| Emissions not tested engine misfiring on a couple of cylinders |7.3.A.1| | 1 |
| Passenger`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Steering box has relative movement between sector shaft and the drop arm |2.2.B.1b| | 1 |
| Nearside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Outer Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Drivers seat insecure (6.2.5 (a) (ii)) | 1 |
| Offside Front Passengers seat insecure (6.2.6 (a) (ii)) | 1 |
| Rear Rear reflector missing (4.8.2 (a) (ii)) | 1 |
| Nearside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Nearside Rear Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Offside Rear Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Brake performance not tested (1.2.1 (g)) | 1 |
| Nearside Rear wheel cylinder leaking |3.6.A.1| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings inner sill |6.1.B.2| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings inner sill/floor |6.1.B.2| | 1 |
| Offside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced inner sill (6.1.1 (c) (i)) | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength lower firewall (5.3.6 (a) (i)) | 1 |
| Nearside Front Road wheel fixing missing (5.2.1 (a) (i)) | 1 |
| All position lamps not working |1.1.A.3b| | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Rear Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Body panel damaged and likely to cause injury wing sharp edges (6.2.1 (a) (i)) | 1 |
| Emissions not tested soooting machine up (8.2.1.2 (d)) | 1 |
| Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Nearside Front Brake hose bulging under pressure (1.1.12 (d)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength strut tower front/rear (5.3.6 (a) (i)) | 1 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Nearside Front coil spring broken |2.4.C.1a| | 1 |
| Headlamp does not operate immediately when selected on dipped beam |1.7.4a| | 1 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Centre Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Front brake application uneven | 1 |
| front brakes release unevenly |3.7.B.4| | 1 |
| Nearside Rear Service brake grabbing severely |3.7.C.2| | 1 |
| Offside Rear Service brake grabbing severely |3.7.C.2| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Headlamp not in good working order |not working| |1.2.4a| | 1 |
| Offside Rear Rear fog lamp missing |1.3.2a| | 1 |
| Rear Exhaust has a part missing |7.1.1a| | 1 |
| Nearside Front Upper Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Exhaust emits dense blue smoke at idle |7.3.A.2b| | 1 |
| Steering column top bearing excessively worn |2.1.2c| | 1 |
| Nearside Rear Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Rear reflector missing |1.5.1a| | 1 |
| Offside Rear reflector missing |1.5.1a| | 1 |
| Nearside Front front brake binding |3.7.B.1| | 1 |
| Front Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Driver`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Offside Front passenger seat cannot be secured in the upright position. |6.2.4| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Rear fog lamp switch missing |1.3.1a| | 1 |
| Nearside Front Direction indicator excessively damaged so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
| Offside Front Direction indicator excessively damaged so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
| Nearside Headlamp incorrect colour |1.7.5b| | 1 |
| Offside Headlamp incorrect colour |1.7.5b| | 1 |
| Offside front brake recording little or no effort |3.7.B.5a| | 1 |
| Offside front brakes release unevenly |3.7.B.4| | 1 |
| Offside front brake grabbing severely |3.7.A.2b| | 1 |
| Service brake is causing the steering wheel to severely pull one way |3.7.C.2| | 1 |
| Mechanical brake component has restricted free movement | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Rear Rear fog lamp missing |1.3.2a| | 1 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Front Anti-roll bar rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Rear Stop lamp missing |1.2.1a| | 1 |
| Nearside Inner Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Side repeater missing |1.4.A.2b| | 1 |
| Rear fog lamp missing |1.3.2a| | 1 |
| Anti-roll bar linkage fractured |2.4.G.1| | 1 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front Steering system has a road wheel fouling a part of the vehicle |2.2.D.2a| | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Seat belt anchorage prescribed area strength or continuity significantly reduced floor (7.1.1 (a) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill (5.3.6 (a) (i)) | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Headlamp not in good working order |not working| |1.2.4a| | 1 |
| Offside Headlamp not in good working order |not working| |1.2.4a| | 1 |
| Nearside Rear Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Offside Front coil spring fractured |2.4.C.1a| | 1 |
| Nearside Front coil spring cracked |2.4.C.1a| | 1 |
| Nearside Obligatory mirror not clearly visible from the drivers seat or incapable of being adjusted to be clearly visible from the driver`s seat |8.1.1d| | 1 |
| Rear Side repeater missing |1.4.A.2b| | 1 |
| Front Side repeater missing |1.4.A.2b| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Horn not working |7.7 |a| |ii|| | 1 |
| Offside Front Passenger`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Front Headlamp aim beam image kick up to the offside both head lights |1.8| | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Drivers seat backrest cannot be secured in the upright position. (6.2.5 (b) (ii)) | 1 |
| Passengers seat backrest cannot be secured in the upright position. (6.2.6 (a) (i)) | 1 |
| Nearside Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced Inner sill holed (6.1.1 (c) (i)) | 1 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Rear Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Nearside Rear Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Rear Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Exhaust carbon monoxide content at idle exceeds default limits |8.2.1.2 |b|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Nearside Front Headlamp levelling device obviously defective |1.7.2| | 1 |
| Brake pedal spongy |3.3.B.1b| | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |