| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 63 |
| Headlamp aim out of alignment | 47 |
| Registration plate lamp issues | 27 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 13 |
| Anti-lock braking system warning lamp indicates an ABS fault | 11 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 6 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 5 |
| Offside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 5 |
| Windscreen washer not working | 5 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 4 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 4 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 4 |
| Nearside Rear Outline marker lamp not working (4.2.1 (a) (ii)) | 4 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 4 |
| Engine MIL inoperative or indicates a malfunction (8.2.2.2 (g)) | 4 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 4 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 3 |
| Nearside Rear Direction indicator incorrect colour (4.4.3 (a)) | 3 |
| Nearside Front Shock absorbers has a serious fluid leak | 3 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 3 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 3 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 3 |
| Offside Rear Upper Outline marker lamp not working (4.2.1 (a) (ii)) | 3 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 3 |
| Offside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 3 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 2 |
| Brakes imbalanced across an axle | 2 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 2 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 2 |
| Nearside Rear Service brake excessively binding |1.2.1 |f|| | 2 |
| Nearside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 2 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 2 |
| Offside Rear Stop lamp not working |1.2.1b| | 2 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
| Offside Side repeater not working |1.4.A.2c| | 2 |
| Nearside Stop lamp|s| not working |4.3.1 |a| |ii|| | 2 |
| Offside Rear fog lamp not working |1.3.2b| | 2 |
| Offside Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 2 |
| Offside Front Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 2 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 2 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Offside Rear Direction indicator incorrect colour (4.4.3 (a)) | 2 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
| Nearside Headlamp aim not tested (4.1.2 (b)) | 2 |
| Exhaust emissions exceed manufacturers specified limit (8.2.2.2 (a)) | 2 |
| Offside Rear Direction indicator not working (4.4.1 (a) (ii)) | 2 |
| Offside Outline marker lamp not working (4.2.1 (a) (ii)) | 2 |
| Nearside Outline marker lamp not working (4.2.1 (a) (ii)) | 2 |
| Offside Front Lower Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
| Offside Front Shock absorbers has a serious fluid leak | 2 |
| Nearside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 2 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 2 |
| Nearside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
| Brake pipe excessively corroded | 2 |
| Front Service brake excessively fluctuating (1.2.1 (e)) | 2 |
| Offside Rear Upper Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Suspension has inadequate clearance with the bump stop |2.4.A.1a| | 1 |
| Offside Rear Suspension has inadequate clearance with the bump stop |2.4.A.1a| | 1 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Fuel system component leaking fuel filter housing |7.2.3| | 1 |
| Offside Rear Upper Outline marker lamp showing red light to the front |4.2.3 |a| |ii|| | 1 |
| Offside Rear Upper Outline marker lamp showing white light to the rear |4.2.3 |a| |ii|| | 1 |
| Nearside Rear Outline marker lamp not working |4.2.1 |a|| | 1 |
| Offside Rear Outline marker lamp not working |4.2.1 |a|| | 1 |
| Trailer electrical socket |13 pin| not operating the trailer lamps as intended fog lamp |1.9.4| | 1 |
| Brake fluid significantly below minimum mark |1.1.10 |d| |ii|| | 1 |
| Horn not working |7.7 |a| |ii|| | 1 |
| Exhaust system insecure |6.1.2 |a|| | 1 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 1 |
| Horn not working |1.6.2a| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Upper Outline marker lamp not working |4.2.1 |a| |ii|| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Nearside Rear Upper Position lamp not working side |4.2.1 |a|| | 1 |
| Nearside Rear Direction indicator incorrect colour |4.4.3 |a|| | 1 |
| Offside Rear Direction indicator incorrect colour |4.4.3 |a|| | 1 |
| Offside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Nearside Rear Lower Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| All outline marker lamps not working |4.2.1 |a|| | 1 |
| Offside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
| Exhaust emissions exceed manufacturer`s specified limit |8.2.2.2 |a|| | 1 |
| Centre Stop lamp not working |1.2.1b| | 1 |
| Fuel tank leaking |7.2.3| | 1 |
| Offside Front Front position lamp|s| not working side light |1.1.A.3b| | 1 |
| Nearside Rear All position lamps adversely affected by the operation of another lamp |4.2.3 |c|| | 1 |
| Offside Rear All position lamps adversely affected by the operation of another lamp |4.2.3 |c|| | 1 |
| Nearside Rear Seat belt flexible stalk damaged likely to lead to failure under load |5.2.4a| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Nearside Rear Bumper damaged and likely to cause injury when grazed or contacted |6.1.4 |a| |i|| | 1 |
| Offside Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Front Braking system leaking NSF fluid leak from ABS control unit /Pump |3.6.A.1| | 1 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Nearside Front Electrical wiring connectors for braking disconnected |4.11 |a| |iii|| | 1 |
| Offside Rear Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Offside Front Position lamp not working |4.2.1 |a|| | 1 |
| Supplementary restraint system warning lamp indicates a fault |7.1.6 |a|| | 1 |
| Electronic stability system warning lamp indicates a fault |3.4.1c| | 1 |
| Nearside rear parking |secondary| brake grabbing severely |3.7.B.6b| | 1 |
| Nearside Fuel system component defective in the case of LPG/CNG/ LNG or hydrogen systems |6.1.3 |f|| | 1 |
| Offside Rear Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Offside Rear Brake cable has restricted free movement |1.1.15 |e|| | 1 |
| Front position lamp|s| adversely affected by the operation of another lamp passenger front |1.1.A.3f| | 1 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 1 |
| Nearside Front Obligatory mirror seriously obscured affecting the rear view |8.1.2a| | 1 |
| Nearside Front Obligatory mirror insecure |8.1.1| | 1 |
| Emissions not tested dipstick broken unable to check oil |8.2.2.2 |e|| | 1 |
| Offside Front Upper Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Offside Rear Hydraulic brake calliper leaking |1.1.16 |b| |i|| | 1 |
| Offside Front Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Nearside Front Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Nearside Front Body has a sharp edge caused by damage door mirror |6.1.C.1| | 1 |
| Fuel pipe union leaking |6.1.3 |b| |i|| | 1 |
| Nearside Headlamp levelling device inoperative |4.1.5 |a|| | 1 |
| Offside Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Nearside Front Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Offside Front Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Headlamp aim not tested |4.1.2 |b|| | 1 |
| Front Exhaust has a major leak of exhaust gases broken studs where front pipe meets dpf |6.1.2 |a|| | 1 |
| Emissions not tested |8.2.2.2 |e|| | 1 |
| Nearside Front front brake binding Unable to check wheel bearing |3.7.B.1| | 1 |
| Offside Front front brake binding Unable to check wheel bearing |3.7.B.1| | 1 |
| Offside Side repeater not working |4.4.1 |a| |ii|| | 1 |
| Offside Rear Seat belt buckle not functioning as intended |7.1.2 |d|| | 1 |
| Central Exhaust system insecure (6.1.2 (a)) | 1 |
| Central Exhaust silencer likely to become detached rubber (8.1.1 (b) (ii)) | 1 |
| Front Anti-roll bar insecure and impairing directional stability (5.3.3 (a) (ii)) | 1 |
| Nearside Front Valve stem seriously damaged (5.2.3 (j)) | 1 |
| Offside Front Valve stem seriously damaged (5.2.3 (j)) | 1 |
| Nearside Rear Valve stem seriously damaged (5.2.3 (j)) | 1 |
| Nearside Rear Seat belt not functioning as intended passenger rear seat belt not working too much slack in belt (7.1.2 (c)) | 1 |
| Exhaust system insecure (6.1.2 (a)) | 1 |
| Rear Brake cable insecure | 1 |
| Brake performance not tested (1.2.1 (g)) | 1 |
| Brake hose damaged and likely to fail (1.1.12 (a)) | 1 |
| Fuel system component leaking filter housing (6.1.3 (b) (i)) | 1 |
| Nearside All outline marker lamps not working (4.2.1 (a) (ii)) | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Rear Position lamp not working both rear side markers (4.2.1 (a) (ii)) | 1 |
| Offside Rear Direction indicator incorrect colour white light (4.4.3 (a)) | 1 |
| Nearside Front Road wheel fixing missing (5.2.1 (a) (i)) | 1 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Exhaust fumes causing a danger to health of persons on board (6.1.2 (b) (ii)) | 1 |
| Exhaust shield missing where fitted as original equipment creating a risk of fire Exhaust incomplete (6.1.3 (e)) | 1 |
| Nearside All direction indicators not working (4.4.1 (a) (ii)) | 1 |
| Offside Rear Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
| Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Rear Anti-lock braking system wiring excessively damaged area (1.6 (d)) | 1 |
| Brake pedal anti-slip provision missing (1.1.2 (c)) | 1 |
| Offside Body component damaged and likely to cause injury mirror casing (6.2.1 (a) (i)) | 1 |
| Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt clip (6.1.7 (g) (ii)) | 1 |
| Fuel system component leaking night heater fuel pump beside front subframe (6.1.3 (b) (i)) | 1 |
| Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Exhaust emits excessive smoke or vapour likely to obscure the vision of other road users (8.2.2.2 (c)) | 1 |
| Exhaust emissions exceed default limit of 1.5m-1 (8.2.2.2 (b)) | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Headlamp aim not tested (4.1.2 (b)) | 1 |
| Offside Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Rear Upper Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
| Stop lamp(s) remains on when the brakes are released all rear brake lights staying on (4.3.2 (a) (iii)) | 1 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Side repeater incorrect colour (4.4.3 (a)) | 1 |
| Nearside Front All direction indicators incorrect colour (4.4.3 (a)) | 1 |
| Offside Front All direction indicators incorrect colour (4.4.3 (a)) | 1 |
| Nearside Direction indicator incorrect colour repeater (4.4.3 (a)) | 1 |
| Supplementary restraint system warning lamp indicates a fault light on dash (7.1.6 (a)) | 1 |
| Offside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Offside Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Front Suspension arm pin or bush excessively worn lower arm rear bush (5.3.4 (a) (i)) | 1 |
| Offside Front Body component damaged and likely to cause injury offside mirror housing damaged (sharp edges) (6.2.1 (a) (i)) | 1 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Supplementary restraint system warning lamp indicates a fault Air bag warning lamp (7.1.6 (a)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Central Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Rear Exhaust system insecure Mount detached (6.1.2 (a)) | 1 |
| Front Outline marker lamp not working both front nsf/osf (4.2.1 (a) (ii)) | 1 |
| Outline marker lamp not working both middle nside and oside (4.2.1 (a) (ii)) | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 1 |
| Rear Exhaust system insecure tail pipe bracket broken (6.1.2 (a)) | 1 |
| Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Front Suspension arm ball joint likely to become detached loose in hub (5.3.4 (a) (ii)) | 1 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt Detaches on lock to lock test (6.1.7 (g) (ii)) | 1 |
| Offside Rear Stop lamp(s) adversely affected by the operation of another lamp (4.3.3 (b)) | 1 |
| Offside Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt insecure (6.1.7 (g) (ii)) | 1 |
| Nearside Front Headlamp levelling device inoperative (4.1.5 (a)) | 1 |
| Offside Front Headlamp levelling device inoperative (4.1.5 (a)) | 1 |
| Offside Front Headlamp has a product on the lens so that the light output is severely reduced (4.1.4 (b)) | 1 |
| Nearside Brake pipe excessively damaged Front to rear (1.1.11 (c)) | 1 |