| Most common failures | No# failures |
|---|
| Registration plate lamp issues | 31 |
| Headlamp aim out of alignment | 23 |
| Windscreen wiper does not clear the windscreen effectively | 12 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 9 |
| Brake pipe excessively corroded | 8 |
| Registration plate issues | 7 |
| Fuel tank leaking |7.2.3| | 6 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 6 |
| Offside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 5 |
| Battery insecure |1.9.1| | 5 |
| Parking brake: efficiency below requirements |3.7.B.7| | 5 |
| Rear brake binding | 5 |
| Windscreen washer not working | 4 |
| Offside Rear coil spring fractured |2.4.C.1a| | 4 |
| Offside Front Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 4 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
| Service brake: efficiency below requirements |3.7.B.7| | 4 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 4 |
| Centre Exhaust system not adequately supported |7.1.1| | 4 |
| Horn not working |1.6.2a| | 4 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 3 |
| Exhaust emissions carbon monoxide content excessive |8.2.1.2 |b|| | 3 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Front brake application uneven | 3 |
| Offside Front front brake binding |3.7.B.1| | 3 |
| Brakes imbalanced across an axle | 3 |
| Offside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Rear Exhaust mounting missing |7.1.1b| | 3 |
| Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 3 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 3 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 3 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 3 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Offside front brake binding |3.7.B.1| | 2 |
| Offside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 2 |
| Nearside Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 2 |
| Exhaust system not adequately supported |7.1.1| | 2 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Nearside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Nearside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Rear Mechanical brake component has restricted free movement | 2 |
| Offside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 2 |
| Steering column movement between the shaft and steering wheel |2.1.2b| | 2 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 2 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 2 |
| Offside Front Direction indicator not working |1.4.A.2c| | 2 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 2 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 2 |
| Nearside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Emissions not tested |7.0| | 2 |
| Rear Fuel system component insecure |7.2.1| | 2 |
| All direction indicators not working (4.4.1 (a) (ii)) | 2 |
| Brake pedal has insufficient reserve travel (1.1.2 (a)) | 2 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Fuel pipe leaking |7.2.3| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Direction indicators flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Fuel cap/sealing device sealing washer deteriorated |7.2.4c| | 1 |
| Offside Rear coil spring incomplete |2.4.C.1a| | 1 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Nearside Outer Rear Statutory seat belt missing |5.1.1| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Offside Front Brake pipe twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Rear Coil spring mounting corroded and seriously weakened |2.4.C.3c| | 1 |
| Offside Front Lower Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Outer Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Exhaust system insecure rubber mounts |6.1.2 |a|| | 1 |
| Nearside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced wing-sill area. |7.1.1 |a| |i|| | 1 |
| Offside Seat belt anchorage prescribed area strength or continuity significantly reduced sill-door shut |7.1.1 |a| |i|| | 1 |
| Nearside Front Upper Suspension component mounting prescribed area excessively corroded significantly reducing structural strength strut mount |5.3.6 |a| |i|| | 1 |
| Nearside Front Shock absorbers has a serious fluid leak | 1 |
| Offside Rear Shock absorbers has a serious fluid leak | 1 |
| Offside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Front Shock absorber has negligible damping effect |2.7.5| | 1 |
| Offside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Offside Rear Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Offside Front Braking system leaking |3.6.A.1| | 1 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Offside Rear Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
| Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Headlamp insecure |1.7.3| | 1 |
| Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Nearside Rear Coil spring mounting corroded and seriously weakened |2.4.C.3c| | 1 |
| Nearside Inner Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear fog lamp not working |1.3.2b| | 1 |
| Speedometer cannot be illuminated. |6.7.3| | 1 |
| Offside Front Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Anti-roll bar ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Dipswitch operation does not deflect all main beam headlamps to make them dipped beams (4.1.3 (b)) | 1 |
| Headlamp not working on dipped beam Stuck on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Front Position lamp not working |4.2.1 |a|| | 1 |
| Offside Rear Road wheel fixing missing |5.2.1 |a| |i|| | 1 |
| Headlamp aim not tested (4.1.2 (b)) | 1 |
| Dipswitch does not operate immediately when selected on main beam (4.1.3 (b)) | 1 |
| Offside Outer Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Exhaust emissions carbon monoxide content excessive (7.3.B.1a) | 1 |
| Nearside Rear Anti-roll bar attachment bracket/mounting insecure (2.4.G.1) | 1 |
| Nearside Front Upper Suspension component mounting prescribed area excessively corroded significantly reducing structural strength strut tower (5.3.6 (a) (i)) | 1 |
| Offside Front Upper Suspension component mounting prescribed area excessively corroded significantly reducing structural strength strut tower (5.3.6 (a) (i)) | 1 |
| Offside Front Direction indicator not working (1.4.A.2c) | 1 |
| Nearside Stop lamp not working (1.2.1b) | 1 |
| Nearside Rear Rear position lamp(s) adversely affected by the operation of another lamp (1.1.A.3f) | 1 |
| Fuel cap/sealing device missing |7.2.4a| | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| Centre Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Nearside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Offside Rear coil spring broken |2.4.C.1a| | 1 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Exhaust mounting missing |7.1.1b| | 1 |
| Nearside Inner Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Inner Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Exhaust has a major leak of exhaust gases Both centre boxes (6.1.2 (a)) | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Nearside Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Nearside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
| Offside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
| Nearside Rear Trailing arm corroded and seriously weakened |2.4.G.1| | 1 |
| Offside Rear Trailing arm corroded and seriously weakened |2.4.G.1| | 1 |
| Offside Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
| Parking brake lever ratchet mechanism is broken |3.1.5| | 1 |
| Front passenger seat insecure |6.2.3| | 1 |
| Rear Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Offside Front Direction indicator insecure |1.4.A.2b| | 1 |
| Nearside Rear Brake hose bulging under pressure |3.6.B.3| | 1 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Rear Lower Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Centre Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
| Nearside Rear Lower Coil spring mounting corroded and seriously weakened |2.4.C.3c| | 1 |
| Offside Rear Lower Coil spring mounting corroded and seriously weakened |2.4.C.3c| | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Nearside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Rear Sub-frame rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Sub-frame rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Rear brake disc excessively pitted |3.5.1h| | 1 |
| Front brake disc excessively pitted |3.5.1h| | 1 |
| Inner Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Fuel system component insecure |7.2.1| | 1 |
| Brake master cylinder insecurely mounted |3.6.G.1a| | 1 |
| Nearside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Offside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Steering column will not lock in a fixed position |adjustable type| |2.1.2a| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Front Body or chassis has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Rear brake disc in such a condition that it is seriously weakened | 1 |
| Offside Rear brake disc excessively scored |3.5.1h| | 1 |
| Centre Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Upper Ball joint has excessive play |2.2.B.1f| | 1 |
| Exhaust noise is clearly in excess of that emitted by a similar vehicle fitted with a standard silencer in average condition |7.1.4| | 1 |
| Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 1 |
| Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Windscreen has damage | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Front Position lamp adversely affected by the operation of another lamp LIGHT COME ON WHEN BRAKE PEDDLE ON (4.2.3 (c)) | 1 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Rear fog lamp obviously incorrectly positioned FITTED TO N./S./ REAR (4.5.4 (a)) | 1 |
| Horn not working (7.7 (a)) | 1 |
| Steering wheel rim loose (2.2.1 (c) (i)) | 1 |
| Oil leaking excessively from transmission OIL COOLER PIPE AT REAR OF GEAR BOX (8.4.1 (a) (i)) | 1 |
| Offside Rear Rear position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Rear Stop lamp excessively damaged so that it is not visible from a reasonable distance |1.2.1d| | 1 |
| Fuel pipe insecure BOTH FRONT TO REAR (6.1.3 (a) (i)) | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Offside Front Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
| Offside Front Headlamp not working on dipped beam OUT WHEN MAIN BEAM PUT ON (4.1.1 (a) (ii)) | 1 |
| Nearside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced THE REAR OF THE ENGINE BED HOLED (6.1.1 (c) (i)) | 1 |
| Offside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced THE REAR OF THE ENGINE BED HOLED (6.1.1 (c) (i)) | 1 |
| Offside Front Inner Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced WING TO THE REAR OF THE STRUT TOP (6.1.1 (c) (i)) | 1 |
| Offside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Anti-roll bar attachment bracket/mounting nut missing |2.4.G.1| | 1 |
| Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Anti-roll bar attachment bracket/mounting corroded and its strength is seriously reduced |2.4.G.1| | 1 |
| front brake binding |3.7.B.1| | 1 |
| All position lamps adversely affected by the operation of another lamp when indicators are on |1.1.A.3f| | 1 |
| Offside Front Lower Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Front Suspension component mounting prescribed area is corroded to the extent that control of the vehicle is likely to be adversely affected anti roll bar mounting (5.3.6 (a) (ii)) | 1 |
| Offside Front Subframe mounting prescribed area is corroded to the extent that control of the vehicle is likely to be adversely affected behind front mounting (5.3.6 (a) (ii)) | 1 |
| Nearside Rear Suspension component mounting prescribed area is corroded to the extent that control of the vehicle is likely to be adversely affected outer sill area (5.3.6 (a) (ii)) | 1 |
| Front Windscreen wiper blade missing both (3.4 (b) (ii)) | 1 |
| Nearside Rear Stop lamp(s) adversely affected by the operation of another lamp (4.3.3 (b)) | 1 |
| Offside Rear Stop lamp(s) adversely affected by the operation of another lamp come on when side lights switched on (4.3.3 (b)) | 1 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Brake performance not tested due to spongy brake pedal (1.2.1 (g)) | 1 |
| Nearside Rear Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Offside Front Headlamp insecure |1.7.3| | 1 |
| Nearside Front Upper Anti-roll bar linkage fractured (5.3.3 (b) (ii)) | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Rear Direction indicator flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Offside Rear Direction indicator flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Front Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Front Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Rear brake disc excessively pitted |3.5.1h| | 1 |
| Rear brake application uneven | 1 |
| Front Suspension spring mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Nearside Front Anti-roll bar attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Front wheel bearing has excessive play |2.5.A.3c| | 1 |