| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 107 |
| Headlamp aim out of alignment | 75 |
| Registration plate lamp issues | 29 |
| Rear Exhaust system not adequately supported |7.1.1| | 20 |
| Rear brake binding | 20 |
| Front brake disc in such a condition that it is seriously weakened | 17 |
| Brakes imbalanced across an axle | 17 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 14 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 13 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 13 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 12 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 12 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 11 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 11 |
| Nearside Stop lamp not working |1.2.1b| | 11 |
| Anti-lock braking system warning lamp indicates an ABS fault | 9 |
| Offside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 9 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 8 |
| Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 8 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 8 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 7 |
| Parking brake: efficiency below requirements |3.7.B.7| | 7 |
| Offside Stop lamp not working |1.2.1b| | 7 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 7 |
| Windscreen washer not working | 7 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 6 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 6 |
| Nearside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 6 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 6 |
| Electronic stability system warning lamp indicates a fault |3.4.1c| | 6 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 6 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 6 |
| Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 6 |
| Rear parking brake recording little or no effort | 6 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 5 |
| Offside Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 5 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 5 |
| Offside Rear Service brake excessively binding |1.2.1 |f|| | 5 |
| Nearside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 5 |
| Stop lamp not working |1.2.1b| | 5 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 5 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 5 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 5 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 5 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 5 |
| Nearside Rear Stop lamp not working |1.2.1b| | 5 |
| Parking brake lever has no reserve travel |3.1.6b| | 5 |
| Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 4 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 4 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 4 |
| Nearside Rear Service brake excessively binding |1.2.1 |f|| | 4 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 4 |
| Offside Front Outer Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 4 |
| Nearside Rear coil spring broken |2.4.C.1a| | 4 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 4 |
| Rear Mechanical brake component has restricted free movement | 4 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 3 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 3 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 3 |
| Offside Front Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 3 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 3 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 3 |
| Offside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 3 |
| Registration plate issues | 3 |
| Exhaust system not adequately supported |7.1.1| | 3 |
| Offside Front Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 3 |
| Brake lever has insufficient reserve travel (1.1.2 (a)) | 3 |
| Offside Rear Stop lamp not working |1.2.1b| | 3 |
| Exhaust system insecure (6.1.2 (a)) | 3 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 3 |
| Nearside Front coil spring broken |2.4.C.1a| | 3 |
| Nearside Front Wheel bolt|s| missing |4.2.A.1e| | 3 |
| Offside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 3 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 3 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 3 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 3 |
| Electronic stability control warning lamp indicates a fault (7.12 (e)) | 3 |
| Offside Front coil spring broken |2.4.C.1a| | 3 |
| Offside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 3 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 3 |
| Offside Headlamp aim not tested (4.1.2 (b)) | 2 |
| Offside Front Suspension arm pin or bush excessively worn rear bush (5.3.4 (a) (i)) | 2 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt insecure (6.1.7 (g) (ii)) | 2 |
| Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 2 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Front Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 2 |
| Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 2 |
| Offside Rear Coil spring fractured or broken |5.3.1 |b| |i|| | 2 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Offside Rear Direction indicator not working |4.4.1 |a| |ii|| | 2 |
| Offside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 2 |
| Offside Rear Position lamp not working |4.2.1 |a|| | 2 |
| Nearside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 2 |
| Nearside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Nearside Rear coil spring fractured |2.4.C.1a| | 2 |
| Nearside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
| Offside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
| Offside Front Wheel bolt|s| missing |4.2.A.1e| | 2 |
| Electronic stability control warning lamp indicates a fault |7.12 |e|| | 2 |
| Horn not working |1.6.2a| | 2 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Offside Rear coil spring broken |2.4.C.1a| | 2 |
| Nearside Front Direction indicator not working (4.4.1 (a) (ii)) | 2 |
| Nearside Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 2 |
| Front brake excessively fluctuating | 2 |
| Nearside Parking brake inoperative on one side |1.4.1 |a|| | 2 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Offside Rear fog lamp not working |1.3.2b| | 2 |
| Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 2 |
| Nearside Front Wheel bearing rough when rotated |5.1.3 |b| |i|| | 2 |
| Nearside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 2 |
| Offside Outer Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Nearside Front Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 2 |
| Offside Front Front constant velocity joint is insecure |2.5.C.1b| | 2 |
| Brake pedal anti-slip provision missing (1.1.2 (c)) | 2 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
| Offside Front Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 2 |
| Nearside Front Front wheel bearing rough when rotated |2.5.A.2| | 2 |
| Offside Rear fog lamp not working |4.5.1 |a| |ii|| | 2 |
| Offside Stop lamp|s| not working |4.3.1 |a| |ii|| | 2 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 2 |
| Nearside Front Outer Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 2 |
| Nearside Front Coil spring fractured or broken |5.3.1 |b| |i|| | 2 |
| Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 2 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Nearside Rear Direction indicator not working |4.4.1 |a| |ii|| | 2 |
| Nearside Front Lower Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 2 |
| Nearside Stop lamp|s| not working |4.3.1 |a| |ii|| | 2 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 2 |