Most common failures | No# failures |
---|
Registration plate lamp issues | 27 |
Windscreen wiper does not clear the windscreen effectively | 23 |
Headlamp aim out of alignment | 14 |
Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 8 |
Parking brake: efficiency below requirements |3.7.B.7| | 7 |
Rear parking brake recording little or no effort | 6 |
Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 6 |
Offside Rear fog lamp not working |1.3.2b| | 5 |
Offside Headlamp not working on dipped beam |1.7.5a| | 5 |
Centre Exhaust has a major leak of exhaust gases |7.1.2| | 5 |
Registration plate issues | 4 |
Offside Front coil spring incomplete |2.4.C.1a| | 4 |
Brakes imbalanced across an axle | 4 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 4 |
Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 4 |
Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 3 |
Nearside Front Headlamp not working on dipped beam |1.7.5a| | 3 |
Nearside Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 3 |
Offside Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 3 |
Nearside Headlamp insecure |1.7.3| | 3 |
Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 3 |
Offside Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 3 |
Offside Outer Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 3 |
Windscreen has damage | 3 |
Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 3 |
Rear Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
Battery insecure |1.9.1| | 3 |
Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
Nearside Headlamp aim beam image kick up to the offside |1.8| | 2 |
Offside Headlamp aim beam image kick up to the offside |1.8| | 2 |
Offside Front coil spring broken |2.4.C.1a| | 2 |
Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 2 |
Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 2 |
Nearside Rear Brake cable has wires broken and is significantly weakened |3.5.1b| | 2 |
Nearside Front coil spring incomplete |2.4.C.1a| | 2 |
Offside Front coil spring fractured |2.4.C.1a| | 2 |
Parking brake lever has no reserve travel |3.1.6b| | 2 |
Offside Front Anti-roll bar ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
Brake pipe excessively corroded | 2 |
Offside Outer Front constant velocity joint is insecure |2.5.C.1b| | 2 |
Nearside Inner Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
Rear Exhaust system not adequately supported |7.1.1| | 2 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
Offside Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
Offside Stop lamp not working |1.2.1b| | 2 |
Nearside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 2 |
Nearside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
Offside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
Nearside Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
Nearside Outer Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
Offside Rear fog lamp missing |1.3.2a| | 2 |
Nearside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 2 |
Nearside Front Front constant velocity joint is insecure |2.5.C.1b| | 2 |
Nearside Rear Coil spring fractured or broken |5.3.1 |b| |i|| | 2 |
Offside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Front Anti-roll bar linkage ball joint excessively worn both |5.3.4 |a| |i|| | 1 |
Offside Front Lower Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
Nearside Front Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
Nearside Direction indicator incorrect colour |1.4.A.2f| | 1 |
Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Offside Front Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
Nearside Front Inner Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt insecure (6.1.7 (g) (ii)) | 1 |
Nearside Front Headlamp aim not tested |1.8.A.1c| | 1 |
Offside Rear Rear fog lamp obviously incorrectly positioned |1.3.2a| | 1 |
Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
Battery insecure and likely to cause a short circuit |4.13 |a| |ii|| | 1 |
Nearside Front Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 1 |
Offside Front Upper Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 1 |
Nearside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
Offside Rear Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
Nearside Front Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
Offside Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
Offside Outer Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Front Anti-roll bar ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Nearside Front Front drive shaft coupling flexible rubber or fabric coupling softened by oil contamination |2.5.C.1e| | 1 |
Rear Mechanical brake component has restricted free movement | 1 |
Front Front position lamp|s| not working both |1.1.A.3b| | 1 |
Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Front Anti-roll bar linkage worn and seriously weakened |2.4.G.1| | 1 |
Nearside Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 1 |
Centre Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
Rear Exhaust has a part missing |7.1.1a| | 1 |
Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Offside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
Offside Rear Position lamp not working |4.2.1 |a|| | 1 |
Offside Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Offside Lower Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Anti-lock braking system warning lamp indicates an ABS fault | 1 |
Nearside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Offside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Horn not working |1.6.2a| | 1 |
Offside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
Parking brake lever has excessive movement indicating incorrect adjustment |1.1.6 |c|| | 1 |
Exhaust emissions likely to be affected by an exhaust leak mid box |8.2.1.1 |b|| | 1 |
Offside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 1 |
Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 1 |
Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
Offside Rear Brake cable damaged (1.1.15 (a)) | 1 |
Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
Offside Rear Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
Front Steering rack damaged and unserviceable |2.2.C.1d| | 1 |
Nearside Front Lower Bonded suspension unit deteriorated and cannot function as intended |2.4.F.3| | 1 |
Offside Front Macpherson strut has excessive movement at the upper attachment |2.5.A.1c| | 1 |
Rear Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Emissions not tested emission not passed |7.3.A.1| | 1 |
Nearside Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Offside Front Hazard warning lamps inoperative |1.4.B.1b| | 1 |
Offside Rear Hazard warning lamps inoperative |1.4.B.1b| | 1 |
Offside Side repeater not working |1.4.A.2c| | 1 |
Offside Front Direction indicator not working |1.4.A.2c| | 1 |
Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
Offside Front Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
Nearside Headlamp not working on main beam |1.7.5a| | 1 |
Offside Brake cable damaged (1.1.15 (a)) | 1 |
Central Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Offside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
Offside Front Front constant velocity joint is insecure |2.5.C.1b| | 1 |
Offside Outer Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
Nearside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Offside Obligatory mirror seriously obscured affecting the rear view |8.1.2a| | 1 |
Offside Front position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
Offside Rear coil spring broken |2.4.C.1a| | 1 |
Centre Exhaust has a major leak of exhaust gases silencer |7.1.2| | 1 |
Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 1 |
Offside Front constant velocity joint is excessively worn |2.5.C.1b| | 1 |
Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
Rear brake binding | 1 |
Nearside Inner Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Nearside Front Steering rack gaiter insecure |2.2.D.2d| | 1 |
Offside Front Steering rack gaiter insecure |2.2.D.2d| | 1 |
Nearside Front Upper Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
Offside Lower Anti-roll bar linkage ball joint dust cover missing |2.4.G.2| | 1 |
Offside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
Steering rack damaged and unserviceable |2.2.C.1d| | 1 |
Stop lamp not working |1.2.1b| | 1 |
Nearside Rear Stop lamp not working |1.2.1b| | 1 |
Offside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
Nearside Headlamp aim not tested |1.8.A.1c| | 1 |
Nearside Front Upper Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Nearside Front Lower Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Front Upper Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Front Lower Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Rear Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Offside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 1 |
Offside Rear Stop lamp not working |1.2.1b| | 1 |
Nearside Front Outer Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Nearside Front Inner Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Offside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
Nearside Front Anti-roll bar ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Rear brake application uneven | 1 |
Front Headlamp not working on main beam both |1.7.5a| | 1 |
Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
Sub-frame corroded and seriously weakened |5.3.3 |b| |i|| | 1 |
Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
Nearside Inner Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Nearside Front Lower Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Steering column movement between the shaft and steering wheel |2.1.2b| | 1 |
Nearside Front coil spring broken |2.4.C.1a| | 1 |
Nearside Stop lamp not working |1.2.1b| | 1 |
Offside Front Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
Offside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
Rear fog lamp not working |1.3.2b| | 1 |
Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Offside Headlamp light intensity severely reduced |4.1.4 |a|| | 1 |
Nearside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
Front Lower Suspension arm ball joint excessively worn n/s and o/s |5.3.4 |a| |i|| | 1 |
Steering rack has excessive free play detected at the steering wheel |steering rack fitted| play in n/s inner steering rack joint |2.3 |a| |i|| | 1 |
Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |