| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 55 |
| Registration plate lamp issues | 42 |
| Anti-lock braking system warning lamp indicates an ABS fault | 27 |
| Windscreen wiper does not clear the windscreen effectively | 25 |
| Parking brake lever has no reserve travel |3.1.6b| | 18 |
| Rear brake binding | 15 |
| Front brake disc in such a condition that it is seriously weakened | 10 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 9 |
| Horn not working |1.6.2a| | 7 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 5 |
| Offside Side repeater not working |1.4.A.2c| | 5 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 5 |
| Parking brake: efficiency below requirements |3.7.B.7| | 4 |
| Driver`s seat insecure |6.2.A.1| | 4 |
| Offside Rear Stop lamp not working |1.2.1b| | 4 |
| Brakes imbalanced across an axle | 4 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 4 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 3 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 3 |
| Offside Side repeater incorrect colour |1.4.A.2f| | 3 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 3 |
| Brake hose damaged | 3 |
| Offside Stop lamp not working |1.2.1b| | 3 |
| Nearside Stop lamp not working |1.2.1b| | 3 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
| Offside Front Driver`s seat insecure |6.2.A.1| | 2 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 2 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
| Offside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 2 |
| Nearside Side repeater not working |1.4.A.2c| | 2 |
| Nearside Rear Stop lamp not working |1.2.1b| | 2 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 2 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Rear brake application uneven | 2 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 2 |
| Nearside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Nearside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
| Electronic stability system warning lamp indicates a fault |3.4.1c| | 2 |
| Nearside Front Passenger`s seat insecure |6.2.A.1| | 1 |
| Offside Upper engine mounting deteriorated resulting in excessive movement |6.1.D.1a| | 1 |
| Electrical wiring insecure engine bay |1.9.2a| | 1 |
| Offside Front Inner Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 1 |
| Offside Front brake disc excessively pitted |3.5.1h| | 1 |
| Fuel cap/sealing device missing |7.2.4a| | 1 |
| Offside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Exhaust noise is clearly in excess of that emitted by a similar vehicle fitted with a standard silencer in average condition |7.1.4| | 1 |
| Nearside Front Direction indicators not working |1.4.A.2c| | 1 |
| Nearside Side repeater incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Headlamp aim beam image obviously incorrect No Beam Pattern . |1.8.A.1b| | 1 |
| Front brake excessively fluctuating | 1 |
| Nearside Front Sub-frame corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Rear brake caliper has restricted free movement |3.5.1k| | 1 |
| Nearside Front Road wheel fixing loose (5.2.1 (a) (i)) | 1 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Side repeater missing |1.4.A.2b| | 1 |
| Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Emissions NOx sensor obviously defective (8.2.1.1 (a)) | 1 |
| Offside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Offside Front Sub-frame corroded and seriously weakened |5.3.3 |b| |i|| | 1 |
| Nearside Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
| Nearside Front Anti-roll bar linkage worn and seriously weakened |2.4.G.1| | 1 |
| Offside Front Anti-roll bar linkage damaged and seriously weakened |2.4.G.1| | 1 |
| Offside Front constant velocity joint is excessively worn |2.5.C.1b| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Brake lever has restricted free movement |3.5.1k| | 1 |
| Nearside Track rod end ball joint dust cover missing |2.2.C.1c| | 1 |
| Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Front Suspension arm ball joint dust cover missing |5.3.4 |b| |ii|| | 1 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Lower Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Rear Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Headlamp aim not tested |1.8.A.1c| | 1 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Front Anti-roll bar ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Rear passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 1 |
| Offside Front Upper Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Brake hose excessively damaged |3.6.B.4d| | 1 |
| Front brake application uneven | 1 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Front Power steering component leaking rack boot (2.1.5 (a)) | 1 |
| Windscreen washer not working | 1 |
| Offside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Hazard warning tell tale not working correctly |1.4.B.1e| | 1 |
| Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Main beam `tell-tale` not working |1.7.4c| | 1 |
| Speedometer cannot be illuminated. |6.7.3| | 1 |
| Headlamp levelling device obviously defective |1.7.2| | 1 |
| Brake hose has insufficient room to move | 1 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Fuel system component insecure |7.2.1| | 1 |
| Offside Front coil spring broken |2.4.C.1a| | 1 |
| Nearside Front Headlamp levelling device obviously defective |1.7.2| | 1 |
| Offside Front Headlamp levelling device obviously defective |1.7.2| | 1 |
| Nearside Rear An item not tested |Manual| | 1 |
| Offside Rear An item not tested |Manual| | 1 |
| Outer Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Offside Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Central Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Exhaust has a major leak of exhaust gases front flex x 2 (6.1.2 (a)) | 1 |
| Emissions unable to be completed (8.2.1.2 (d)) | 1 |
| Front Sub-frame corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Shock absorber has an excessively worn linkage |2.7.4| | 1 |
| brake disc excessively scored |3.5.1h| | 1 |
| Rear Headlamp levelling device obviously defective both leveling sensor mechanisms broken |1.7.2| | 1 |
| Nearside Inner Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Windscreen has damage | 1 |
| Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Side repeater obscured more than 50% |1.4.A.2d| | 1 |
| Registration plate issues | 1 |
| Brake lever has insufficient reserve travel (1.1.2 (a)) | 1 |
| Nearside Headlamp cleaning device inoperative |1.7.2| | 1 |
| Offside Headlamp cleaning device inoperative |1.7.2| | 1 |
| Centre Rear Statutory seat belt missing seatbelt clasp |5.1.1| | 1 |
| Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Headlamp insecure |1.7.3| | 1 |
| Nearside Front Lower Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Nearside Front Lower Ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Front Shock absorber has an excessively worn shock absorber pivot |2.7.4| | 1 |
| Offside Front Shock absorber has an excessively worn shock absorber pivot |2.7.4| | 1 |
| Nearside Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Offside Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Parking brake lever is fouling adjacent parts of the vehicle |3.1.6b| | 1 |
| Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Service brake effort inadequate at a wheel |1.2.1 |a| |i|| | 1 |
| Nearside Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Offside Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Offside Front Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Upper Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 1 |
| Nearside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
| Offside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 1 |
| Offside Inner Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Side repeater lens defective such that the emitted light is adversely affected (4.4.1 (b) (ii)) | 1 |
| Offside Front Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 1 |
| Offside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Inner Steering linkage ball joint worn to the extent there is a serious risk of detachment |2.1.3 |b| |ii|| | 1 |
| Nearside Rear Wheel bolt|s| missing |4.2.A.1e| | 1 |
| Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Stop lamp not working |1.2.1b| | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment |1.1.6 |c|| | 1 |
| Rear brake disc in such a condition that it is seriously weakened | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |