| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 20 |
| Registration plate lamp issues | 10 |
| Windscreen wiper does not clear the windscreen effectively | 7 |
| Brake pipe excessively corroded | 6 |
| Exhaust system not adequately supported |7.1.1| | 5 |
| Brakes imbalanced across an axle | 5 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 5 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 4 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 4 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
| Rear parking brake recording little or no effort | 4 |
| Nearside Stop lamp not working |1.2.1b| | 4 |
| Battery insecure |1.9.1| | 4 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 3 |
| Horn not working |1.6.2a| | 3 |
| Nearside Front Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 3 |
| Parking brake: efficiency below requirements |3.7.B.7| | 3 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Service brake: efficiency below requirements |3.7.B.7| | 3 |
| Offside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 3 |
| Offside Front Direction indicator not working |1.4.A.2c| | 3 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 2 |
| Offside Rear fog lamp not working |1.3.2b| | 2 |
| Centre Exhaust system not adequately supported |7.1.1| | 2 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 2 |
| Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 2 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner arch |5.3.6 |a| |i|| | 2 |
| Nearside Front Headlamp aim beam image kick up to the offside |1.8| | 2 |
| Offside Front Headlamp aim beam image kick up to the offside |1.8| | 2 |
| Centre Exhaust mounting missing |7.1.1b| | 2 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Offside Headlamp not working on main beam |1.7.5a| | 2 |
| Nearside Side repeater not working |1.4.A.2c| | 2 |
| Fuel system component leaking |7.2.3| | 2 |
| Nearside Front Brake pipe inadequately clipped |3.6.B.1| | 2 |
| Offside Inner Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 2 |
| Front Headlamp aim beam image kick up to the offside |1.8| | 2 |
| Brake hose excessively deteriorated | 2 |
| Rear fog lamp not working |1.3.2b| | 2 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Rear brake binding | 2 |
| Rear Exhaust system not adequately supported |7.1.1| | 2 |
| Rear engine mounting bracket insecure and likely to fail |6.1.D.1b| | 2 |
| Offside Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Main beam `tell-tale` not working |1.7.4c| | 2 |
| Hazard warning lamps inoperative |1.4.B.1b| | 1 |
| Offside Front Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Front Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Brake lever has insufficient reserve travel (1.1.2 (a)) | 1 |
| Nearside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Bonnet cannot be secured in the closed position |8.4.1| | 1 |
| Rear Brake load sensing valve linkage seized |3.6.E.3| | 1 |
| Nearside Rear Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Rear Exhaust mounting missing |7.1.1b| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Offside Front front brake juddering severely |3.7.A.2b| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Headlamp aim not tested |1.8.A.1c| | 1 |
| Nearside Front Side repeater not working |1.4.A.2c| | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Direction indicators adversely affected by the operation of another lamp When dip beam was turned on the indicators stopped functioning, possible due to charging system |1.4.A.2h| | 1 |
| Nearside Rear rear brake excessively fluctuating |3.7.B.3| | 1 |
| Nearside Front Subframe mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Nearside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Front Radius arm attachment bracket/mounting corroded and its strength is seriously reduced |2.4.G.1| | 1 |
| Offside Front Radius arm attachment bracket/mounting corroded and its strength is seriously reduced |2.4.G.1| | 1 |
| Centre Fuel system component insecure |7.2.1| | 1 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Offside Rear Wheel bearing rough when rotated |5.1.3 |b| |i|| | 1 |
| Nearside Front Headlamp insecure |1.7.3| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Nearside Front suspension has a suspension lower ball joint securing nut not locked |2.5.B.1a| | 1 |
| Nearside Front suspension has a suspension lower ball joint securing nut loose |2.5.B.1a| | 1 |
| Offside Front suspension has a suspension lower ball joint securing nut loose |2.5.B.1a| | 1 |
| Nearside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Offside Front Suspension component mounting prescribed area is inadequately repaired (5.3.6 (a) (i)) | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength next to fuel tank (5.3.6 (a) (i)) | 1 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 1 |
| Brake pedal has insufficient reserve travel (1.1.2 (a)) | 1 |
| Front Headlamp incorrect colour |1.7.5b| | 1 |
| Offside Rear Leaf spring anchor bracket corroded and seriously weakened |2.4.B.6d| | 1 |
| Front Headlamp aim beam image kick up to the offside both |1.8| | 1 |
| Front Brake pipe inadequately supported both |3.6.B.1| | 1 |
| Nearside Front Position lamp light intensity significantly reduced (4.2.3 (a) (ii)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect blur (4.1.2 (c)) | 1 |
| Windscreen washer not working | 1 |
| Bonnet cannot be secured in the closed position (3.1 (b) (i)) | 1 |
| Exhaust system insecure all (6.1.2 (a)) | 1 |
| Offside Front Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength arch area (5.3.6 (a) (i)) | 1 |
| Offside Front Macpherson strut corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner arch - top mount area (5.3.6 (a) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength spring hanger - front of 2 (5.3.6 (a) (i)) | 1 |
| Offside Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
| Offside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Brake pedal anti-slip provision worn smooth |3.3.A.1b| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 1 |
| Offside Front brake disc excessively pitted |3.5.1h| | 1 |
| Front Direction indicator flashing less than 60 times a minute |1.4.A.2g| | 1 |
| Windscreen has damage | 1 |
| Emissions not tested |7.0| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Front Braking system leaking |3.6.A.1| | 1 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Offside Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Outer Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Outer Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Exhaust mounting missing |7.1.1b| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Offside Rear Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Rear Upper Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear fog lamp missing |1.3.2a| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Brake load sensing valve seized |3.6.E.3| | 1 |
| Horn sounds harsh or grating |1.6.2e| | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Rear Upper Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Upper Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Direction indicator not working |4.4.1 |a| |ii|| | 1 |
| Nearside Direction indicator not working repeater |4.4.1 |a| |ii|| | 1 |
| Windscreen wiper not working |3.4 |a|| | 1 |
| Central Brake pipe at imminent risk of failure or fracture |1.1.11 |a|| | 1 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced floor x3 |7.1.1 |a| |i|| | 1 |
| Offside Front Subframe mounting prescribed area excessively corroded significantly reducing structural strength inner arch |5.3.6 |a| |i|| | 1 |
| Brake performance not tested central brake pipe |1.2.1 |g|| | 1 |
| Main beam tell-tale not working (4.9.1 (a) (ii)) | 1 |
| Offside Front Suspension component mounting prescribed area is inadequately repaired suspension arm mounting bracket area (5.3.6 (a) (i)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect kickup to offside (4.1.2 (c)) | 1 |
| Position lamp switch allows the rear position lamps to be switched off when the headlamps are on (4.2.2 (a)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect kickup to offside (4.1.2 (c)) | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Offside Headlamp not working on main beam |4.1.1 |a| |ii|| | 1 |
| Brake load sensing valve seized and ABS not fitted or inoperative |1.1.17 |c| |ii|| | 1 |
| Offside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
| Offside Rear Exhaust system insecure (6.1.2 (a)) | 1 |
| Nearside Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
| Lower engine mounting deteriorated resulting in excessive movement |6.1.D.1a| | 1 |
| Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Exhaust emits an excessive level of metered smoke for a non-turbo charged engine |7.4.B.3b| | 1 |
| Nearside Front Lower Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Nearside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front Seat belt damaged sufficient to obstruct correct operation of the belt seat belt will not retract automatically |5.2.2a| | 1 |
| Nearside Front Seat belt flexible stalk deteriorated likely to lead to failure under load stalk and cover insufficient |5.2.4a| | 1 |
| Offside Front Obligatory mirror seriously obscured affecting the rear view |8.1.2a| | 1 |
| Headlamp aim beam image obviously incorrect headlamp aim not met |1.8.A.1b| | 1 |
| Front position lamp|s| not working front upper marker lamps inop |1.1.A.3b| | 1 |
| Nearside Rear position lamp|s| not working upper inop |1.1.A.3b| | 1 |
| brake disc in such a condition that it is seriously weakened both front brake discs corroded |3.5.1i| | 1 |
| Brake load sensing valve seized siezed |3.6.E.3| | 1 |
| Nearside Track rod end loose worn to excess |2.2.B.1d| | 1 |
| Leaf spring eye defective |anchor| both rear of rear spring eye bushes worn ,, n/side and o/side |2.4.B.1b| | 1 |
| Exhaust has a major leak of exhaust gases exhaust gasses leaking from exhaust system excessive |7.1.2| | 1 |
| Exhaust system not adequately supported exhaust not adequitly supported and all areas of exhaust |7.1.1| | 1 |
| Body has a sharp edge caused by damage both rear edge bumpers n/side and o/side showing sharp edges |6.1.C.1| | 1 |
| Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance rear n/side position lamp broken and deteriorated |1.1.A.3d| | 1 |
| Direction indicators not working front right hand flashers not working |1.4.A.2c| | 1 |
| Nearside Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
| Stop lamp not working |1.2.1b| | 1 |
| Direction indicators flashing less than 60 times a minute |1.4.A.2g| | 1 |
| Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Hazard warning tell tale not working correctly |1.4.B.1e| | 1 |
| Offside Rear rear brake juddering severely |3.7.A.5b| | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Headlamp aim not tested (4.1.2 (b)) | 1 |
| Offside Front Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Drive belt excessively worn alternator belt broken and battery light on (6.1.7 (c) (i)) | 1 |
| Offside Front Drivers door cannot be opened from inside the vehicle (6.2.3 (a)) | 1 |
| Exhaust emissions likely to be affected by an exhaust leak |8.2.2.1 |b|| | 1 |
| Emissions not tested |8.2.2.2 |e|| | 1 |
| Offside Rear Upper Stop lamp not working |1.2.1b| | 1 |
| Nearside Stop lamp excessively damaged so that it is not visible from a reasonable distance |1.2.1d| | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Service brake effort inadequate at a wheel both rear (1.2.1 (a) (i)) | 1 |
| Nearside Rear Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Nearside Rear Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Rear fog lamp obviously incorrectly positioned |1.3.2a| | 1 |
| Exhaust emits excessive smoke or vapour of any colour |7.4.B.4| | 1 |