Most common failures | No# failures |
---|
Headlamp aim out of alignment | 32 |
Brakes imbalanced across an axle | 20 |
Rear brake binding | 15 |
Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 14 |
Registration plate lamp issues | 10 |
Windscreen wiper does not clear the windscreen effectively | 9 |
Rear brake application uneven | 8 |
Exhaust has a major leak of exhaust gases |7.1.2| | 7 |
Nearside Steering rack gaiter split |2.2.D.2d| | 6 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 6 |
Front Exhaust has a major leak of exhaust gases |7.1.2| | 6 |
Windscreen washer not working | 6 |
Offside front brake binding |3.7.B.1| | 6 |
Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 5 |
Nearside Front Tie bar/rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 5 |
Hazard warning lamps inoperative |1.4.B.1b| | 4 |
Offside Headlamp not working on dipped beam |1.7.5a| | 4 |
Service brake: efficiency below requirements |3.7.B.7| | 4 |
Rear fog lamp not working |1.3.2b| | 4 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 4 |
Rear Mechanical brake component has restricted free movement | 4 |
Offside Front Tie bar/rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 4 |
Offside Stop lamp not working |1.2.1b| | 4 |
Nearside Headlamp not working on main beam |1.7.5a| | 3 |
Parking brake lever has no reserve travel |3.1.6b| | 3 |
Nearside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
Rear Rear fog lamp not working |1.3.2b| | 3 |
Nearside Rear Stop lamp not working |1.2.1b| | 3 |
Horn not working |1.6.2a| | 3 |
Hazard warning switch faulty |1.4.B.1d| | 3 |
Offside Rear fog lamp not working |1.3.2b| | 3 |
Front brake application uneven | 3 |
Direction indicators not working |1.4.A.2c| | 3 |
Emissions not tested |7.3.A.1| | 3 |
Battery insecure |1.9.1| | 3 |
Nearside Front Steering rack gaiter split |2.2.D.2d| | 3 |
Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 3 |
Offside Steering rack gaiter split |2.2.D.2d| | 3 |
Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Parking brake: efficiency below requirements |3.7.B.7| | 2 |
Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 2 |
Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 2 |
rear brakes release unevenly |3.7.B.4| | 2 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
Nearside Front Direction indicator not working |1.4.A.2c| | 2 |
Offside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 2 |
Nearside Rear wheel bearing rough when rotated |2.6.1| | 2 |
Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
Offside Headlamp aim beam image kick up to the offside |1.8| | 2 |
Nearside Front front brake binding |3.7.B.1| | 2 |
Offside Rear rear brake recording little or no effort |3.7.B.5a| | 2 |
Nearside front brake binding |3.7.B.1| | 2 |
Registration plate issues | 2 |
Horn not working (7.7 (a) (ii)) | 2 |
Offside Rear Brake drum contaminated (1.1.14 (b)) | 2 |
Bonnet cannot be secured in the closed position |8.4.1| | 2 |
Exhaust mounting missing |7.1.1b| | 2 |
Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Offside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 2 |
Hazard warning tell tale not working correctly |1.4.B.1e| | 2 |
Offside Front Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 2 |
Offside Front Direction indicator not working |1.4.A.2c| | 2 |
Fuel pipe leaking |7.2.3| | 2 |
Rear Exhaust system not adequately supported |7.1.1| | 2 |
Brake pedal has insufficient reserve movement |3.3.A.5| | 1 |
Nearside Front Road wheel spigot mounting worn to the extent that wheel is likely to become detached spokes broken (5.2.2 (c) (ii)) | 1 |
Rear parking brake recording little or no effort | 1 |
Steering column universal joint has excessive play |2.1.5| | 1 |
Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Front Sub-frame corroded and seriously weakened |2.4.G.1| | 1 |
Fuel hose leaking |7.2.3| | 1 |
Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Offside Front Lower Suspension arm corroded and seriously weakened |2.4.G.1| | 1 |
Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Rear An item not tested |Manual| | 1 |
Nearside Rear Suspension component mounting prescribed area excessively damaged significantly reducing structural strength chassis leg by mounting (5.3.6 (a) (i)) | 1 |
Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Steering system excessively tight |2.2.D.1| | 1 |
Front Tie bar/rod synthetic bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
Offside Exhaust system not adequately supported |7.1.1| | 1 |
Nearside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
Central Rear Fluid leaking continuously posing a serious risk to road safety hose under panel leaking (8.4.1 (a) (ii)) | 1 |
Fuel system component leaking sender seal |7.2.3| | 1 |
Offside Inner Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Offside Outer Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Fuel tank leaking |7.2.3| | 1 |
Offside Steering rack gaiter insecure |2.2.D.2d| | 1 |
Brake servo leaking |3.6.C.1c| | 1 |
Offside Rear front brake binding |3.7.B.1| | 1 |
Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
Nearside Front position lamp|s| has less than 50% of the light sources illuminating |1.1.A.3b| | 1 |
Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
Rear fog lamp tell tale not working |1.3.1b| | 1 |
Nearside Vehicle structure has a fracture which adversely affects braking or steering |6.1.A.1| | 1 |
Horn sounds harsh or grating |1.6.2e| | 1 |
Offside Rear Braking system leaking |3.6.A.1| | 1 |
Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
Steering system excessively rough |2.2.D.1| | 1 |
Steering column top bearing excessively worn |2.1.2c| | 1 |
Steering pivot point has excessive play |2.2.B.1g| | 1 |
Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
Offside Rear wheel bearing rough when rotated |2.6.1| | 1 |
Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Mechanical brake component has restricted free movement | 1 |
Stop lamp not working |1.2.1b| | 1 |
Direction indicators flashing more than 120 times a minute |1.4.A.2g| | 1 |
Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
Nearside Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
Nearside Passenger`s seat insecure |6.2.A.1| | 1 |
Nearside Front Mechanical brake component locking device insecure lower caliper pin |3.5.1l| | 1 |
Nearside Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
Offside Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
Exhaust system not adequately supported |7.1.1| | 1 |
Nearside Front Suspension rod attachment bracket/mounting insecure (5.3.3 (a) (i)) | 1 |
Nearside Stop lamp not working |1.2.1b| | 1 |
Nearside Front Tie bar/rod synthetic bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Front Tie bar/rod synthetic bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Horn not working |7.7 |a| |ii|| | 1 |
Offside Rear Brake clevis joint has restricted free movement |3.5.1k| | 1 |
Centre Exhaust system not adequately supported |7.1.1| | 1 |
Nearside Rear Suspension arm corroded and seriously weakened |2.4.G.1| | 1 |
Nearside Suspension component mounting prescribed area is excessively corroded front and mid chassis |2.4.A.3| | 1 |
Nearside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
Offside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
Offside Front Brake hose leaking |3.6.A.1| | 1 |
Brake hose damaged | 1 |
Nearside Rear wheel bearing has excessive play |2.6.2| | 1 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Emissions not tested |7.0| | 1 |
Offside Front front brake binding |3.7.B.1| | 1 |
front brake binding |3.7.B.1| | 1 |
Brake performance not tested |3.7.A.1| | 1 |
Service brake: efficiency below requirements |3.7.C.1a| | 1 |
Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
Offside Exhaust mounting missing |7.1.1b| | 1 |
Front Fuel system component leaking (6.1.3 (b) (i)) | 1 |
Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Front Indicator switch faulty |1.4.A.1| | 1 |
Steering wheel has movement relative to the column indicating looseness (2.2.1 (a) (i)) | 1 |
Front passenger door cannot be opened from inside the vehicle |6.2.3 |a|| | 1 |
Front passenger door cannot be opened from outside the vehicle |6.2.3 |a|| | 1 |
Exhaust emissions carbon monoxide content excessive |8.2.1.2 |b|| | 1 |
Offside Front Headlamp does not operate immediately when selected on dipped beam |1.7.4a| | 1 |
Offside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Offside Front position lamp|s| not in good working order |function impaired| |1.1.4a| | 1 |
Offside Rear fog lamp excessively damaged so that it is not visible from a reasonable distance |1.3.2d| | 1 |
Nearside Headlamp insecure |1.7.3| | 1 |
Offside Headlamp insecure |1.7.3| | 1 |
Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Nearside Rear Torsion bar attachment bracket corroded and seriously weakened |2.4.E.4c| | 1 |
Offside Rear Lower Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
Front Position lamp not working both side (4.2.1 (a) (ii)) | 1 |
Rear Position lamp not working both side (4.2.1 (a) (ii)) | 1 |
Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
Front Windscreen wiper not working both side (3.4 (a)) | 1 |
Front Service brake has no recorded effort at a wheel both side (1.2.1 (a) (ii)) | 1 |
Brake performance not tested (1.2.1 (g)) | 1 |
Nearside Front Lower Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
Offside Rear Exhaust system insecure mount broken (6.1.2 (a)) | 1 |
Nearside Front Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Front Direction indicator not working |4.4.1 |a| |ii|| | 1 |
Nearside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
Nearside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced lower face (6.1.1 (c) (i)) | 1 |
Offside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced lower face (6.1.1 (c) (i)) | 1 |
Offside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced outer face (6.1.1 (c) (i)) | 1 |
Nearside Rear Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced lower face (6.1.1 (c) (i)) | 1 |
Nearside Rear Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced outer face, inside wheel arch area (6.1.1 (c) (i)) | 1 |
Nearside Front Position lamp not working |4.2.1 |a| |ii|| | 1 |
Nearside Passenger`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
Nearside Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
Nearside Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
Nearside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Front Track rod end loose |2.2.B.1d| | 1 |
Offside Front Track rod end loose |2.2.B.1d| | 1 |
Exhaust engine idle speed too high |7.3.A.2a| | 1 |
Nearside Rear Upper Tie bar/rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Rear Upper Tie bar/rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Front position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
Offside Rear Front position lamp|s| not in good working order |function impaired| |1.1.4a| | 1 |
Indicator switch faulty |1.4.A.1| | 1 |
Nearside Rear Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Nearside Rear Upper Trailing arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Rear Upper Trailing arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Steering wheel retaining device insecure |2.1.6| | 1 |
Nearside Front position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Nearside Front Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
Offside Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
Offside Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
Service brake is causing the vehicle to swerve to the nearside |3.7.C.2| | 1 |
Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Rear Exhaust has a part missing |7.1.1a| | 1 |
Exhaust noise is clearly in excess of that emitted by a similar vehicle fitted with a standard silencer in average condition |7.1.4| | 1 |
Offside Front Steering rack gaiter insecure |2.2.D.2d| | 1 |