| Most common failures | No# failures |
|---|
| Registration plate lamp issues | 37 |
| Headlamp aim out of alignment | 27 |
| Horn not working |1.6.2a| | 17 |
| Nearside Stop lamp not working |1.2.1b| | 10 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 9 |
| Windscreen wiper does not clear the windscreen effectively | 9 |
| Brakes imbalanced across an axle | 6 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 5 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 5 |
| Offside Stop lamp not working |1.2.1b| | 5 |
| Offside Rear Stop lamp not working |1.2.1b| | 5 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 5 |
| Brake pipe excessively corroded | 5 |
| Windscreen has damage | 4 |
| Registration plate issues | 4 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 4 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 4 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 4 |
| Nearside Front Side repeater incorrect colour |1.4.A.2f| | 4 |
| Offside Front Side repeater incorrect colour |1.4.A.2f| | 4 |
| Service brake: efficiency below requirements |3.7.B.7| | 3 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 3 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 3 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 3 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 3 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 3 |
| Exhaust carbon monoxide content at idle exceeds manufacturers specified limits (8.2.1.2 (b)) | 3 |
| Nearside Rear Stop lamp not working |1.2.1b| | 3 |
| Exhaust system not adequately supported |7.1.1| | 2 |
| Front brake disc in such a condition that it is seriously weakened | 2 |
| Fuel system component leaking |7.2.3| | 2 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 2 |
| Battery insecure |1.9.1| | 2 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Exhaust carbon monoxide content at idle exceeds default limits (8.2.1.2 (b)) | 2 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Brake pedal anti-slip provision missing (1.1.2 (c)) | 2 |
| Nearside Side repeater incorrect colour |1.4.A.2f| | 2 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 2 |
| Nearside Front Front constant velocity joint gaiter split |2.5.C.1a| | 2 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 2 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 2 |
| Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Brake load sensing valve linkage defective and function impaired spring broken (1.1.17 (a)) | 2 |
| Nearside Rear Direction indicators incorrect colour |1.4.A.2f| | 2 |
| Offside Rear Direction indicators incorrect colour |1.4.A.2f| | 2 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 2 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 2 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Windscreen wiper blade missing |8.2.2| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Offside Rear Braking system leaking |3.6.A.1| | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Windscreen washer not working | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Nearside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Anti-lock braking system warning lamp indicates an ABS fault | 1 |
| Electronic stability control warning lamp indicates a fault (7.12 (e)) | 1 |
| Hazard warning switch inoperative (4.4.2 (a) (ii)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Rear Service brake effort inadequate at a wheel both (1.2.1 (a) (i)) | 1 |
| Exhaust tailpipe not capable of allowing the emission probe to be inserted |7.3.D.1| | 1 |
| Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Nearside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Side repeater incorrect colour (4.4.3 (a)) | 1 |
| Offside Side repeater incorrect colour (4.4.3 (a)) | 1 |
| Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Emissions not tested |7.0| | 1 |
| Horn not working (7.7 (a)) | 1 |
| Offside Front Outer Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Offside Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Power steering pump drive system defective |2.3.6| | 1 |
| Fuel cap/sealing device sealing washer missing |7.2.4c| | 1 |
| Central Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Brake load sensing valve linkage defective and function impaired (1.1.17 (a)) | 1 |
| Nearside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Brake load sensing valve seized and ABS not fitted or inoperative (1.1.17 (c) (ii)) | 1 |
| Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Power steering component|s| leaking |2.3.3b| | 1 |
| Offside Front Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front coil spring broken |2.4.C.1a| | 1 |
| Nearside Passenger`s seat insecure |6.2.A.1| | 1 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 1 |
| Offside Front brake disc excessively pitted |3.5.1h| | 1 |
| An item not tested |Manual| | 1 |
| Rear brake application uneven | 1 |
| Offside Rear Rear position lamp|s| incomplete |1.1.4a| | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Power steering fluid reservoir empty (2.1.5 (b) (ii)) | 1 |
| Nearside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Power steering inoperative (2.1.5 (c) (i)) | 1 |
| Offside Front Bumper insecure (6.1.4 (a) (i)) | 1 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Headlamp levelling device inoperative (4.1.5 (a)) | 1 |
| Brake performance not tested (1.2.1 (g)) | 1 |
| Emissions not tested eml on also exhaust leak (8.2.1.2 (d)) | 1 |
| Fluid leak harmful to the environment or a risk to other road users power steering pipe (8.4.1 (a) (i)) | 1 |
| Spare wheel insecure |6.4.2| | 1 |
| Nearside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Offside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Nearside Body has a sharp edge caused by damage mirror |6.1.C.1| | 1 |
| Nearside Front Side repeater incorrect colour |4.4.3 |a|| | 1 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Engine MIL inoperative or indicates a malfunction |8.2.2.2 |g|| | 1 |
| Supplementary restraint system warning lamp indicates a fault |7.1.6 |a|| | 1 |
| Offside Front Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Offside Front Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 1 |
| Offside Side repeater incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced inner sill (7.1.1 (a) (i)) | 1 |
| Offside Front Upper Macpherson strut top bush or bearing has excessive wear or free play (5.3.4 (a) (i)) | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Brake hose excessively damaged |3.6.B.4d| | 1 |
| Battery insecure and likely to fall from carrier |4.13 |a| |ii|| | 1 |
| Windscreen damaged and affecting the driver`s view of the road |3.2 |a| |ii|| | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Rear Wheel bearing rough when rotated |5.1.3 |b| |i|| | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Nearside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Parking brake: efficiency below requirements |3.7.B.7| | 1 |
| Nearside Inner Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Offside Inner Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Nearside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Brake hose damaged | 1 |
| Central Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Offside Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Indicator switch faulty |1.4.A.1| | 1 |
| Offside Rear Road wheel bead rim badly distorted |4.2.A.1a| | 1 |
| Steering column top bearing excessively worn |2.1.2c| | 1 |
| rear brake recording little or no effort |3.7.B.5a| | 1 |
| Rear Exhaust mounting missing |7.1.1b| | 1 |
| Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front Steering rack insecure |2.2.B.1a| | 1 |
| Power steering pipe|s| or hose|s| leaking from a joint |2.3.3b| | 1 |
| Front Exhaust mounting missing |7.1.1b| | 1 |
| Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Front Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Rear brake binding | 1 |
| Brake load sensing valve defective and function impaired |3.6.E.3| | 1 |
| Nearside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Brake load sensing valve linkage defective and function impaired spring missing (1.1.17 (a)) | 1 |
| Power steering component leaking (2.1.5 (a)) | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |