Most common failures | No# failures |
---|
Registration plate lamp issues | 54 |
Parking brake: efficiency below requirements |3.7.B.7| | 48 |
Windscreen wiper does not clear the windscreen effectively | 43 |
Rear parking brake recording little or no effort | 28 |
Offside Front position lamp|s| not working |1.1.A.3b| | 24 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 20 |
Headlamp aim out of alignment | 17 |
Nearside Front Direction indicator not working |1.4.A.2c| | 10 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 8 |
Rear brake binding | 8 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 6 |
Registration plate issues | 6 |
Front brake disc in such a condition that it is seriously weakened | 5 |
Offside Rear passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 5 |
Offside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 5 |
Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 5 |
Windscreen wiper blade insecure | 5 |
Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 5 |
Nearside Front Front constant velocity joint gaiter split |2.5.C.1a| | 5 |
Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 5 |
Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 4 |
Offside Front Anti-roll bar ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 4 |
Offside Front Direction indicator not working |1.4.A.2c| | 4 |
Offside passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 4 |
Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 4 |
Offside Front Front position lamp|s| not working |1.1.A.3b| | 4 |
Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 4 |
Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 4 |
Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 3 |
Nearside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 3 |
Nearside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 3 |
Centre Exhaust system not adequately supported |7.1.1| | 3 |
Front brake application uneven | 3 |
Parking brake lever has no reserve travel |3.1.6b| | 3 |
Rear Mechanical brake component has restricted free movement | 3 |
Nearside Front Wheel bolt|s| missing |4.2.A.1e| | 2 |
Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
Offside Front Upper Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
Offside Front coil spring broken |2.4.C.1a| | 2 |
Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.A.3| | 2 |
Exhaust system not adequately supported |7.1.1| | 2 |
Offside rear brake recording little or no effort |3.7.B.5a| | 2 |
Parking brake efficiency below requirements |1.4.2 |a| |i|| | 2 |
Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
Offside Front Shock absorber has a serious fluid leak |2.7.3| | 2 |
Nearside Outer Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
Offside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
Offside Front coil spring fractured |2.4.C.1a| | 2 |
Offside Front constant velocity joint is insecure |2.5.C.1b| | 2 |
Offside Front Anti-roll bar ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
Service brake: efficiency below requirements |3.7.B.7| | 2 |
Offside Front Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
Offside Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 2 |
Offside Stop lamp not working |1.2.1b| | 2 |
Nearside Stop lamp not working |1.2.1b| | 2 |
Nearside Front Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
Nearside Front Anti-roll bar ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
Exhaust emissions exceed manufacturer`s specified limit |8.2.2.2 |a|| | 2 |
Parking brake efficiency below requirements (1.4.2 (a) (i)) | 2 |
Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
Offside Side repeater incorrect colour |1.4.A.2f| | 2 |
Nearside Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 2 |
Nearside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
Offside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
Nearside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
Offside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
Offside Rear coil spring fractured |2.4.C.1a| | 2 |
Nearside Front All position lamps not working |1.1.A.3b| | 1 |
Fuel hose insecure |7.2.1| | 1 |
Offside Front Wheel bolt|s| missing |4.2.A.1e| | 1 |
Front Sub-frame attachment bracket/mounting bolt missing |2.4.G.1| | 1 |
Nearside Front Macpherson strut upper support bearing is stiff in operation |2.5.B.1b| | 1 |
Offside Front Macpherson strut upper support bearing is stiff in operation |2.5.B.1b| | 1 |
Parking brake: efficiency below requirements |3.7.D.4| | 1 |
Offside Front Front position lamp|s| insecure |1.1.A.3a| | 1 |
Nearside Rear Stop lamp not working |1.2.1b| | 1 |
Nearside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 1 |
Offside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 1 |
Front Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
Centre Seat belt retracting mechanism defective |5.2.5b| | 1 |
Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Nearside Front Upper Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Horn not working |1.6.2a| | 1 |
Front position lamp|s| not working |1.1.A.3b| | 1 |
Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Front Upper Fuel system component leaking |7.2.3| | 1 |
Offside Rear Stop lamp not working |1.2.1b| | 1 |
Brake pedal anti-slip provision missing |3.3.A.1b| | 1 |
Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
Offside Rear rear parking |secondary| brake grabbing severely |3.7.B.6b| | 1 |
Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
Offside Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Brake hose has insufficient room to move | 1 |
Nearside Upper Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Front Lower Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Nearside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
Offside Front Position lamp not working |4.2.1 |a|| | 1 |
Offside Rear Position lamp not working |4.2.1 |a|| | 1 |
Offside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
Nearside Front Lower Suspension component ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
Offside Front Lower Suspension component ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
Offside Rear coil spring broken |2.4.C.1a| | 1 |
Offside Outer Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
Nearside Outer Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Offside Outer Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Nearside Front constant velocity joint is insecure |2.5.C.1b| | 1 |
Offside Front Electrical wiring damaged and bare wires exposed |1.9.2c| | 1 |
Power steering component|s| leaking |2.3.3b| | 1 |
Brake cable inappropriately repaired |3.5.1n| | 1 |
Offside Rear brake caliper leaking |3.6.A.1| | 1 |
Offside Rear Rear fog lamp emits a light other than red |1.3.2e| | 1 |
Nearside Front Anti-roll bar ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Nearside Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
Nearside Steering rack gaiter split |2.2.D.2d| | 1 |
Offside Front position lamp|s| insecure |1.1.A.3a| | 1 |
Offside Headlamp aim not tested due to incorrect beam image |4.1.2 |b|| | 1 |
Nearside Other passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
Fuel hose leaking into fuel tank (6.1.3 (b) (i)) | 1 |
Offside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
Nearside Rear passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 1 |
Nearside Front Obligatory mirror insecure |8.1.1| | 1 |
Rear fog lamp not working |1.3.2b| | 1 |
Rear Exhaust system not adequately supported |7.1.1| | 1 |
Bonnet retaining device insecure |8.4.2| | 1 |
Seat belt retracting mechanism defective |5.2.5b| | 1 |
Offside Rear fog lamp emits a light other than red |1.3.2e| | 1 |
Nearside Front Lower Ball joint has excessive play |2.2.B.1f| | 1 |
Offside Front Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
Parking brake lever has excessive side play in the pivot and may disengage |3.1.4a| | 1 |
Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Nearside Front Stop lamp not working |1.2.1b| | 1 |
Offside Rear Brake pipe fouled by moving parts |3.6.B.2a| | 1 |
Rear brake disc in such a condition that it is seriously weakened | 1 |
Brakes imbalanced across an axle | 1 |
Nearside Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
Offside Front Anti-roll bar linkage ball joint dust cover insecure so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Rear coil spring broken |2.4.C.1a| | 1 |
Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Nearside Front Direction indicators not in good working order |function impaired| |1.5.A1b| | 1 |
Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
Nearside Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Driver`s door does not latch securely closed |6.2.B.1a| | 1 |
Offside Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Exhaust catalytic converter missing where one was fitted as standard |7.1.3| | 1 |
Emissions not tested |7.4.B.1| | 1 |
Rear rear brake juddering severely |3.7.A.5b| | 1 |
Brake pipe excessively corroded | 1 |
Rear Exhaust has a major leak of exhaust gases back box |7.1.2| | 1 |
Nearside Front Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings inner sill |6.1.B.2| | 1 |
Nearside Front Ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Front Front drive shaft coupling flexible rubber or fabric coupling unit severely cracked clip needed |2.5.C.1d| | 1 |
Fuel pipe leaking |7.2.3| | 1 |
Offside Front Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
Offside Rear Driver`s door cannot be opened from outside the vehicle |6.2.3 |a|| | 1 |
Fluid leak harmful to the environment or a risk to other road users |8.4.1 |a| |i|| | 1 |
Nearside Front Drive shaft flexible coupling excessively deteriorated clip not working |6.1.7 |d| |i|| | 1 |
Offside Front Service brake excessively binding |1.2.1 |f|| | 1 |
Offside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced inner and outer sill |6.1.1 |c| |i|| | 1 |
Offside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced inner sill may clean up |6.1.1 |c| |i|| | 1 |
Offside Front Upper Anti-roll bar ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Windscreen has damage | 1 |
Nearside Headlamp aim not tested |1.8.A.1c| | 1 |
Emissions not tested |7.0| | 1 |
Front brake excessively fluctuating | 1 |
Fuel cap/sealing device sealing washer missing |7.2.4c| | 1 |
Nearside Headlamp cleaning device obviously defective |1.7.2| | 1 |
Offside Headlamp cleaning device obviously defective |1.7.2| | 1 |
Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
Offside Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
Offside Rear brake caliper has restricted free movement |3.5.1k| | 1 |
Nearside Front Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Nearside Headlamp cleaning device inoperative |1.7.2| | 1 |
Offside Headlamp cleaning device inoperative |1.7.2| | 1 |
Offside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
Offside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
Front Headlamp cleaning device inoperative |1.7.2| | 1 |
Nearside Front Front suspension has excessive movement at a suspension ball joint |2.5.A.1c| | 1 |
Nearside Rear Rear passenger seat cannot be secured in the upright position. |6.2.3| | 1 |
Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
Centre Windscreen is of a temporary type |8.3.1f| | 1 |
Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Offside Front Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
Brake pedal has no servo assistance |3.3.B.2| | 1 |
Rear Seat belt retracting mechanism defective |5.2.5b| | 1 |
Offside Headlamp insecure |1.7.3| | 1 |
Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
Offside Rear Statutory seat belt missing |5.1.1| | 1 |
Offside Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
Offside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
Offside Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
Rear brake application uneven | 1 |
Offside Outer Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
Nearside Front Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Fuel cap/sealing device missing |7.2.4a| | 1 |
Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Offside Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Offside Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Nearside Headlamp aim beam image kick up to the offside |1.8| | 1 |
Offside Headlamp aim beam image kick up to the offside |1.8| | 1 |
Nearside Front brake disc excessively pitted |3.5.1h| | 1 |
Offside Front brake disc excessively pitted |3.5.1h| | 1 |
Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
Offside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
Nearside Front Headlamps matched pair are incorrectly positioned |1.7.3| | 1 |
Offside Front Headlamps matched pair are incorrectly positioned |1.7.3| | 1 |
Nearside Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Exhaust system not adequately supported |7.1.1| | 1 |
Nearside Rear passenger door cannot be opened from outside the vehicle Sliding door |6.2.B.1c| | 1 |
Exhaust emissions exceed level of metered smoke for a turbo charged engine |8.2.2.2 |b|| | 1 |
Nearside Rear fog lamp does not emit a steady red light |1.3.2e| | 1 |
Nearside Side repeater incorrect colour |1.4.A.2f| | 1 |
Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill |5.3.6 |a| |i|| | 1 |
Offside Rear Brake back plate|s| securing device loose |3.5.1j| | 1 |
Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Nearside Rear Other passenger door cannot be opened from outside the vehicle |6.2.3 |a|| | 1 |
Offside Rear Other passenger door cannot be opened from outside the vehicle |6.2.3 |a|| | 1 |
Offside Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sill |5.3.6 |a| |i|| | 1 |
Offside Front Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Front Ball joint has excessive play |2.2.B.1f| | 1 |