| Most common failures | No# failures |
|---|
| Brake pipe excessively corroded | 13 |
| Windscreen wiper does not clear the windscreen effectively | 9 |
| Service brake: efficiency below requirements |3.7.B.7| | 7 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 7 |
| Brakes imbalanced across an axle | 6 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 6 |
| Exhaust system not adequately supported |7.1.1| | 4 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 3 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 3 |
| Windscreen washer not working | 3 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 3 |
| Offside Rear wheel bearing has excessive play |2.6.2| | 3 |
| Headlamp aim out of alignment | 2 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Offside Upper Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Brake hose excessively deteriorated | 2 |
| Rear brake application uneven | 2 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 2 |
| Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 2 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 2 |
| Rear parking brake recording little or no effort | 2 |
| Drivers door cannot be opened from inside the vehicle (6.2.3 (a)) | 1 |
| Offside Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds manufacturer`s specified limits |8.2.1.2 |a|| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturer`s specified limits |8.2.1.2 |a|| | 1 |
| Exhaust emissions likely to be affected by an induction leak air box broken |8.2.1.1 |b|| | 1 |
| Exhaust catalytic converter obviously modified |8.2.1.1 |a|| | 1 |
| Offside Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Inner Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Power steering malfunctioning |2.3.3a| | 1 |
| Power steering pipe|s| or hose|s| leaking |2.3.3b| | 1 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Nearside Front Brake disc significantly and obviously worn |1.1.14 |a| |i|| | 1 |
| Offside Front Brake disc significantly and obviously worn |1.1.14 |a| |i|| | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds default limits |8.2.1.2 |b|| | 1 |
| Nearside Rear Position lamp not working |4.2.1 |a|| | 1 |
| Offside Stop lamp|s| light intensity significantly reduced |4.3.3 |a| |ii|| | 1 |
| Vehicle structure is damaged, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Exhaust tailpipe not capable of allowing the emission probe to be inserted |7.3.D.1| | 1 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 1 |
| Registration plate issues | 1 |
| Registration plate lamp issues | 1 |
| Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Fuel system component insecure |7.2.1| | 1 |
| Exhaust emits visible black smoke at idle |7.3.A.2b| | 1 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Front Subframe mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Chassis support beam (5.3.6 (a) (i)) | 1 |
| Horn not working (7.7 (a)) | 1 |
| Offside Rear Shock absorbers has a serious fluid leak | 1 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| Nearside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced inner wheel arch (6.1.1 (c) (i)) | 1 |
| Offside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced inner wheel arch (6.1.1 (c) (i)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Brake valve leaking load valve (1.1.7 (d) (i)) | 1 |
| Brake load sensing valve seized and ABS not fitted or inoperative (1.1.17 (c) (ii)) | 1 |
| Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Rear Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Brake lever has insufficient reserve travel (1.1.2 (a)) | 1 |
| Exhaust carbon monoxide content at idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Nearside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt split (6.1.7 (g) (ii)) | 1 |
| Exhaust emissions hydrocarbon content excessive (8.2.1.2 (b)) | 1 |
| Offside Side repeater not working |4.4.1 |a| |ii|| | 1 |
| Battery insecure |1.9.1| | 1 |
| Rear Air suspension supply pipe insecure |2.4.D.3| | 1 |
| Offside rear brake excessively fluctuating |3.7.B.3| | 1 |
| Brake load sensing valve seized |3.6.E.3| | 1 |
| Windscreen has damage | 1 |
| Offside Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
| Offside Seat belt damaged sufficient to significantly weakened the webbing |5.2.2a| | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Parking brake: efficiency below requirements |3.7.B.7| | 1 |
| Nearside Upper Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Rear Leaf spring to axle securing bolt missing |2.4.B.7b| | 1 |
| Offside Rear Leaf spring to axle securing bolt missing |2.4.B.7b| | 1 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Brake load sensing valve linkage defective and function impaired (1.1.17 (a)) | 1 |
| Exhaust has a major leak of exhaust gases silencer & emissions not tested |7.1.2| | 1 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits major exhaust leak |7.3.D.3| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc inner boot |2.5.C.1a| | 1 |
| Central Exhaust system not adequately supported spring mount missing |7.1.1| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Fluid leaking continuously posing a serious risk to road safety lpg fuel pipes leaking on manifold area very dangeous (8.4.1 (a) (ii)) | 1 |
| Offside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Rear brake binding | 1 |
| Offside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Offside Front Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Nearside Front Lower Suspension component mounting prescribed area is excessively corroded inner arch |2.4.A.3| | 1 |
| Nearside Front Braking system leaking |3.6.A.1| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Exhaust system not adequately supported Two mounts missing |7.1.1| | 1 |
| Offside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Rear fog lamp switch insecure |1.3.1a| | 1 |
| Offside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Power steering pipe|s| or hose|s| excessively corroded pump to rack |2.3.2| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded Inner wheel arch |2.4.A.3| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Exhaust carbon monoxide content at idle exceeds manufacturers specified limits (8.2.1.2 (b)) | 1 |
| Exhaust emits excessive dense blue smoke during acceleration (8.2.1.2 (g)) | 1 |
| Exhaust emits dense blue smoke at idle (8.2.1.2 (f)) | 1 |